IllustrationWHILE PARKED AND IDLING, VEHICLE JUMPS OUT OF GEAR INTO REVERSE AND WENT BACKWARD INTO A FENCE. DRIVER SUSTAINED INJURIES TO HIS RIGHT KNEE. *AK *JG
2001 Jeep Cherokee
Owner reports · Recalls · Investigations
More warning signs than most Cherokee years
Owner complaints for the 2001 Jeep Cherokee are substantially higher than the model-year median of 113.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cherokee years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
260–25K
1525–50K
2250–75K
1475–100K
19100–150K
8150K+
104 reports with mileage · 125 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports13 fire reports15 injury reports
What owners actually said
229 reportsREPLACEMENT FAILED 12/05/2001 AT 16,709 MILES. THIS REPLACEMENT APPEARS TO BE FAILING AGAIN. STRONG ODOR AND INTERMITTENT HOWLING FROM REAR END. ODOR WAS ATTRIBUTED BY DEALER ON PREVIOUS FAILURE TO BURNT SYNTHETIC OIL USED IN DIFFERENTIAL. *AK
WHILE TRAVELING OVER THE HOWARD-FRANKLIN BRIDGE, (THIS IS A 6 MONTH OLD 2001 JEEP CHEROKEE GRAND LAREDO WITH 13000 MILES) HEADING INTO TAMPA, FLORIDA AT A RATE OF 65 MPH MY DRIVERSIDE REAR TIRE OUTER SIDEWALL FAILED AND INSTANTLY WENT FLAT AND COULD HAVE CAUSED A FATAL ACCIDENT, NOT TO MENTION, CAUSING THE JEEP TO DROP HARD ON …
Read full complaint
WHILE TRAVELING OVER THE HOWARD-FRANKLIN BRIDGE, (THIS IS A 6 MONTH OLD 2001 JEEP CHEROKEE GRAND LAREDO WITH 13000 MILES) HEADING INTO TAMPA, FLORIDA AT A RATE OF 65 MPH MY DRIVERSIDE REAR TIRE OUTER SIDEWALL FAILED AND INSTANTLY WENT FLAT AND COULD HAVE CAUSED A FATAL ACCIDENT, NOT TO MENTION, CAUSING THE JEEP TO DROP HARD ON THE ROAD WITH THE RIM, THEREBY DAMAGING MY WHEEL RIM AND RENDERING THE TIRE USELESS. A FLORIDA ROAD RANGER ASSISTED ME AND CHANGED MY TIRE WITH THE SPARE. MY TIRE DID NOT HIT ANY OBJECT NOR DID ANY OBJECT HIT MY TIRE. I CONTACTED GOODYEAR AND SHOWED THEM THE TIRE AT THEIR GOODYEAR TIRE CENTER LOCATED AT 7511 49TH STREET, PINELLAS PARK, FLORIDA 33782..(727) 547-8422. THEY WOULD NOT REPLACE THE TIRE UNTIL I GAVE THEM MY OLD TIRE TO BE SHIPPED, AT MY EXPENSE, TO CORPORATE GOODYEAR'S TEST LABS. A LITTLE LIKE THE FOX WATCHING THE HEN HOUSE IN MY OPINION. I GOT ALOT OF BS FROM GOODYEAR AND EXPLAINATIONS ABOUT THE TIRE FAILURE THAT WITH A LITTLE COMMON SENSE DIDN'T ADD UP. THIS TIRE IS VISUALLY A DEFECT FROM THE LOOKS OF THE TREAD SEPERATION FROM THE SIDEWALL, JUST LIKE I HAVE SEEN ON THE NEWS WITH THE FIRESTONE TIRES. THE LOCAL GOODYEAR DEALER DIDN'T SATISFY ME AND DIDN'T EVEN CARE ABOUT MY NEEDS SO, I CONTACTED GOODYEAR CORPORATE BY PHONE. THEY TOLD ME THAT THE SIDEWALL LOOKED ALL SHREDED UP BECAUSE THE TIRE ROLLED ON ITSELF DEFLATED AT THE 65 MPH SPEED AS I COASTED TO AT STOP ( THANK GOD I DIDN'T PANIC AND USE MY BRAKES) ( IN HEAVY RUSH HOUR TRAFFIC ON A FOUR LANE BRIDGE TRAVELING IN THE THIRD LANE ). IF THEIR THEORY ABOUT SHREDING IS TRUE, WHY DIDN'T THE INTERIOR SIDEWALL GET SHREDED? IT LOOKS LIKE NEW. THEY'RE FULL OF EXCUSES. I WANT ALL OF THESE TIRES OFF MY TRUCK. IF I HAVE MY FAMILY RIDING IN THIS VEHICLE I DON'T FEEL SAFE KNOWING WHAT MIGHT OCCUR. PLEASE TAKE A LOOK AT MY TIRE. I KNOW SOMETHING IS VERY WRONG WITH THE WAY IT WAS CONSTRUCTED AND CAME APPART. THANK YOU. THIS IS MY SECOND REQUEST IN 4 MONTHS. THOMAS A. NERVINA
VEHICLE WAS PARKED ON A SLIGHT DOWNHILL GRADE, GEAR SELECTOR IN PARK, WITH THE ENGINE RUNNING. AFTER A PERIOD OF TIME LESS THAN 5 MINUTES, THE VEHICLE CAME OUT OF PARK ON ITS OWN AND BEGAN TO ROLL FORWARD, CRASHING THROUGH A FENCE, SMALL TREES AND SHRUBS, THEN DOWN AN ENBANKMENT. THE VEHICLE SUSTAINED SEVERE DAMAGE AND IS PROB…
Read full complaint
VEHICLE WAS PARKED ON A SLIGHT DOWNHILL GRADE, GEAR SELECTOR IN PARK, WITH THE ENGINE RUNNING. AFTER A PERIOD OF TIME LESS THAN 5 MINUTES, THE VEHICLE CAME OUT OF PARK ON ITS OWN AND BEGAN TO ROLL FORWARD, CRASHING THROUGH A FENCE, SMALL TREES AND SHRUBS, THEN DOWN AN ENBANKMENT. THE VEHICLE SUSTAINED SEVERE DAMAGE AND IS PROBABLY A TOTAL LOSS.*AK
WHILE PARKED, ENGINE COMPARTMENT CAUGHT ON FIRE, CLAIM 22-V664-585. *SLC
CLUTCH MAKES A NOISE WHEN CONSUMER PUSHES CLUTCH IN. CONSUMER HAS TAKEN VEHICLE INTO DEALER 11 TIMES IN PAST 6 MONTHS. PLEASE PROVIDE MORE INFORMATION.*AK
ROTORS ARE PITTED LESS THAN 20000 MILES. WHEN APPLYING BRAKES VEHICLE IS NOT STOPPING PROPERLY. VEHICLE HAS A PULSATING ACTION. CONTACTED DEALER, AND DEALER URGED CONSUMER TO BRING VEHICLE IN . PLEASE ADD VIN. *AK
WHILE TRAVELING, AND AS A RESULT OF BEING REAR ENDED AND PUSHED INTO ANOTHER VEHICLE, AIR BAGS DID NOT DEPLOY.*AK *SLC
I HAVE BEEN CONCERNED ABOUT THE BRAKING SYSTEM AS THE SHOES WERE CRACKED AND NEEDED TO BE REPLACED AT 5745 MILES. AT 12503 MILES THE ROTORS NEEDED TO BE RESURFACED. NOW AT 15, 200 MILES I STILL FEEL A VIBRATION UPON APPLYING THE BRAKES AND THE SERVICE DEPARTMENT HAS BEEN VERY PATRONIZING. THEY STATE IT'S MY TIRES. THE GOODYE…
Read full complaint
I HAVE BEEN CONCERNED ABOUT THE BRAKING SYSTEM AS THE SHOES WERE CRACKED AND NEEDED TO BE REPLACED AT 5745 MILES. AT 12503 MILES THE ROTORS NEEDED TO BE RESURFACED. NOW AT 15, 200 MILES I STILL FEEL A VIBRATION UPON APPLYING THE BRAKES AND THE SERVICE DEPARTMENT HAS BEEN VERY PATRONIZING. THEY STATE IT'S MY TIRES. THE GOODYEAR TIRE DEALER STATED THAT IF THERE IS VIBRATION UPON APPLYING THE BRAKES IT IS NOT THE TIRES BUT IT IS THE BRAKES. THE SERVICE DEPARTMENT AT ACTION MOTORS HAS BEEN STALLING ME SO THAT THE CAR REACHES 18000 MILES AND WILL BE INELIGIBLE FOR THE LEMON LAW RETURN. I BELIEVE THERE ARE OTHER JEEP OWNERS WITH THE SAME PROBLEM. I'VE SPOKEN TO SEVERAL JEEP OWNERS AND THEY STATED THEY HAD THE SAME PROBLEM.. UNFORTUNATELY I DID NOT GET ANYONE'S NAMES AND ADDRESSES BUT I BELIEVE THAT THE NHTSA SHOULD INVESTIGATE ALL THE SERVICE RECORDS OF THE JEEP CHEROKEE TO ASCERTAIN HOW MANY PERSONS HAD PROBLEMS WITH THE BRAKING SYSTEM. THANK YOU ROSALIE CICOGNA. *AK
@ 3000 MILES CAR SHUDDERS WHEN BRAKING, TOLD OPERATING TO FACTORY SPECS. INDEPENDENT MECHANIC SAID NO, DEALER TURNED ROTORS, @ 7500 PROBLEM RECURRED,@ 11,000 OTHER DEALER REPLACED ROTORS AS ORIGINALS WERE TOO WARPED TO MACHINE, @ 15,000 SAME PROBLEM, @ 18,000 DEALER AGAIN MACHINED ROTORS AS A "GOODWILL SERVICE. " *AK
Official recalls
202V104000 · Fuel System, Gasoline:fuel Injection System:injectors
Apr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V366000 · Child Seat
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by