IllustrationGOT HOME SHUT OFF VEHICLE OPENED LIFTGATE WENT TO BATHROOM LOOKED OUT WINDOW A FIRE STARTED FROM INTERIOR LIGHT WITHIN 10 MINUTES WAS A TOTAL LOSS. *TR
2001 Jeep Cherokee
Owner reports · Recalls · Investigations
More warning signs than most Cherokee years
Owner complaints for the 2001 Jeep Cherokee are substantially higher than the model-year median of 113.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cherokee years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
260–25K
1525–50K
2250–75K
1475–100K
19100–150K
8150K+
104 reports with mileage · 125 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports13 fire reports15 injury reports
Exterior Lighting complaints
10 reportsI HAVE TWO JEEP GRAND CHEROKEES AND HAVE HAD NOTHING BUT PROBLEMS WITH BOTH INVOLVING THE REAR TAIL/BRAKE LIGHTS. I HAVE REPLACED THE BULBS ON AND OFF FOR THE LAST 10 YEARS AND LAST YEAR I REPLACE THE ENTIRE LIGHT HOUSING. I AM EXPERIENCING THIS WITH BOTH VEHICLES AND HAVE NOTICE MANY OTHER JEEPS ON THE ROAD WITH THEIR TAIL L…
Read full complaint
I HAVE TWO JEEP GRAND CHEROKEES AND HAVE HAD NOTHING BUT PROBLEMS WITH BOTH INVOLVING THE REAR TAIL/BRAKE LIGHTS. I HAVE REPLACED THE BULBS ON AND OFF FOR THE LAST 10 YEARS AND LAST YEAR I REPLACE THE ENTIRE LIGHT HOUSING. I AM EXPERIENCING THIS WITH BOTH VEHICLES AND HAVE NOTICE MANY OTHER JEEPS ON THE ROAD WITH THEIR TAIL LIGHT OR BRAKE LIGHTS NOT PROPERLY WORKING. THIS IS AN ONGOING PROBLEM. THE TAIL LIGHTS WORK SOMETIMES BUT THE BRAKE LIGHTS MAY NOT WORK AT ALL, VERY FRUSTRATING. WHEN THERE HAVE BEEN TIMES WHEN THE TAIL LIGHTS WILL WORK AND THE BRAKE LIGHT WILL NOT, BOTH USING THE SAME BULB. THIS IS A VERY DANGEROUS SITUATION WHEN APPLYING THE BREAKS AND HAVING THE LIGHTS ON THE REAR OF MY VEHICLE NOT INDICATE THAT I AM STOPPING OR IN FACT MAKING MY VEHICLE LESS NOTICEABLE. I HAVE HEARD THERE ARE NUMEROUS COMPLAINTS FOR THIS SAME PROBLEM. I AM HAVING THE SAME PROBLEM WITH BOTH VEHICLES - NOT A COINCIDENT BUT A MANUFACTURES DEFEAT. *JS
TL* THE CONTACT OWNS 2001 JEEP GRAND CHEROKEE. THE CONTACT STATED THAT THE DRIVERS SIDE BRAKE LIGHT FAILED TO WORK WHEN THE HEADLIGHTS WERE TURNED ON. THE FAILURE WAS NOT DIAGNOSED BY THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 176,000.
DON'T BUY A JEEP! PIECE OF JUNK. SINCE I HAVE OWNED MINE THE FOLLOWING HAS BROKE RADIATOR, SEAT TRACK, POWER WINDOW MOTOR, BRAKES, BLOWOUT, TRANSMISSION, HEADLIGHT COVERS DULLED, MULTIPLE REAR LIGHT OUTAGES, INSIDE LIGHTS OUT. *TR
TL*THE CONTACT OWNS A 2001 JEEP CHEROKEE. THE CONTACT STATED THAT THE SECURITY SYSTEM ALARM KEPT SOUNDING IN THE VEHICLE. THE ALARM, HORN, AND ALL THE LIGHTS WOULD ACTIVATE. THE CONTACT WOULD HAVE TO WAIT 30-45 MINUTES BEFORE THE FAILURES WOULD STOP. THE FAILURE OCCURRED WHILE DRIVING OR WHEN THE VEHICLE WAS PARKED. THE DEA…
Read full complaint
TL*THE CONTACT OWNS A 2001 JEEP CHEROKEE. THE CONTACT STATED THAT THE SECURITY SYSTEM ALARM KEPT SOUNDING IN THE VEHICLE. THE ALARM, HORN, AND ALL THE LIGHTS WOULD ACTIVATE. THE CONTACT WOULD HAVE TO WAIT 30-45 MINUTES BEFORE THE FAILURES WOULD STOP. THE FAILURE OCCURRED WHILE DRIVING OR WHEN THE VEHICLE WAS PARKED. THE DEALER INSTALLED A NEW BATTERY TO CORRECT THE FAILURE. THE DEALER PLACED A KEY IN THE IGNITION SWITCH AND THE KEY BECAME STUCK. THE DEALER ALSO INSTALLED A NEW COMPUTER, WHICH DID NOT REMEDY THE FAILURE. THE COMPUTER WAS PRONOUNCED AS DEFECTIVE AND ANOTHER ONE WAS ORDERED. THE REPLACEMENT COMPUTER DID NOT CORRECT THE ISSUE EITHER. THE MANUFACTURER STATED THAT THEY WOULD NOT BE ABLE TO ASSIST IF THE FAILURE COULD NOT BE DUPLICATED. THE CURRENT MILEAGE WAS 44,404 AND FAILURE MILEAGE WAS APPROXIMATELY 40,000.
2001 JEEP CHEROKEE REAR BRAKE AND TURN SIGNAL LIGHTS REPEATEDLY BURN OUT. *KB *JB
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE STALLED WITHOUT WARNING. ALSO, THE LOW BEAM STOPPED WORKING. BOTH PROBLEMS OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO COULD NOT DUPLICATE EITHER PROBLEM.
DT*: THE CONTACT STATED THAT THE VEHICLE'S REAR BRAKE LIGHTS BURNS OUT REPEATEDLY. THE VEHICLE HAS NOT BEEN TAKEN TO THE DEALERS FOR FURTHER.
THERE IS VIBRATION IN THE STEERING WHEEL. GEARS ARE STUCK WHEN TRYING TO CHANGE GEARS. DEALERSHIP IS AWARE OF PROBLEM.*AK STEERING WHEEL DOES NOT LOCK. CONSUMER FEELS VIBRATION IN STEERING WHEEL, GAS PEDAL, PASSENGER DOOR, GEAR SHIFT, AND PASSENGER SEAT, CONSUMER HEARS A NOISE THAT SOUNDS LIKE IT IS COMING FROM THE RIMS. AIR …
Read full complaint
THERE IS VIBRATION IN THE STEERING WHEEL. GEARS ARE STUCK WHEN TRYING TO CHANGE GEARS. DEALERSHIP IS AWARE OF PROBLEM.*AK STEERING WHEEL DOES NOT LOCK. CONSUMER FEELS VIBRATION IN STEERING WHEEL, GAS PEDAL, PASSENGER DOOR, GEAR SHIFT, AND PASSENGER SEAT, CONSUMER HEARS A NOISE THAT SOUNDS LIKE IT IS COMING FROM THE RIMS. AIR CONDITIONER SWITCH NEEDED RESET. HOOD IS OUT OF LINE, DRIVERS SIDE DOOR PANEL NEEDS REPLACING AND THERE IS A GAP AT THE TOP OF THE OUTSIDE. ENGINE LIGHT IS ILLUMINATED. GLOVE BOX LIGHT WENT OUT. UPPER BALL JOINT WAS REPLACED. *JB
WHILE DRIVING ON HIGHWAY AT 70 MPH AND WITHOUT WARNING, HEADLIGHTS WENT COMPLETELY OUT CAUSING POOR VISIBILITY WHICH RESULTED IN AN ACCIDENT, CONSUMER REARENDED ANOTHER VEHICLE CAUSING ONE INJURY, UPON IMPACT THE AIRBAGS DID NOT EXPERIENCE DEPLOYMENT, CONSUMER HAD BEEN TO DEALER SEVERAL TIMES DUE TO TAILLIGHTS INOPERABLE AND HEA…
Read full complaint
WHILE DRIVING ON HIGHWAY AT 70 MPH AND WITHOUT WARNING, HEADLIGHTS WENT COMPLETELY OUT CAUSING POOR VISIBILITY WHICH RESULTED IN AN ACCIDENT, CONSUMER REARENDED ANOTHER VEHICLE CAUSING ONE INJURY, UPON IMPACT THE AIRBAGS DID NOT EXPERIENCE DEPLOYMENT, CONSUMER HAD BEEN TO DEALER SEVERAL TIMES DUE TO TAILLIGHTS INOPERABLE AND HEADLAMPS INOPERABLE PRIOR TO ACCIDENT, DEALER REPLACED FUSES AND FOUND CONNECTOR'S LOOSE. CONSUMER STATES FRONT END PULLED TO THE LEFT WHILE DRIVING, DEALER FOUND NO PROBLEMS. CONSUMER STATES ON NORMAL BRAKING, PEDAL GOES TO THE FLOOR AND DURING ABOVE MENTIONED ACCIDENT BRAKES LOCKED CAUSING A BLOCK OF SKID MARKS, PRIOR TO ACCIDENT WHEN DEALER COULD FIND NO PROBLEMS WITH ABS OR HYDRAULIC BRAKE SYSTEM. VEHICLE HAD STALLED ON 2 OCCASIONS AT STOPS, DEALER FOUND NO PROBLEM AND 3000 MILES LATER THE STALLING OCCURRED AGAIN, HOWEVER DEALER STILL COULD NOT FIND PROBLEM, POSSIBLE ENGINE PROBLEM. *SLC
Official recalls
202V104000 · Fuel System, Gasoline:fuel Injection System:injectors
Apr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V366000 · Child Seat
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by