THIS UNIT IS EQUIPPED WITH DEXTER AXLES AND IS A NEW UNIT. IT WAS DETERMINED THIS WEEK AFTER 2 ATTEMPTS OF REPORTING INCIDENTS TO LOCAL RV DEALERSHIP THAT ALL FOUR GREASE SEALS FAILED CAUSING LOSS OF BRAKES. FIRST INCIDENT OCCURRED ON NYS THRUWAY TRAVELING @ 60 MPH DURING SUMMER OF 2011. A SUDDEN STOP WAS NEEDED AND THERE WAS…
Read full complaint
THIS UNIT IS EQUIPPED WITH DEXTER AXLES AND IS A NEW UNIT. IT WAS DETERMINED THIS WEEK AFTER 2 ATTEMPTS OF REPORTING INCIDENTS TO LOCAL RV DEALERSHIP THAT ALL FOUR GREASE SEALS FAILED CAUSING LOSS OF BRAKES. FIRST INCIDENT OCCURRED ON NYS THRUWAY TRAVELING @ 60 MPH DURING SUMMER OF 2011. A SUDDEN STOP WAS NEEDED AND THERE WAS NO BRAKING FROM THE TRAILER. TOW VEHICLE IS A 08 CHEVY 2500HD. I WAS ABLE TO AVOID COLLISION WITH NUMEROUS OTHER VEHICLES STOPPED ON THRUWAY DUE TO SHOULDER LANE AVAILABLE. OTHERWISE, THERE WOULD HAVE BEEN A COLLISION AND LOSS OF LIFE. 2ND INCIDENT OCCURRED ON 4/29/12 WHEN GOING DOWN A SMALL HILL. TRAILER BRAKE CONTROLLER SHOWED POWER TO BRAKES, HOWEVER, WHEN FULLY ENGAGED, THERE WAS NO BRAKES FROM TRAILER CAUSING BOTH TOW VEHICLE AND TRAILER TO GO THROUGH A RED LIGHT AND INTO INTERSECTION. LOCAL DEALER HAS STATED THEY HAVE NOT SEEN A GREASE SEAL FAILURE LIKE THIS IN ALL 4 DRUMS AT ONCE CAUSING COMPLETE LOSS OF BRAKING. JAYCO IS COVERING REPAIR UNDER WARRANTY, HOWEVER, WHERE IS REASSURANCE THIS DOES NOT OCCUR AGAIN?? *TR
JAYCO IS RECALLING CERTAIN MODEL YEAR 2011 EAGLE, SUPER LITE AND JAY FLIGHT G2 TRAVEL TRAILERS MANUFACTURED FROM DECEMBER 9, 2010, THROUGH FEBRUARY 11, 2011. THESE TRAILERS MAY HAVE CRACKED BOLTS ATTACHING THE LEVELING JACKS TO THE TRAILER FRAME. IF ALL OF THE BOLTS BREAK, IT COULD RESULT IN THE JACK COMING LOOSE FROM THE FRAME.
Consequence & remedy
Consequence: IF THE JACK COMES LOOSE WHILE THE VEHICLE IS IN MOTION A CRASH, INJURY OR DEATH MAY RESULT.
Remedy: DEALERS WILL REPLACE THE FASTENERS ATTACHING THE LEVELING JACKS TO THE FRAME WITH MORE ROBUST FASTENERS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2011. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.
JAYCO IS RECALLING CERTAIN MODEL YEAR 2011 EAGLE SUPERLITE FIFTH-WHEELS MANUFACTURED FROM NOVEMBER 15, 2010, THROUGH FEBRUARY 9, 2011. DUE TO A TYPOGRAPHICAL ERROR, THE SIZE OF THE TIRE AS INDICATED ON THE FEDERAL ID LABEL IS INCORRECTLY IDENTIFIED. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: A MISPRINTED LABEL COULD LEAD TO SELECTION OF AN IMPROPERLY SIZED REPLACEMENT TIRE.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT JAYCO AT 1-574-825-0608.
JAYCO IS RECALLING CERTAIN MODEL YEAR 2011 TRAVEL TRAILERS AND FIFTH WHEELS MANUFACTURED FROM AUGUST 16, 2010, THROUGH OCTOBER 1, 2010, EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.
Consequence & remedy
Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.
Remedy: JAYCO IS WORKING WITH ATWOOD AND WILL REPLACE OR REPAIR THE STOVES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 8, 2010. OWNERS MAY CONTACT ATWOOD AT 1-574-266-4749 OR JAYCO AT 1-574-825-0608.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2011 Jayco Eagle Super Lite Problems, Complaints & Recalls | Skip That Year
Illustration