NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
186 reportsClear category filterMileage unknown · Feb 23, 2018
Fuel/propulsion System
TL* THE CONTACT OWNS A 2014 JEEP CHEROKEE. THE CONTACT STATED THAT FUEL FAILED TO ENTER THE FUEL TANK, WHICH SPEWED OUT SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A DEALER (SHEBOYGAN CHRYSLER CENTER INC, 2701 WASHINGTON AVE, SHEBOYGAN, WI 53081, (920) 459-6020) WHERE IT WAS DIAGNOSED THAT THE VALVE IN THE FUEL TANK WAS STICKING. T…
Read full complaint
TL* THE CONTACT OWNS A 2014 JEEP CHEROKEE. THE CONTACT STATED THAT FUEL FAILED TO ENTER THE FUEL TANK, WHICH SPEWED OUT SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A DEALER (SHEBOYGAN CHRYSLER CENTER INC, 2701 WASHINGTON AVE, SHEBOYGAN, WI 53081, (920) 459-6020) WHERE IT WAS DIAGNOSED THAT THE VALVE IN THE FUEL TANK WAS STICKING. THE DEALER REPLACED THE FUEL TANK. THE MANUFACTURER HAD NOT ISSUED ANY RECALLS, BUT ISSUED THREE TSBS ON THE FUEL SYSTEM. THE MANUFACTURER PROVIDED NO SOLUTION OTHER THAN HAVING THE VEHICLE DIAGNOSED AND REPAIRED BY A DEALER. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #11074512
43,000 miles · Feb 13, 2018
Fuel/propulsion System
WHEN ATTEMPTING TO FILL THE TANK, LESS THAN 0.25 GALLONS WILL GO INTO THE TANK BEFORE THE PUMP CUTS OFF. AT FIRST WE THOUGHT THE PROBLEM MAY HAVE TO DO WITH THE PUMPS AT THE STATION. SO WE TOOK IT TO OTHER STATIONS TO HAVE THE PROBLEM CONTINUE. THERE HAS BEEN NO CHANGE TO THE SITUATION SINCE IT BEGAN. WHEN WE TOOK THE CAR IN…
Read full complaint
WHEN ATTEMPTING TO FILL THE TANK, LESS THAN 0.25 GALLONS WILL GO INTO THE TANK BEFORE THE PUMP CUTS OFF. AT FIRST WE THOUGHT THE PROBLEM MAY HAVE TO DO WITH THE PUMPS AT THE STATION. SO WE TOOK IT TO OTHER STATIONS TO HAVE THE PROBLEM CONTINUE. THERE HAS BEEN NO CHANGE TO THE SITUATION SINCE IT BEGAN. WHEN WE TOOK THE CAR IN FOR SERVICE AND WERE TOLD A VALVE IN THE TANK HAD FAILED AND THE ENTIRE TANK WOULD HAVE TO BE REPLACED. OTHERS WHO HAVE REPORTED THIS PROBLEM ON LINE HAVE SAID THAT REPLACING THE TANK IS NOT A GUARANTEE OF ELIMINATING THE PROBLEM. AFTER REPLACING THE TANK, THE PROBLEM REOCCURRED.
NHTSA ODI #11072484
60,000 miles · Feb 4, 2018
Fuel/propulsion System
THIS STARTED ABOUT A YEAR AGO WHEN MY VEHICLE 2015 JEEP CHEROKEE HAD APX 60000 MILES, WHEN I FILL MY GAS TANK I NEED TO TRICKLE THE FUEL IN. IF TRY TO FILL IT TOO FAST IT WILL SHUT OFF THE PUMP, MAKING IT APX 10-15 MINUTES TO PUMP 10 OR MORE GALLONS, WHEN IT IS FINELY IS FULL, IT WILL OVER FLOW AND "BURP" OUT THE FUEL ALL OVER T…
Read full complaint
THIS STARTED ABOUT A YEAR AGO WHEN MY VEHICLE 2015 JEEP CHEROKEE HAD APX 60000 MILES, WHEN I FILL MY GAS TANK I NEED TO TRICKLE THE FUEL IN. IF TRY TO FILL IT TOO FAST IT WILL SHUT OFF THE PUMP, MAKING IT APX 10-15 MINUTES TO PUMP 10 OR MORE GALLONS, WHEN IT IS FINELY IS FULL, IT WILL OVER FLOW AND "BURP" OUT THE FUEL ALL OVER THE SIDE OF THE VEHICLE AND THE PERSON FILLING THE TANK. I WENT TO THE DEALER AND THEY SAID I NEEDED TO REPLACE THE FUEL TANK AND IT WAS NOT UNDER WARRANTY. THE FUEL TANK WAS ON BACK ORDER AND WOULD BE 2 TO 4 WEEKS. IN THE MEAN TIME THE PROBLEM WENT AWAY BEFORE THE BACK ORDERED TANK CAME IN. NOTE THE DEALER NEVER DID CALL WHEN THE PART CAME IN IF IT DID. I DID NOT HAVE THE TANK REPLACE THIS LASTED APX 6 MONTHS UNTIL THE PROBLEM STARTED AGAIN. THIS SOUNDS LIKE A MANUFACTURERS DEFECT, THAT IS DANGEROUS (SPILLED FUEL), ENVIRONMENTALLY BAD AND WASTEFUL. I HAVE SPOKEN TO OTHER JEEP OWNERS WITH THE SAME PROBLEM AND HAVE HEAR ABOUT THE SAME PROBLEM FROM SEVERAL EMPLOYEES AT THE GAS STATIONS I HAVE USED. I WOULD UNDERSTAND IF THERE WAS A WEARABLE PART INVOLVED, BUT WHAT CAN WEAR OUT ON A FUEL TANK IN 60000 MILES AND 2.5 YEARS. I BELIEVE THIS SHOULD BE A JEEP RECALL AND SHOULD BE COVERED BY JEEP.
NHTSA ODI #11066872
43,000 miles · Jan 28, 2018
Fuel/propulsion System
MY 2014 JEEP CHEROKEE WHEN I PUT GAS IN IT .I PUT THE GAS CAP THEN GOT IN IT PUT MY FOOT ON THE BRAKE AND PUSH THE START BUTTON IT START ED THEN I PUT IT IN DRIVE AND WE COULDN'T GO ANY WHERE. IT JERK SOME THEN JUST SHUT DOWN. WHEN WE FINELY GOT GOING IT QUIT AGAIN AND AGAIN FINELY WHEN IT STARTED I RAN ALL STOP SIGN UNTIL I COU…
Read full complaint
MY 2014 JEEP CHEROKEE WHEN I PUT GAS IN IT .I PUT THE GAS CAP THEN GOT IN IT PUT MY FOOT ON THE BRAKE AND PUSH THE START BUTTON IT START ED THEN I PUT IT IN DRIVE AND WE COULDN'T GO ANY WHERE. IT JERK SOME THEN JUST SHUT DOWN. WHEN WE FINELY GOT GOING IT QUIT AGAIN AND AGAIN FINELY WHEN IT STARTED I RAN ALL STOP SIGN UNTIL I COULD GET TO SOME TO HELP.THEN THEY SAID IF IT DIDN'T SHOW A CODE THEY COULDN'T DO ANYTHING ABOUT IT .
NHTSA ODI #11065494
55,000 miles · Jan 12, 2018
Fuel/propulsion System
3.6L PENTASTAR ENGINE CRACKED OIL FILTER HOUSING. OIL FILTER HOUSING CRACKED AND BEGAN TO LEAK LARGE AMOUNTS OF OIL. CRACK OCCURRED DURING COLD WEATHER AND WAS 9 MONTHS AFTER OIL CHANGE (NOT RELATED TO OVER TOURQING OF FILTER HOUSING). 100S OF COMPLAINTS LOGGED ONLINE FOR THE SAME ISSUE ON THIS ENGINE. NEEDS TO BE RECALLED. …
Read full complaint
3.6L PENTASTAR ENGINE CRACKED OIL FILTER HOUSING. OIL FILTER HOUSING CRACKED AND BEGAN TO LEAK LARGE AMOUNTS OF OIL. CRACK OCCURRED DURING COLD WEATHER AND WAS 9 MONTHS AFTER OIL CHANGE (NOT RELATED TO OVER TOURQING OF FILTER HOUSING). 100S OF COMPLAINTS LOGGED ONLINE FOR THE SAME ISSUE ON THIS ENGINE. NEEDS TO BE RECALLED. THEY REFUSE TO COVER VIA 100K POWERTRAIN WARRANTY.
NHTSA ODI #11062484
35,000 miles · Jan 5, 2018
EngineFuel/propulsion SystemPower Train
THE 2014 JEEP CHEROKEE COMPLETELY STALLS WHILE DRIVING WITH A MESSAGE THAT STATES "MUST BE IN P TO SHIFT GEARS". THE VEHICLE ALSO STALLS WHILE DRIVING AFTER FILLING THE GAS TANK, WITH THE SAME MESSAGE. THE DEALER CANNOT IDENTIFY THE PROBLEM. I'VE SEEN SEVERAL OTHER COMPLAINTS FROM OWNERS FOR THE EXACT SAME THING THAT DON'T SEEM …
Read full complaint
THE 2014 JEEP CHEROKEE COMPLETELY STALLS WHILE DRIVING WITH A MESSAGE THAT STATES "MUST BE IN P TO SHIFT GEARS". THE VEHICLE ALSO STALLS WHILE DRIVING AFTER FILLING THE GAS TANK, WITH THE SAME MESSAGE. THE DEALER CANNOT IDENTIFY THE PROBLEM. I'VE SEEN SEVERAL OTHER COMPLAINTS FROM OWNERS FOR THE EXACT SAME THING THAT DON'T SEEM TO BE GETTING ADDRESSED. FAILURE TO ADDRESS THIS ISSUE IS A RISK TO THOSE OWNING THE VEHICLES AS WELL AS OTHERS ON THE ROADS AND POSES A MAJOR LIABILITY TO THE COMPANY IF NOTHING IS DONE TO RESOLVE THE ISSUE. I'M LISTING THE MOST RECENT DATE, HOWEVER THIS IS NOT THE FIRST TIME IT'S HAPPENED.
NHTSA ODI #11060736
73,000 miles · Jan 3, 2018
Fuel/propulsion System
MY CAR STOPPED ALLOWING ME TO PUT GAS IN IT. ONE DAY IT WAS FINE, THE NEXT TIME I TRIED TO PUT GAS IN IT, THE PUMP KEPT SHUTTING OFF, SIMILARLY TO WHEN IT'S FULL AND/OR THE PUMP IS LOW. AFTER TRYING DIFFERENT STATIONS, CARDS, ETC. I IDENTIFIED IT WAS THE CAR. I WATCHED THE GAS GO INTO THE TANK, FILL QUICKLY THEN SLOWLY DISPERSE …
Read full complaint
MY CAR STOPPED ALLOWING ME TO PUT GAS IN IT. ONE DAY IT WAS FINE, THE NEXT TIME I TRIED TO PUT GAS IN IT, THE PUMP KEPT SHUTTING OFF, SIMILARLY TO WHEN IT'S FULL AND/OR THE PUMP IS LOW. AFTER TRYING DIFFERENT STATIONS, CARDS, ETC. I IDENTIFIED IT WAS THE CAR. I WATCHED THE GAS GO INTO THE TANK, FILL QUICKLY THEN SLOWLY DISPERSE DOWN INTO THE TANK. I TOOK THE CAR TO THE DEALERSHIP AND JEEP STATED THEY BELIEVED THAT THE ROLL OVER VALVE HAD MALFUNCTIONED CAUSING IT TO STICK AND THAT THE GAS TANK NEEDED REPLACEMENT. I SPECIFICALLY ASKED THE CAUSE OF THIS TYPE OF ISSUE AND THE SERVICE MANAGER STATED IT "SOMETIMES JUST HAPPENS" AND CONFIRMED MULTIPLE TIMES IT WAS "NO FORM OF MISSED MAINTENANCE" THAT IT "JUST HAPPENS". UPON FURTHER INSPECTION AND MECHANICAL REVIEW, THE TANK DOESN'T CONTAIN THE VALVE ITSELF, THE FUEL PUMP CONTAINS THE VALVE WHICH SOMEHOW JUST GOT "STUCK" IN TURN MAKING THE VEHICLE THINK IT HAD ROLLED OVER, SHUTTING OFF FLOW TO PREVENT FIRES. I HAD THE PUMP REPLACED AND THE CAR IS FUNCTIONING FINE.
NHTSA ODI #11058330
70,000 miles · Dec 30, 2017
EngineFuel/propulsion SystemService Brakes
AFTER FILLING MY TANK WITH GAS I TURNED ONTO A NEARBY ROADWAY AND FELT MY CAR SPUTTERING AND JERKING. AS I CAME TO A SLOW STOP AT A STOP LIGHT MY CAR ABRUPTLY SLAMMED TO A STOP AND MADE A LOUD BANG/SLAMMING NOISE AND PROMPTED ME TO SHIFT TO PARK AND RESTART THE CAR. I FOLLOWED THESE COMMANDS AND THE CAR WOULD NOT MOVE. AS SOON A…
Read full complaint
AFTER FILLING MY TANK WITH GAS I TURNED ONTO A NEARBY ROADWAY AND FELT MY CAR SPUTTERING AND JERKING. AS I CAME TO A SLOW STOP AT A STOP LIGHT MY CAR ABRUPTLY SLAMMED TO A STOP AND MADE A LOUD BANG/SLAMMING NOISE AND PROMPTED ME TO SHIFT TO PARK AND RESTART THE CAR. I FOLLOWED THESE COMMANDS AND THE CAR WOULD NOT MOVE. AS SOON AS I WOULD SHIFT OUT OF PARK THE LOUD SLAMMING WOULD OCCUR AGAIN AND I BEGAN TO SMELL FUMES SO I STOPPED TRYING TO FOLLOW THE PROMPTS. I PUT MY CAR IN NEUTRAL AND PUSHED MY CAR OUT OF THE MOVING TRAFFIC LANES AND GOT IT TOWED. THE DEALERSHIP CLAIMED NOTHING IS WRONG WITH MY VEHICLE AND GAVE IT BACK. I HAVE EXPERIENCED THE SAME ISSUE 3 TIMES SINCE. THEY REPLACED AN EVAPORATION PRESSURE SWITCH THE SECOND TIME I TOOK MY CAR IN AND THIS STILL HAS NOT FIXED THE ISSUE. THE LAST TIME THE ISSUE OCCURRED I WAS SLOWING DOWN ON A HIGHWAY IN DENSE TRAFFIC AND AS TRAFFIC STARTED MOVING AGAIN MY GAS PEDAL STOPPED WORKING. I COULD NOT ACCELERATE WHEN I PRESSED THE GAS I ONLY HEARD LOUD REVVING NOISES AS MY CAR COASTED.. WHEN I WENT TO PRESS THE BRAKES AND PULL OFF THE ROAD I IMMEDIATELY HEARD THE LOUD SLAMMING NOISE AND MY CAR BROKE DOWN AGAIN IN A VERY UNSAFE LOCATION ON THE HIGHWAY. I WAITED ONE HOUR AND MY CAR WAS ABLE TO RESTART AND I SLOWLY GOT IT OFF THE HIGHWAY WITH MY E-LIGHTS ON. I WILL BE TAKING IT TO THE SHOP AFTER THE NEW YEAR.. AGAIN. WORST OF ALL AFTER LOOKING INTO THIS ISSUE ONLINE I SEE IT IS COMMON AMONG JEEP VEHICLES. NOT JUST THE CHEROKEE. HAPPENS AFTER I GAS UP. IT IS EXTREMELY UNSAFE AS I HAVE ALMOST BEEN REAR ENDED AT HIGH SPEEDS BY OTHER CARS ON THE ROADWAY. HAS BEEN LISTED IN FORUMS AS SOMESORT OF ROLLOVER FUEL VALVE. PLEASE INVESTIGATE BEFORE MORE SERIOUS INJURIES OR EVEN DEATH OCCURS ASSUMING THAT HASN'T ALREADY HAPPENED. ALSO PLEASE NOTE THAT SINCE THE WORK THEY DID ON 2ND VISIT TO DEALER I HAVE HAD CHECK GAS CAP AND ENGINE LIGHTS ON
NHTSA ODI #11057694
65,000 miles · Dec 14, 2017
EngineFuel/propulsion SystemPower Train
SINCE I PURCHASED MY USED VEHICLE I HAVE HAD A REOCCURRING ISSUE WHERE THE VEHICLE HESITATES TO ACCELERATE IN THE FIRST GEAR. RECENTLY IT HAS GOTTEN SO SEVERE THAT THE VEHICLE COMPLETELY SHUTS OFF. I'VE NOTICED THAT IT OCCURS MOST FREQUENTLY AFTER I FILL MY TANK AND AFTER PROLONGED PERIODS OF BEING STOPPED. IT HAS OCCURRED FOUR …
Read full complaint
SINCE I PURCHASED MY USED VEHICLE I HAVE HAD A REOCCURRING ISSUE WHERE THE VEHICLE HESITATES TO ACCELERATE IN THE FIRST GEAR. RECENTLY IT HAS GOTTEN SO SEVERE THAT THE VEHICLE COMPLETELY SHUTS OFF. I'VE NOTICED THAT IT OCCURS MOST FREQUENTLY AFTER I FILL MY TANK AND AFTER PROLONGED PERIODS OF BEING STOPPED. IT HAS OCCURRED FOUR TIMES ON THE HIGHWAY WHILE SITTING IN TRAFFIC AND MOST RECENTLY WHILE WAITING AT A RED LIGHT. WHEN IT OCCURS THE VEHICLE STILL HAS POWER RUNNING THROUGH AND A NOTICES ALWAYS POPS UP SAYING "CAR MUST BE IN PARK IN ORDER TO SHIFT." IN ALL CASES I HAVE HAD TO TURN THE VEHICLE OFF AND WAIT SEVERAL MINUTES BEFORE THE CAR WAS ABLE TO TURN BACK ON. IN ALL CASES NO INDICATOR LIGHT APPEARED AS TO WHAT THE PROBLEM COULD BE. AFTER TAKING THE VEHICLE TO GET SERVICED THEW FIRST TIME I WAS TOLD IT WAS THE BATTERY. THE SECOND TIME I TOOK IT TO GET SERVICED I WAS TOLD THE EVAPORATED CANISTER AND PURGE SOLENOID HAD TO REPLACED. THE ISSUE STILL EXISTS AND THE DEALERSHIP HAS ASKED ME TO CONTINUE DRIVING THE VEHICLE AS IS UNTIL A SERVICE LIGHT APPEARS BECAUSE THEY DO NOT KNOW WHAT THE PROBLEM CAN BE. THIS VEHICLE IS NOT SAFE TO DRIVE AS IS.
NHTSA ODI #11054716
39,000 miles · Dec 12, 2017
Fuel/propulsion SystemPower Train
CAR STALLS AND COMPLETELY SHUTS OFF. TOLD ITS GAS AND NOT TO FILL UP GAS TANK. NOT SURE HOW THIS EFFECTS THE TRANSMISSION. CAR JERKS INTO GEAR OR RIGHT BEFORE SHUTTING OFF. SHAKES, IS LOUD. DOES THIS WITH OR WITHOUT FILLING UP THE TANK. CAR HAD BARELY HALF A TANK WHEN I PURCHASED IT AND IT DID IT THEN. THE VERY NEXT DAY. I HAVE …
Read full complaint
CAR STALLS AND COMPLETELY SHUTS OFF. TOLD ITS GAS AND NOT TO FILL UP GAS TANK. NOT SURE HOW THIS EFFECTS THE TRANSMISSION. CAR JERKS INTO GEAR OR RIGHT BEFORE SHUTTING OFF. SHAKES, IS LOUD. DOES THIS WITH OR WITHOUT FILLING UP THE TANK. CAR HAD BARELY HALF A TANK WHEN I PURCHASED IT AND IT DID IT THEN. THE VERY NEXT DAY. I HAVE AN EXTENDED WARRANTY. AND I BELIEVE THE POWER TRAIN WARRANTY STILL APPLIES BUT THEY WON'T FIX THE PROBLEM. KEEPS SAYING ITS NOT PULLING OR STORING CODES. ENGINE LIGHT AND SERVICE TRANSMISSION LIGHT COMES ON AND STAYS ON. NOT ON THE NEXT NEXT. HARD STARTS. TRANS IS SLIPPING. IT DOES THIS WHILE I'M DRIVING. EITHER AT TAKE OFF OR WHILE I'M SLOWING DOWN TO STOP IS WHEN IT SHUTS OFF. YOU CAN FEEL THE TRANS SLIPPING WHILE DRIVING. CAR IS NOISY SOMETIMES AND SLOW TO ACCELERATE. CAR ACTS LIKE IT GOING TO STALL WHILE DRIVING ON CITY STREET OR HIGHWAY. HAS SHUT OFF ON BOTH. I DO MOSTLY FREEWAY DRIVING. WAS TOLD THERE WAS A CASE INVOLVING MAKE YEAR AND MODEL OF MY CAR. I LOOKED IT UP AND THERE APPEARS TO BE A CLASS ACTION LAWSUIT IN REGARDS TO FAULTY TRANSMISSION AND CHRYSLER KNEW OF THIS. I WAS NOT TOLD ABOUT THIS WHEN I PURCHASED THE VEHICLE AND THE VEHICLE HAS BEEN DOING THIS SINCE I PURCHASED IT IN SEPTEMBER OF THIS YEAR. I HAVE TAKEN IT IN AND CALLED SEVERAL TIMES FOR THE SAME THING. THEY UPDATED THE COMPUTER AND REPLACED A PART AND NOW THEY ARE BASICALLY TELLING ME THEY DON'T KNOW WHAT THE PROBLEM IS EXCEPT THAT IT MAY BE FROM FILLING UP MY GAS TANK AND IT MAKING THE ENGINE STALL BUT NO SOLUTION TO FIX THE PROBLEM BESIDES NOT FILLING MY TANK I AM GUESSING. BUT NO EXPLANATION ON THE TRANS. JUST KEEPS SAYING ITS NOT STORING OR PULLING CODES. THIS IS DANGEROUS TO BE DRIVING A CAR THAT CAN SHUT OFF AT WILL WITH MY KIDS IN THE CAR.
NHTSA ODI #11054183
Official recalls
13May 11, 2023
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Additional source detail variants (2)
Structure:body:hatchback/liftgate
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Electrical System:wiring: Rear Compartment/trunk
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Jun 11, 2020
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence & remedy
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Additional source detail variants (2)
Power Train:driveline:differential Unit
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Power Train:automatic Transmission
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Jun 13, 2019
Chrysler (FCA US LLC) is recalling certain 2014 Jeep Cherokee vehicles equipped with 3.2L engines. In the event that a clutch becomes stuck in the transmission, the transmission software may shift the transmission to neutral.
Consequence & remedy
Consequence: An unexpected shift to neutral would result in a loss of drive, increasing the risk of crash.
Remedy: Chrysler will notify owners, and dealers will update the transmission software, free of charge. The recall began August 8, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V69.
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Dec 21, 2017
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.
Aug 10, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence & remedy
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Additional source detail variants (2)
Seats:mid/rear Assembly
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Seats
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Jul 12, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee and 2015 Chrysler 200, Jeep Renegade, RAM ProMaster, and 2016 Fiat 500X vehicles equipped with 9-speed automatic transmissions. The transmission sensor clusters may have insufficient crimps in the transmission wire harness, and as a result, the transmission may unexpectedly shift to neutral. On August 29, 2016 Chrysler added the 2016 Fiat 500X vehicles to this recall.
Consequence & remedy
Consequence: If the vehicle unexpectedly shifts to neutral, there is an increased risk of a crash.
Remedy: Chrysler will notify owners, dealers will reprogram the Powertrain Control Module and the Transmission Control Module and if necessary replace the transaxle range sensor wire harness, free of charge. The recall began on November 7, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S55.
Aug 12, 2015
Chrysler (FCA US LLC) is recalling certain model year 2014 Jeep Cherokee vehicles manufactured January 4, 2013, to July 11, 2014. Use of the front windshield wipers on dry glass may cause damage to the body control module (BCM).
Consequence & remedy
Consequence: BCM damage may result in the failure of the windshield wipers, impairing the driver's vision and increasing the risk of a vehicle crash.
Remedy: Chrysler will notify owners, and dealers will install a ground strap to protect the BCM from damage, free of charge. Owners were notified of the recall on October 7, 2015. The recall began on December 15, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R39.
Jul 23, 2015
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, 3500, 4500, and 5500, 2015 Chrysler 200, Chrysler 300, Dodge Charger, and Dodge Challenger, 2014-2015 Jeep Grand Cherokee, Cherokee, and Dodge Durango, and 2013-2015 Dodge Viper vehicles. The affected vehicles are equipped with radios that have software vulnerabilities that can allow third-party access to certain networked vehicle control systems.
Consequence & remedy
Consequence: Exploitation of the software vulnerability may result in unauthorized remote modification and control of certain vehicle systems, increasing the risk of a crash.
Remedy: Chrysler will notify and mail affected owners a USB drive that includes a software update that eliminates the vulnerability, free of charge. Optionally, owners may download the update to their own USB drive from http://www.driveuconnect.com/software-update/ or take their vehicle to a Chrysler dealer for immediate installation. In an effort to mitigate the effects of this security vulnerability, Chrysler has had the wireless service provider close the open cellular connection to the vehicle that provided unauthorized access to the vehicle network. This measure may not have been implemented on all vehicles and does not address access by other means that will be remedied by the software update. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R40.
Jun 22, 2015
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 4, 2013, to February 18, 2015 and equipped with a Power Liftgate option. In the affected vehicles, water may enter the Power Liftgate Control Module and cause a high resistance short circuit in the module.
Consequence & remedy
Consequence: A short circuit in the liftgate control module may result in a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the power liftgate control module and connectors for corrosion, substitute a bolt for the threaded grommet installed to seal an attachment point used in non-power liftgate vehicles and cover the power liftgate control module in a foam water shield, free of charge. The recall began on October 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R27. This recall is superseded by NHTSA recall 23V-338.
Jan 28, 2015
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence & remedy
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Additional source detail variants (2)
Air Bags:side/window:curtain
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Air Bags:side/window
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Jul 2, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Jeep Cherokee and Ram 1500 and 2015 Chrysler 200 vehicles. Due to an insufficient weld, the rear shocks may detach from the vehicle at one end and possibly damage other chassis components, the tire or result in reduced braking.
Consequence & remedy
Consequence: Damage to the tire or reduced braking increases the risk of a vehicle crash.
Remedy: Chrysler will notify owners, and dealers will inspect the rear shocks and replace any affected ones, free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P37.
Jun 4, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Dodge Durango vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee SRT vehicles manufactured February 3, 2014 to April 8, 2014, and Jeep Cherokee vehicles manufactured March 6, 2014 to April 17, 2014. When the adaptive cruise control is engaged and the driver presses the accelerator pedal to increase the vehicle's speed more than the cruise control system would on its own, the vehicle may continue to accelerate briefly after the accelerator pedal is released.
Consequence & remedy
Consequence: The unintended continued acceleration may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the Driver Assistance System Module (DASM), free of charge. The recall began in June 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P31.
Additional source detail variants (2)
Forward Collision Avoidance: Adaptive Cruise Control
Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Dodge Durango vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee SRT vehicles manufactured February 3, 2014 to April 8, 2014, and Jeep Cherokee vehicles manufactured March 6, 2014 to April 17, 2014. When the adaptive cruise control is engaged and the driver presses the accelerator pedal to increase the vehicle's speed more than the cruise control system would on its own, the vehicle may continue to accelerate briefly after the accelerator pedal is released.
Consequence: The unintended continued acceleration may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the Driver Assistance System Module (DASM), free of charge. The recall began in June 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P31.
Vehicle Speed Control:accelerator Pedal
Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Dodge Durango vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee vehicles manufactured January 16, 2014 to April 8, 2014, Jeep Grand Cherokee SRT vehicles manufactured February 3, 2014 to April 8, 2014, and Jeep Cherokee vehicles manufactured March 6, 2014 to April 17, 2014. When the adaptive cruise control is engaged and the driver presses the accelerator pedal to increase the vehicle's speed more than the cruise control system would on its own, the vehicle may continue to accelerate briefly after the accelerator pedal is released.
Consequence: The unintended continued acceleration may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the Driver Assistance System Module (DASM), free of charge. The recall began in June 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P31.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE22009 · Electronic Parking Brake Water Ingress
Opened Jul 22, 2022 · Closed Oct 29, 2023
Status: closed (inferred from source dates) · Parking Brake:electrical; Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Parking Brake:electrical
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
RQ15004 · Software Security Vulnerability
Opened Jul 24, 2015 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Electrical System:software
On July 23, 2015, Fiat Chrysler Automobiles (FCA) launched Safety Recall 15V-461 to remedy security vulnerabilities in approximately 1.4 million model year (MY) 2013 through 2015 vehicles equipped with Uconnect head units (HU) 8.4A (RA3 radio) and 8.4AN (RA4 radio) manufactured by Harman International.On July 24, 2015, the Office of Defects Investigation (ODI) opened Recall Query, RQ 15-004, to investigate HU security vulnerabilities and remedy effectiveness in the recalled population and to determine whether similar units have been supplied for use in other FCA vehicles.In an August 11, 2015 letter, FCA submitted a second Part 573 safety recall report expanding the scope of the Uconnect RA4 model radio to include additional 7,810 MY 2015 Jeep Renegade vehicles manufactured from September 18, 2014 through June 25, 2015 (Recall 15V-508).Scope analysis indicated that Uconnect radios installed in FCA vehicles not included in recalls 15V-461 or 15V-508 (subject recalls) are not equipped with built-in cellular access or short range wireless communication features and, thus, do not contain the security vulnerabilities addressed by the subject recalls. SUBJECT VEHICLES: MY2014 through 2015 Dodge Durango, Jeep Grand Cherokee and Jeep Cherokee sport utility vehicles; MY2013 through 2015 Ram 1500, 2500, 3500 and 4500/5500 pickup trucks; MY2013 through 2015 Dodge Viper vehicles; and MY2015 Chrysler 200, 300, Jeep Renegade, Dodge Charger and Challenger vehicles.According to FCA, long and short range wireless vulnerabilities identified in the recalled vehicles could allow unauthorized third-party access to, and manipulation of, networked vehicle control systems.Successful exploitation of the vulnerabilities, coupled with reverse engineering of networked microprocessor control modules, could result in unauthorized manipulation of vehicle control systems. This unauthorized manipulation of vehicle controls and systems could expose the driver, vehicle occupants or other highway users to an increased risk of injury.FCA and its network provider, Sprint, conducted a nationwide campaign to block access to a radio communications port that was unintentionally left open.On July 27, 2015, short range wireless vulnerabilities were also blocked.Finally, third party security evaluation and regression testing identified vulnerabilities that were either remedied by Sprint or through updates to the FCA Uconnect software.ODI identified a total of 30 complaints or field reports on unique vehicles submitted by FCA (29) or received by NHTSA (1) alleging incidents of theft from a vehicle or anomalous performance that the owner alleged were caused by, or may have been caused by, remote hacking.Twenty-six (87%) of these reports were submitted after a magazine article was published on July 21, 2015, describing the remote hacking of an FCA vehicle by researchers who were able to affect the operation of various vehicle control systems, including the service brakes, steering, throttle and ignition.Most of the complaints involved vehicle systems that were not safety critical (e.g., complaints related to radio, navigation system, or air-conditioning control) and did not affect vehicle control.Three complaints reported engine stalls.One owner reported sudden unintended acceleration allegedly related to hacking.None of the complaints or field reports reviewed involved the steering and braking vehicle control effects demonstrated by the research hackers prior to the recall.There were no confirmed incidents of hacking in any of the records reviewed by ODI.The remedies completed by Sprint and FCA appear to have eliminated vulnerabilities that mi
Illustration