NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
1,468 reportsClear category filter7,700 miles · Jan 31, 2015
Power TrainVehicle Speed Control
WHILE DRIVING ON FLAT TERRAIN AT A CONSTANT HIGHWAY SPEED THE CAR SUDDENLY DECELERATED FOR A FEW SECONDS WITH THE TACHOMETER NEEDLE SWAYING BACK AND FORTH AND THEN RETURNED TO NORMAL OPERATION. THIS RECURRED 5 MINUTES LATER. THE DEALER INDICATED THAT IT WAS A TRANSMISSION SOFTWARE PROBLEM AND LOADED THE LATEST SOFTWARE RELEASE…
Read full complaint
WHILE DRIVING ON FLAT TERRAIN AT A CONSTANT HIGHWAY SPEED THE CAR SUDDENLY DECELERATED FOR A FEW SECONDS WITH THE TACHOMETER NEEDLE SWAYING BACK AND FORTH AND THEN RETURNED TO NORMAL OPERATION. THIS RECURRED 5 MINUTES LATER. THE DEALER INDICATED THAT IT WAS A TRANSMISSION SOFTWARE PROBLEM AND LOADED THE LATEST SOFTWARE RELEASE. TWO WEEKS LATER THE PROBLEM OCCURRED AGAIN. *TR
NHTSA ODI #10680127
7,200 miles · Jan 23, 2015
Power Train
DRIVING ON LOCAL STREET ABOUT 25 MPH WHEN SERVICE TRANSMISSION WARNING COMES ON. VEHICLE WOULD NOT SHIFT BEYOND 2ND GEAR, TRANSMISSION BEGAN SLIPPING AND EVENTUALLY WOULD ONLY SHIFT INTO DRIVE OR REVERSE AFTER DELAYS OF ABOUT TEN SECONDS. VEHICLE NEEDED TO BE TOWED IN TO DEALER. *TR
NHTSA ODI #10678657
300 miles · Jan 22, 2015
Power Train
I BOUGHT THIS 2014 JEEP CHEROKEE SPORT IN AUGUST 2014. IT HAD APPROX. 300 MILES ON IT. NOTICED A STRONG "SHIMMY" IN THE JEEP AFTER IT SHIFTS TO 2ND GEAR. THE SHIMMY GOES AWAY AFTER INCREASED SPEED. TOOK IT TO THE DEALER AND THE TECH DROVE IT AND NOTICED THE SHIMMY ALSO. HE CHECKED FOR ANY SBS. CHRYSLER SAID TO REPLACE THE FRONT …
Read full complaint
I BOUGHT THIS 2014 JEEP CHEROKEE SPORT IN AUGUST 2014. IT HAD APPROX. 300 MILES ON IT. NOTICED A STRONG "SHIMMY" IN THE JEEP AFTER IT SHIFTS TO 2ND GEAR. THE SHIMMY GOES AWAY AFTER INCREASED SPEED. TOOK IT TO THE DEALER AND THE TECH DROVE IT AND NOTICED THE SHIMMY ALSO. HE CHECKED FOR ANY SBS. CHRYSLER SAID TO REPLACE THE FRONT HALF-SHAFTS. THIS WAS DONE 2 WEEKS LATER. THE SHIMMY WAS STILL THERE WHEN I PICKED IT UP. THE TECH SAID THERE WAS A "BREAK IN PERIOD" OF 3000 MI AND IT WOULD GO AWAY. THERE IS NO SUCH THING AS A BREAK IN PERIOD FOR THIS PART. THE VEHICLE HAS HAD 3 SOFTWARE UPGRADES ON THE TRANNY TO EASE HARSH SHIFTING. THIS WORKS FOR ABOUT 1 MONTH AND THEN BACK TO HARSH SHIFTING. THE SHIFTING GETS BETTER AS THE VEHICLE WARMS UP BUT THE SHIMMY IS THERE NO MATTER WHAT TEMP. TALKED TO THE SERVICE MANAGER AT THE DEALER AND HE RODE IN IT TODAY (1/21/14) AND NOTICED THE SHIMMY. WE THEN DROVE ANOTHER 2014 JEEP CHEROKEE, IT DID NOT HAVE A SHIMMY HE SAID HE WOULD REOPEN THE STAR CASE WITH CHRYSLER TO TRY TO RESOLVE THE ISSUE..THIS IS A $30,000 VEHICLE WITH 2000 MILES. IT SHOULD NOT BE DOING THIS, AND I AM SICK OF HEARING "THIS IS NORMAL" FROM SERVICE TECHS WHEN THEY HAVE NO CLUE WHY IT IS DOING THIS. WHEN IT GOES BACK IN THIS TIME, THIS WILL NUMBER 3. IF IT IS NOT REPAIRED CORRECTLY AND THE SHIMMY AND TRANS. ISSUES ARE STILL THERE, CHRYSLER WILL BUYING IT BACK PER LEMON LAW. *TR
NHTSA ODI #10678181
12,600 miles · Jan 17, 2015
Electrical SystemPower Train
ON DECEMBER 7TH, THE CAR (2014 JEEP CHEROKEE WITH 12,600 MILES) LOST POWER UNEXPECTEDLY WHILE I APPROACHED A STOPLIGHT, AND HAD TO BE COASTED TO THE SIDE OF THE ROAD. WE WAITED APPROXIMATELY 10 MINUTES, AND IT RESTARTED. NO WARNING OR CHECK ENGINE LIGHTS CAME ON. OVER THE NEXT SEVERAL DAYS, WE HAD APPROXIMATELY 3 INSTANCES WHERE…
Read full complaint
ON DECEMBER 7TH, THE CAR (2014 JEEP CHEROKEE WITH 12,600 MILES) LOST POWER UNEXPECTEDLY WHILE I APPROACHED A STOPLIGHT, AND HAD TO BE COASTED TO THE SIDE OF THE ROAD. WE WAITED APPROXIMATELY 10 MINUTES, AND IT RESTARTED. NO WARNING OR CHECK ENGINE LIGHTS CAME ON. OVER THE NEXT SEVERAL DAYS, WE HAD APPROXIMATELY 3 INSTANCES WHERE THE CAR EITHER WOULDN'T START, OR WOULD LOSE POWER. STILL NO WARNING LIGHTS CAME ON INDICATING AN ISSUE. AS WE BELIEVED THIS TO BE A POTENTIAL SAFETY ISSUE, WE TOOK IT TO THE LOCAL JEEP DEALERSHIP AND ASKED THEM TO CHECK IT OUT. THEY KEPT IT FOR 6 DAYS AND INDICATED THAT THEY COULD NOT RECREATE THE ISSUE. WE PICKED THE CAR UP ON DEC. 16TH. ON DECEMBER 25 THE CAR AGAIN LOST ALL POWER WHILE DRIVING (LOST ENGINE, POWER STEERING, AND POWER BREAKS). FORTUNATELY THIS OCCURRED ON A LOCAL ROAD AND THE CAR WAS ABLE TO BE COASTED TO STOP WITHOUT INCIDENT. THIS TIME SEVERAL INDICATORS ILLUMINATED INCLUDING THE 'CHECK ENGINE' LIGHT. WE HAD THE CAR TOWED THE NEXT DAY TO THE SAME DEALER. AT THE TIME OF THIS WRITING, THE DEALERSHIP HAS HAD THE CAR 22 DAYS, AND STILL HAVE NOT BEEN ABLE TO DIAGNOSE THE ISSUE. THEY DID REPLACE THE PCM, HOWEVER THIS DID NOT CORRECT THE ISSUE. I'M FILING THIS COMPLAINT BECAUSE OF THE POTENTIAL SAFETY ISSUE. I ALSO HAVE A CONCERN BECAUSE JEEP IS NOT ABLE TO PROPERLY DIAGNOSE THE PROBLEM IN A REASONABLE AMOUNT OF TIME. *TR
NHTSA ODI #10676223
3,000 miles · Jan 15, 2015
Electrical SystemPower Train
TWO PROBLEMS CAME UP AT AROUND THE SAME TIME. THE CAR WAS DELIVERED WITH THE TRANSMISSION 4 QUARTS LOW ON FLUID. THE CAR WAS SLIPPING OUT OF GEAR, LURCHING AND SHUDDERING. THE TRANSMISSION IS A SEALED UNIT SO THERE WAS NO WAY FOR ME TO KNOW THAT. THEN THE DASH DISPLAY WENT COMPLETELY DARK. NO FEEDBACK WAS GIVEN, ITS A DIGITA…
Read full complaint
TWO PROBLEMS CAME UP AT AROUND THE SAME TIME. THE CAR WAS DELIVERED WITH THE TRANSMISSION 4 QUARTS LOW ON FLUID. THE CAR WAS SLIPPING OUT OF GEAR, LURCHING AND SHUDDERING. THE TRANSMISSION IS A SEALED UNIT SO THERE WAS NO WAY FOR ME TO KNOW THAT. THEN THE DASH DISPLAY WENT COMPLETELY DARK. NO FEEDBACK WAS GIVEN, ITS A DIGITAL DISPLAY. SO I HAD NO SPEEDOMETER, TACHOMETER ETC AND THE WARNING LIGHTS WERE OUT. I FEEL LIKE A VEHICLE WITH NO DASH DISPLAY THAT SLIPS OUT OF GEAR WHEN PASSING OR LURCHES FORWARD WHEN STOPPING COULD BE DANGEROUS TO OTHER DRIVERS AND PEDESTRIANS. *TR
NHTSA ODI #10672873
14,000 miles · Jan 15, 2015
Power Train
DRIVING ON MAJOR HIGHWAY. HEARD LOUD BANG THEN "SERVICE TRANSMISSION INDICATION AND LOSS OF TRACTION" CAME ON. I LOST ALL POWER WITH NO WAY TO KEEP UP MY SPEED. I HIT MY 4 WAY FLASHERS AND THE TRACTOR TRAILER TRUCK BEHIND ME HAD TO BRAKE HARD AND WENT INTO THE GRASS MEDIAN. I FINALLY COASTED TO THE BERM AND WE GOT OUT TO MAKE S…
Read full complaint
DRIVING ON MAJOR HIGHWAY. HEARD LOUD BANG THEN "SERVICE TRANSMISSION INDICATION AND LOSS OF TRACTION" CAME ON. I LOST ALL POWER WITH NO WAY TO KEEP UP MY SPEED. I HIT MY 4 WAY FLASHERS AND THE TRACTOR TRAILER TRUCK BEHIND ME HAD TO BRAKE HARD AND WENT INTO THE GRASS MEDIAN. I FINALLY COASTED TO THE BERM AND WE GOT OUT TO MAKE SURE EVERYBODY WAS OK. THIS COULD HAVE ENDED IN A VERY DIFFERENT WAY. I FEEL IT IS NOT SAFE FOR ME OR MY FAMILY TO DRIVE THE VEHICLE. IF THE TRACTOR TRAILER DRIVER WAS NOT PAYING ATTENTION I COULD HAVE BEEN KILLED. *TR
NHTSA ODI #10672629
1,436 miles · Jan 11, 2015
Power Train
ON 6/24/2014 WAS DRIVING DOWN HIGHWAY WHEN ENGINE LIGHT CAME ON FOR THE FIRST TIME, THERE WAS NO LOSS OF POWER OR ANYTHING THE LIGHT JUST CAME ON. CALLED DEALERSHIP AS I HAD ONLY HAD THE VEHICLE 35 DAYS. BROUGHT IT IN WAS THE AIR INTAKE DEALERSHIP HAD IT FOR 5 DAYS. THEN IN OCTOBER 27TH ENGINE LIGHT CAME ON AGAIN. CALLED DEALERS…
Read full complaint
ON 6/24/2014 WAS DRIVING DOWN HIGHWAY WHEN ENGINE LIGHT CAME ON FOR THE FIRST TIME, THERE WAS NO LOSS OF POWER OR ANYTHING THE LIGHT JUST CAME ON. CALLED DEALERSHIP AS I HAD ONLY HAD THE VEHICLE 35 DAYS. BROUGHT IT IN WAS THE AIR INTAKE DEALERSHIP HAD IT FOR 5 DAYS. THEN IN OCTOBER 27TH ENGINE LIGHT CAME ON AGAIN. CALLED DEALERSHIP BROUGHT IT BACK IN LIGHT WENT OFF WHEN I BROUGHT IT UP THERE HAD THEM CHECK FOR RECALLS. 10/31/2014 BROUGHT IT BACK AS LIGHT WAS ON AGAIN.11/15 BROUGHT IN BECAUSE IT WAS NOT SHIFTING PROPERLY IT WAS LIKE THE LOWER GEAR DIDN'T WANT TO GO INTO THE HIGHER GEARS AND SHIFTING REALLY HARD, THEY HAD IT FOR TWO DAYS THIS TIME. . DURING THANKSGIVING TIRE LIGHT CAME ON THE FACTORY TIRE HAD A DEFECT AND HAD TO GO TO THE GOODYEAR DEALER FOR THEM TO REPLACE IT. DEC 27TH CALLED DEALERSHIP AGAIN ITS NOT SHIFTING CORRECTLY AND ENGINE LIGHT IS ON AGAIN, AT A STOP IT JERKED BACK AND I HAD TO TURN THE CAR OFF AND RESTART IN NEUTRAL TO PUT BACK INTO PARK. ALL THE LIGHTS CAME ON IN THE DASH. I THOUGHT I HIT SOMETHING BUT WAS JUST THE TRANSMISSION ACTING UP. IT RED LINES BEFORE SWITCHING GEARS TOOK IT TO THE DEALERSHIP ON 12/31/14 TO FIGURE OUT WHY THIS IS STILL GOING ON. . AS OF 1/11/15 IT IS STILL AT THE SHOP AS THEY ARE WAITING ON MORE "UPDATES" FROM CHRYSLER. *TR
NHTSA ODI #10671667
6,800 miles · Jan 7, 2015
Power Train
EARLIER I REPORTED ABOUT HAVING TROUBLE IN SECOND GEAR. NOW THE TRANSMISSION IS HAVING PROBLEM AND SERVICE TRANSMISSION LIGHT CAME ON IN A BRAND NEW CAR WITH JUST UNDER 7000 MILES. THE PROBLEM STARTED WITH JERKS DURING GEAR SHIFTS FROM PARK TO DRIVE AND VICE-VERSE. THEN, I COULD FEEL JERKS WHILE SHIFTING FROM 4TH TO 5TH GEAR AND…
Read full complaint
EARLIER I REPORTED ABOUT HAVING TROUBLE IN SECOND GEAR. NOW THE TRANSMISSION IS HAVING PROBLEM AND SERVICE TRANSMISSION LIGHT CAME ON IN A BRAND NEW CAR WITH JUST UNDER 7000 MILES. THE PROBLEM STARTED WITH JERKS DURING GEAR SHIFTS FROM PARK TO DRIVE AND VICE-VERSE. THEN, I COULD FEEL JERKS WHILE SHIFTING FROM 4TH TO 5TH GEAR AND WHEN IT WOULD SHIFT BACK TO 4TH FROM 5TH, THE ENGINE WOULD REV UPTO 2000 RPM AND THEN SLOW DOWN. THAT WAS KIND OF DANGEROUS AS IT WOULD ACCELERATE THE VEHICLE WHERE YOU NEED IT TO STOP. ALL OF A SUDDEN, THE SERVICE TRANSMISSION LIGHT CAME ON THE VEHICLE WOULD NOT MOVE FROM 6TH GEAR AND I HAD TO STOP ON THE SIDE OF THE HIGHWAY. AFTER SWITCHING THE ENGINE OFF AND ON AGAIN, THE VEHICLE STARTED DRIVING BUT THE SAME PROBLEM STARTED REPEATING. I WAS ON A VACATION DRIVING UP NORTH IN NORTH HAMPSHIRE, VERMONT AND NEW YORK AND I HAD TO GET BACK HOME. SOMEHOW I WAS ABLE TO MAKE IT HOME. I'M STILL WAITING FOR THE DEALER TO GIVE ME A CONFIRMATION ABOUT A LOANER CAR SO THAT I CAN GIVE IT FOR REPAIRS. *TR
NHTSA ODI #10670660
100 miles · Jan 6, 2015
Power Train
THE FOLLOWING ARE DESCRIPTIONS OF VARIOUS ISSUES ENCOUNTERED WITH THE AUTOMATIC 9-SPEED TRANSMISSION ON THE 4-CYLINDER 2WD 2014 JEEP CHEROKEE (LATITUDE). OBSERVATIONS OCCURRED IN FIRST 5000 MILES SINCE NEW. 1. SOMETIMES, WHEN DOWNSHIFTING FROM 2ND TO 1ST GEAR, THE CAR LUNGES FORWARD. NORMALLY, ITS ANNOYING, BUT SOMETIMES, WHEN…
Read full complaint
THE FOLLOWING ARE DESCRIPTIONS OF VARIOUS ISSUES ENCOUNTERED WITH THE AUTOMATIC 9-SPEED TRANSMISSION ON THE 4-CYLINDER 2WD 2014 JEEP CHEROKEE (LATITUDE). OBSERVATIONS OCCURRED IN FIRST 5000 MILES SINCE NEW. 1. SOMETIMES, WHEN DOWNSHIFTING FROM 2ND TO 1ST GEAR, THE CAR LUNGES FORWARD. NORMALLY, ITS ANNOYING, BUT SOMETIMES, WHEN STOPING AT A CROSS-WALK CAR LUNGES AT PEDESTRIANS. NO INCIDENTS YET, BUT IT CAN STARTLE OR ANGER PEDESTRIANS. ALSO, WHEN PULLING UP TO A TIGHT INTERSECTION, CAR SOMETIMES LUNGES FORWARD CAUSING NOSE OF VEHICLE TO PROTRUDE INTO INTERSECTION. (SOMEWHAT MITIGATED BY FLASH UPDATED, BUT NOT COMPLETELY RESOLVED) 2. OFTEN, BUT NOT ALWAYS, DURING GENTLE AND SMOOTH ACCELERATION WHEN SHIFTING FROM 1ST TO 2ND GEAR VEHICLE APPEARS TO STAY TOO LONG IN 1ST GEAR RESULTING IN DECREASED POWER, THEN WHEN IT SHIFTS TO 2ND GEAR, THE VEHICLE LUNGES FORWARD MOMENTARILY BEFORE RESUMING NORMAL ACCELERATION. (ALSO, OCCURS, BETWEEN 2ND AND 3RD GEAR, BUT TO A LESSER EXTENT.) 3. A FEW TIMES DURING FIRM ACCELERATION TRANSMISSION HESITATES RESULTING IN COMPLETE LOSS OF POWER FOR 1 OR 2 SECONDS. 4. ONCE, WHEN DRIVING DOWN HILL, THE THE BRAKE WAS APPLIED AND VEHICLE WAS STOPPED. THE TRANSMISSION WAS SWITCHED FROM DRIVE TO REVERSE, AND WHEN BRAKE PRESSURE WAS RELEASED THE VEHICLE CONTINUED TO ROLL FORWARD (DOWNHILL) FOR APPROXIMATELY 2 OR 3 FEET BEFORE THE TRANSMISSION FINALLY ENGAGED AND WENT INTO REVERSE.
NHTSA ODI #10670416
3,156 miles · Jan 5, 2015
Power Train
WHILE TRAVELING ON A TRIP, I NOTICED I WAS LOOSING SPEED WHILE GOING DOWN A 4 LANE ROAD. I LOOKED AT THE CONTROL CENTER AND THE MESSAGE WAS "SERVICE TRANSMISSION AND THE CHECK ENGINE LIGHT WAS ON". I WAS LOSING SPEED SO PULLED OFF ON THE SIDE OF THE ROAD. THE ENGINE HAD QUIT RUNNING AND THE JEEP WOULD NOT GO INTO ANY GEAR.…
Read full complaint
WHILE TRAVELING ON A TRIP, I NOTICED I WAS LOOSING SPEED WHILE GOING DOWN A 4 LANE ROAD. I LOOKED AT THE CONTROL CENTER AND THE MESSAGE WAS "SERVICE TRANSMISSION AND THE CHECK ENGINE LIGHT WAS ON". I WAS LOSING SPEED SO PULLED OFF ON THE SIDE OF THE ROAD. THE ENGINE HAD QUIT RUNNING AND THE JEEP WOULD NOT GO INTO ANY GEAR. WE WERE IN THE DESERT 40 MILES FROM NO WHERE! CALLED A TOW SERVICE THEY TOOK US TO THE NEAREST JEEP DEALER. NEXT MORNING THE DEALERSHIP CALLED AND SAID OUR JEEP WAS READY TO GO. SECOND TIME JULY 14, 2014 WHILE TRAVELING ON A 2 LANE HIGHWAY I NOTICED I WAS LOSING SPEED. THE MESSAGE CENTER SAID " CHECK BATTERY" AGAIN THE ENGINE SHUT DOWN AS I WAS MOVING TO THE SIDE OF THE ROAD. CONTACTED THE SERVICE DEPT. OF OUR DEALERSHIP. WAS TOLD TO WAIT 10 MIN. THEN TRY TO START THE JEEP. IT DID START AND WE MADE IT BACK HOME. THIRD TIME, NOV. 20, 2014 WHILE TRAVELING NOTICED THE JEEP WOULD SPEED UP WHEN I LET OFF THE ACCELERATOR TO SLOW DOWN OR COAST. IF I APPLIED THE BRAKE THE JEEP WOULD THEN SLOW DOWN. NOTICED EVERY TIME I LET OFF THE GAS THE JEEP WOULD SPEED UP NOT SLOW DOWN. ABOUT 30 MIN. MORE OF TRAVELING TIME I AGAIN GOT THE MESSAGE "SERVICE TRANSMISSION WITH THE ENGINE LIGHT ON. I GOT OVER TO THE SIDE OF A 6 LANE INTERSTATE HIGHWAY AND CALLED FOR A TOW TRUCK AGAIN WAS TAKEN TO THE NEAREST DEALERSHIP. AT THAT POINT 12, 967 MILES ON THE ODOMETER. SIX DAYS LATER WHEN THE DEALERSHIP GOT AROUND TO THE DIAGNOSIS ON THE JEEP THEY SAID IT NEEDS A NEW NINE SPEED TRANSMISSION. WE WERE HOME AT THAT TIME 460 AWAY FROM WHERE WE HAD TO LEAVE THE JEEP WHEN IT QUIT RUNNING. BEING STRANDED ON THE SIDE OF A ROAD IN A NEW VEHICLE IS NOT SAFE BUT UNACCEPTABLE PERFORMANCE FOR A NEW VEHICLE. *TR
NHTSA ODI #10670210
Official recalls
13May 11, 2023
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Additional source detail variants (2)
Structure:body:hatchback/liftgate
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Electrical System:wiring: Rear Compartment/trunk
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Jun 11, 2020
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence & remedy
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Additional source detail variants (2)
Power Train:driveline:differential Unit
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Power Train:automatic Transmission
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Jun 13, 2019
Chrysler (FCA US LLC) is recalling certain 2014 Jeep Cherokee vehicles equipped with 3.2L engines. In the event that a clutch becomes stuck in the transmission, the transmission software may shift the transmission to neutral.
Consequence & remedy
Consequence: An unexpected shift to neutral would result in a loss of drive, increasing the risk of crash.
Remedy: Chrysler will notify owners, and dealers will update the transmission software, free of charge. The recall began August 8, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V69.
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Dec 21, 2017
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.
Aug 10, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence & remedy
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Additional source detail variants (2)
Seats:mid/rear Assembly
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Seats
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Jul 12, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee and 2015 Chrysler 200, Jeep Renegade, RAM ProMaster, and 2016 Fiat 500X vehicles equipped with 9-speed automatic transmissions. The transmission sensor clusters may have insufficient crimps in the transmission wire harness, and as a result, the transmission may unexpectedly shift to neutral. On August 29, 2016 Chrysler added the 2016 Fiat 500X vehicles to this recall.
Consequence & remedy
Consequence: If the vehicle unexpectedly shifts to neutral, there is an increased risk of a crash.
Remedy: Chrysler will notify owners, dealers will reprogram the Powertrain Control Module and the Transmission Control Module and if necessary replace the transaxle range sensor wire harness, free of charge. The recall began on November 7, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S55.
Aug 12, 2015
Chrysler (FCA US LLC) is recalling certain model year 2014 Jeep Cherokee vehicles manufactured January 4, 2013, to July 11, 2014. Use of the front windshield wipers on dry glass may cause damage to the body control module (BCM).
Consequence & remedy
Consequence: BCM damage may result in the failure of the windshield wipers, impairing the driver's vision and increasing the risk of a vehicle crash.
Remedy: Chrysler will notify owners, and dealers will install a ground strap to protect the BCM from damage, free of charge. Owners were notified of the recall on October 7, 2015. The recall began on December 15, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R39.
Jul 23, 2015
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, 3500, 4500, and 5500, 2015 Chrysler 200, Chrysler 300, Dodge Charger, and Dodge Challenger, 2014-2015 Jeep Grand Cherokee, Cherokee, and Dodge Durango, and 2013-2015 Dodge Viper vehicles. The affected vehicles are equipped with radios that have software vulnerabilities that can allow third-party access to certain networked vehicle control systems.
Consequence & remedy
Consequence: Exploitation of the software vulnerability may result in unauthorized remote modification and control of certain vehicle systems, increasing the risk of a crash.
Remedy: Chrysler will notify and mail affected owners a USB drive that includes a software update that eliminates the vulnerability, free of charge. Optionally, owners may download the update to their own USB drive from http://www.driveuconnect.com/software-update/ or take their vehicle to a Chrysler dealer for immediate installation. In an effort to mitigate the effects of this security vulnerability, Chrysler has had the wireless service provider close the open cellular connection to the vehicle that provided unauthorized access to the vehicle network. This measure may not have been implemented on all vehicles and does not address access by other means that will be remedied by the software update. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R40.
Jun 22, 2015
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 4, 2013, to February 18, 2015 and equipped with a Power Liftgate option. In the affected vehicles, water may enter the Power Liftgate Control Module and cause a high resistance short circuit in the module.
Consequence & remedy
Consequence: A short circuit in the liftgate control module may result in a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the power liftgate control module and connectors for corrosion, substitute a bolt for the threaded grommet installed to seal an attachment point used in non-power liftgate vehicles and cover the power liftgate control module in a foam water shield, free of charge. The recall began on October 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R27. This recall is superseded by NHTSA recall 23V-338.
Jan 28, 2015
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence & remedy
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Additional source detail variants (2)
Air Bags:side/window:curtain
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Air Bags:side/window
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Jul 2, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Jeep Cherokee and Ram 1500 and 2015 Chrysler 200 vehicles. Due to an insufficient weld, the rear shocks may detach from the vehicle at one end and possibly damage other chassis components, the tire or result in reduced braking.
Consequence & remedy
Consequence: Damage to the tire or reduced braking increases the risk of a vehicle crash.
Remedy: Chrysler will notify owners, and dealers will inspect the rear shocks and replace any affected ones, free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P37.
Jun 4, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Dodge Durango vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee SRT vehicles manufactured February 3, 2014 to April 8, 2014, and Jeep Cherokee vehicles manufactured March 6, 2014 to April 17, 2014. When the adaptive cruise control is engaged and the driver presses the accelerator pedal to increase the vehicle's speed more than the cruise control system would on its own, the vehicle may continue to accelerate briefly after the accelerator pedal is released.
Consequence & remedy
Consequence: The unintended continued acceleration may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the Driver Assistance System Module (DASM), free of charge. The recall began in June 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P31.
Additional source detail variants (2)
Forward Collision Avoidance: Adaptive Cruise Control
Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Dodge Durango vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee SRT vehicles manufactured February 3, 2014 to April 8, 2014, and Jeep Cherokee vehicles manufactured March 6, 2014 to April 17, 2014. When the adaptive cruise control is engaged and the driver presses the accelerator pedal to increase the vehicle's speed more than the cruise control system would on its own, the vehicle may continue to accelerate briefly after the accelerator pedal is released.
Consequence: The unintended continued acceleration may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the Driver Assistance System Module (DASM), free of charge. The recall began in June 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P31.
Vehicle Speed Control:accelerator Pedal
Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Dodge Durango vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee SRT vehicles manufactured February 3, 2014 to April 8, 2014, and Jeep Cherokee vehicles manufactured March 6, 2014 to April 17, 2014. When the adaptive cruise control is engaged and the driver presses the accelerator pedal to increase the vehicle's speed more than the cruise control system would on its own, the vehicle may continue to accelerate briefly after the accelerator pedal is released.
Consequence: The unintended continued acceleration may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the Driver Assistance System Module (DASM), free of charge. The recall began in June 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P31.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE22009 · Electronic Parking Brake Water Ingress
Opened Jul 22, 2022 · Closed Oct 29, 2023
Status: closed (inferred from source dates) · Parking Brake:electrical; Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Parking Brake:electrical
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
RQ15004 · Software Security Vulnerability
Opened Jul 24, 2015 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Electrical System:software
On July 23, 2015, Fiat Chrysler Automobiles (FCA) launched Safety Recall 15V-461 to remedy security vulnerabilities in approximately 1.4 million model year (MY) 2013 through 2015 vehicles equipped with Uconnect head units (HU) 8.4A (RA3 radio) and 8.4AN (RA4 radio) manufactured by Harman International.On July 24, 2015, the Office of Defects Investigation (ODI) opened Recall Query, RQ 15-004, to investigate HU security vulnerabilities and remedy effectiveness in the recalled population and to determine whether similar units have been supplied for use in other FCA vehicles.In an August 11, 2015 letter, FCA submitted a second Part 573 safety recall report expanding the scope of the Uconnect RA4 model radio to include additional 7,810 MY 2015 Jeep Renegade vehicles manufactured from September 18, 2014 through June 25, 2015 (Recall 15V-508).Scope analysis indicated that Uconnect radios installed in FCA vehicles not included in recalls 15V-461 or 15V-508 (subject recalls) are not equipped with built-in cellular access or short range wireless communication features and, thus, do not contain the security vulnerabilities addressed by the subject recalls. SUBJECT VEHICLES: MY2014 through 2015 Dodge Durango, Jeep Grand Cherokee and Jeep Cherokee sport utility vehicles; MY2013 through 2015 Ram 1500, 2500, 3500 and 4500/5500 pickup trucks; MY2013 through 2015 Dodge Viper vehicles; and MY2015 Chrysler 200, 300, Jeep Renegade, Dodge Charger and Challenger vehicles.According to FCA, long and short range wireless vulnerabilities identified in the recalled vehicles could allow unauthorized third-party access to, and manipulation of, networked vehicle control systems.Successful exploitation of the vulnerabilities, coupled with reverse engineering of networked microprocessor control modules, could result in unauthorized manipulation of vehicle control systems. This unauthorized manipulation of vehicle controls and systems could expose the driver, vehicle occupants or other highway users to an increased risk of injury.FCA and its network provider, Sprint, conducted a nationwide campaign to block access to a radio communications port that was unintentionally left open.On July 27, 2015, short range wireless vulnerabilities were also blocked.Finally, third party security evaluation and regression testing identified vulnerabilities that were either remedied by Sprint or through updates to the FCA Uconnect software.ODI identified a total of 30 complaints or field reports on unique vehicles submitted by FCA (29) or received by NHTSA (1) alleging incidents of theft from a vehicle or anomalous performance that the owner alleged were caused by, or may have been caused by, remote hacking.Twenty-six (87%) of these reports were submitted after a magazine article was published on July 21, 2015, describing the remote hacking of an FCA vehicle by researchers who were able to affect the operation of various vehicle control systems, including the service brakes, steering, throttle and ignition.Most of the complaints involved vehicle systems that were not safety critical (e.g., complaints related to radio, navigation system, or air-conditioning control) and did not affect vehicle control.Three complaints reported engine stalls.One owner reported sudden unintended acceleration allegedly related to hacking.None of the complaints or field reports reviewed involved the steering and braking vehicle control effects demonstrated by the research hackers prior to the recall.There were no confirmed incidents of hacking in any of the records reviewed by ODI.The remedies completed by Sprint and FCA appear to have eliminated vulnerabilities that mi
Illustration