IllustrationAIR BAG LIGHT ILLUMINATED WHILE DRIVING. DEALER WAS CONTACTED.*AK
2001 Jeep Cherokee
Owner reports · Recalls · Investigations
More warning signs than most Cherokee years
Owner complaints for the 2001 Jeep Cherokee are substantially higher than the model-year median of 113.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cherokee years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
260–25K
1525–50K
2250–75K
1475–100K
19100–150K
8150K+
104 reports with mileage · 125 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports13 fire reports15 injury reports
What owners actually said
229 reportsCONSUMER WAS COMPLAINING ABOUT A DIFFERENTIAL PROBLEM. THE BEARINGS WERE GRINDING. CONSUMER TOOK VEHICLE TO THE DEALER ON 4 DIFFERENT OCCASIONS, BUT PROBLEM RECURRED. *AK
WHILE DRIVING, THE CRUISE CONTROL DIDN'T SET THE SPEED WHEN ENGAGED. THE VEHICLE WAS TAKEN TO A DEALERSHIP, WHO INDICATED THAT A CLOCK SPRING FAILURE CAUSED THE CRUISE CONTROL TO MALFUNCTION. THE HORN IS ALSO NOT OPERATIONAL. THE CLOCK SPRING WILL BE REPLACED.*AK THE RIGHT FRONT DOOR CONTAINED RUST
CONSUMER COMPLAINED ABOUT ABOUT REAR DIFFERENTIAL. CONSUMER TOOK VEHICLE TO DEALER FOR SERVICING ON 4 OCCASIONS, AND IT WAS MAKING A GRINDING NOISE 8 MONTHS LATER. WARRANTY EXPIRED, AND CONSUMER WAS ASKED TO PAY $500.00 FOR REPAIRS. CONSUMER WAS TOLD THAT THERE WAS METAL IN THE BOTTOM OF DIFFERENTIAL. *AK
WHEN DRIVING CONSUMER NOTICED THAT DRIVER'S SIDE SEAT BROKE OFF THE TRACK. CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP FOR REPAIRS. *AK THE CONSUMER HAD TO PAY FOR THE REPLACEMENT OF THE SEAT TRACK BECAUSE THE VEHICLE WAS NO LONGER UNDER WARRANTY. *NM
WHEN DRIVING WITH THE CRUISE CONTROL SET AT 60 MPH AND GOING UP A HILL THE VEHICLE ACCELERATED WITHOUT WARNING. WHEN THE DRIVER ATTEMPTED TO DISENGAGE THE CRUISE CONTROL THE VEHICLE WENT FASTER TO 80 MPH. TO STOP THE VEHICLE THE DRIVER HAD TO PUT THE VEHICLE INTO NUETRAL. NO IMPACT REPORTED. PLEASE PROVIDED ADDITIONAL INFORMATIO…
Read full complaint
WHEN DRIVING WITH THE CRUISE CONTROL SET AT 60 MPH AND GOING UP A HILL THE VEHICLE ACCELERATED WITHOUT WARNING. WHEN THE DRIVER ATTEMPTED TO DISENGAGE THE CRUISE CONTROL THE VEHICLE WENT FASTER TO 80 MPH. TO STOP THE VEHICLE THE DRIVER HAD TO PUT THE VEHICLE INTO NUETRAL. NO IMPACT REPORTED. PLEASE PROVIDED ADDITIONAL INFORMATION. *JB
PROBLEMS WITH STANDING WATER IN THE FOOTWELL, FAILED AIR CONDITIONER, RUBBING FAN AND DOOR ADJUSTMENTS. *MR THERE WAS STANDING WATER IN THE PASSENGER FOOT WELL. THE VEHICLE ALSO NEEDED NEW BRAKES DUE TO RUSTED ROTORS. THE CONSUMER REQUESTED REIMBURSEMENT. *SC *JB
BRAKES ON A JEEP CHEROKEE. THE BRAKES ON MY 2001 JEEP CHEROKEE HAVE STARTED SHAKING THE CAR RAPPIDLY WHEN THE BRAKES ARE APPLIED AT FREEWAY SPEEDS. I HAVE CONTACTED THE DEALER AND HAVE BEEN INFORMED THAT THIS IS NOT A WARRANTY ISSUE. I ALSO CALLED A LOCAL MEINEKE LOCATION AND WAS TOLD THAT THIS IS A COMMON ISSUE WITH MOST CHEROK…
Read full complaint
BRAKES ON A JEEP CHEROKEE. THE BRAKES ON MY 2001 JEEP CHEROKEE HAVE STARTED SHAKING THE CAR RAPPIDLY WHEN THE BRAKES ARE APPLIED AT FREEWAY SPEEDS. I HAVE CONTACTED THE DEALER AND HAVE BEEN INFORMED THAT THIS IS NOT A WARRANTY ISSUE. I ALSO CALLED A LOCAL MEINEKE LOCATION AND WAS TOLD THAT THIS IS A COMMON ISSUE WITH MOST CHEROKEE'S. THE RESULT IS THAT THIS WILL COST ME $300 FOR A PROBLEM THAT SHOULD BE COVERED UNDER A RECALL.*AK
THIS IS A SERIOUS PROBLEM THAT JEEP KNOWS ABOUT, BUT I DON'T THINK THEY KNOW HOW TO FIX IT. IT'S COMMONLY REFERRED TO AS THE "DEATH WOBBLE" -- AND I GATHER THAT IT MIGHT BE MORE COMMON AMONGST JEEPS THAT ARE LIFTED, THOUGH MINE HAS NOT BEEN LIFTED. SATURDAY, MAY 15, 2004. DRIVING AT FREEWAY SPEED. VEERED INTO LEFT LANE TO…
Read full complaint
THIS IS A SERIOUS PROBLEM THAT JEEP KNOWS ABOUT, BUT I DON'T THINK THEY KNOW HOW TO FIX IT. IT'S COMMONLY REFERRED TO AS THE "DEATH WOBBLE" -- AND I GATHER THAT IT MIGHT BE MORE COMMON AMONGST JEEPS THAT ARE LIFTED, THOUGH MINE HAS NOT BEEN LIFTED. SATURDAY, MAY 15, 2004. DRIVING AT FREEWAY SPEED. VEERED INTO LEFT LANE TO AVOID CARS THAT WERE SLOWING IN MY LANE. I STEPPED ON THE BRAKE AS I MOVED INTO THE LEFT LANE. STEERING WHEEL AND WHOLE FRONT OF CAR SHOOK VIOLENTLY TO THE POINT IT FELT THAT IT WAS GOING TO FALL APART. TOOK FOOT OFF GAS/BRAKE AND AS THE CAR SLOWED DOWN IT STOPPED SHAKING AFTER ABOUT 5-10 SECONDS. PULLED INTO FAR LEFT SHOULDER B/C I WAS SHAKEN UP, THEN PROCEEDED HOME. I TOOK THE CAR TO A BRAKE SHOP. MY CAR HAD 18,000 MILES ON IT AND YET THE ROTORS WERE WARPED, SO I HAD THE ROTORS AND BRAKE PADS REPLACED. TUESDAY, MAY 25, 2004. SAME FREEWAY INCIDENT FROM ABOVE OCCURRED. DID SOME RESEARCH ON THE INTERNET AND QUICKLY FOUND "DEATH WOBBLE," ON A VARIETY OF SITES ABOUT JEEPS. DISCOVERED PROBLEM MIGHT BE AN ALIGNMENT PROBLEM, SO I HAD MY CAR ALIGNED AND THE TIRES BALANCED. SUNDAY, JUNE 20, 2004. CAR SHOOK AGAIN ON FREEWAY. HAD BEEN TOLD BY A FRIEND THAT TURNING THE WHEEL SLIGHTLY TO THE RIGHT MIGHT STOP THE SHAKING. I DID THIS AND THE SHAKING STOPPED. SATURDAY, JULY 03, 2004. CAR SHOOK WHILE GOING THROUGH 9TH ST. TUNNEL IN WASHINGTON DC. TOOK CAR TO ROSENTHAL JEEP. WROTE LENGTHLY DESCRIPTION OF THE PROBLEM ON THE DROP-OFF ENVELOPE. ASKED THAT THEY CHECK OUT THE ENTIRE FRONT OF THE CAR. JEEP REPLACED THE STEERING DAMPER -- WHICH WAS "LEAKING." SATURDAY, JULY 10, 2004. CAR SHOOK ON FREEWAY. CALLED ROSENTHAL JEEP AT 2:57PM. A WOMAN IN THE SERVICE DEPARTMENT LISTENED TO MY PROBLEM, PUT ME ON HOLD AND THEN PUT ME INTO A MALE'S VOICEMAIL. HAVE YET TO RECEIVE A RETURN PHONE CALL. *LA
PURCHASED A NEW 2001 JEEP CHEROKEE SPORT. WHEN BRAKES APPLIED CAR WEAVED OR PULLED TO THE LEFT. (2) EMERGENCEY STOP ON MAJOR HWY. 2 AM FRONT END SHOOK VIOLENTLY AND PULLED MY CAR ONTO THE CENTER GRASS DIVIDER.(3) RETURNED JEEP TO DEALER. SERVICE MANAGER COULD NOT REPLICATE PROBLEM. BROUGHT CAR TO INDEPENDENT BRAKE REPAIR SHOP. R…
Read full complaint
PURCHASED A NEW 2001 JEEP CHEROKEE SPORT. WHEN BRAKES APPLIED CAR WEAVED OR PULLED TO THE LEFT. (2) EMERGENCEY STOP ON MAJOR HWY. 2 AM FRONT END SHOOK VIOLENTLY AND PULLED MY CAR ONTO THE CENTER GRASS DIVIDER.(3) RETURNED JEEP TO DEALER. SERVICE MANAGER COULD NOT REPLICATE PROBLEM. BROUGHT CAR TO INDEPENDENT BRAKE REPAIR SHOP. REPLACED PADS, AND INSTALLED NEW ROTORS. TWO DAYS LATER CAR SHOOK VIOLENTLY UPON BRAKING AT 45MPH. RETURNED TO LITHIA COLORADO JEEP DEALER. STATED WARPED ROTORS. REPLACED ROTORS AND PADS. PROBLEM IS ON GOING AND WILL NOW NEED TO HAVE REPAIRS DONE A THIRD TIME IN 24.000 MILES. GENERAL MANAGER OF LITHIA STATES HE CAN REPAIR BRAKES BUT NOT SOLVE THE PROBLEM BECAUSE BOTH HE AND CHRYSLER KNOW THE ROTORS ARE DEFECTIVE THEY SIMPLY REPLACE THE OLD ROTORS WITH NEW DEFECTIVE ROTORS. 35 EXACT PROBLEMS REPORTED ON WWW.MYCARSTATS.COM IN THE LAST 90 DAYS. *AK
Official recalls
202V104000 · Fuel System, Gasoline:fuel Injection System:injectors
Apr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V366000 · Child Seat
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by