IllustrationWHEN YOU SLOW DOWN, THE VEHICLE CUTS OFF COMPLETELY. WHEN YOU TURN THE CAR ON, IT'S ALMOST AS IF THE GAS IS NOT TRAVELING SOMEWHERE AND CAUSES IT TO TAKE A WHILE. HAVING IT CUT OFF ON THE HIGHWAY IS A VERY SCARY THING. I SEE RECALLS YET THEY'RE ACTING AS IF MY VEHICLE IS NOT AFFECTED BY IT.
2010 Jaguar Xf
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Xf years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
725–50K
2050–75K
1575–100K
9100–150K
2150K+
73 reports with mileage · 33 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports0 injury reports
Engine complaints
12 reportsTL* THE CONTACT OWNS A 2010 JAGUAR XF. THE CONTACT STATED THERE WAS AN ABNORMAL ODOR OF FUEL DETECTED INSIDE AND OUTSIDE OF THE VEHICLE. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHCILE WAS TAKEN TO JAGUAR HONOLULU (888 KAPIOLANI BLVD, HONOLULU, HI 96813, (808) 592-5108) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FU…
Read full complaint
TL* THE CONTACT OWNS A 2010 JAGUAR XF. THE CONTACT STATED THERE WAS AN ABNORMAL ODOR OF FUEL DETECTED INSIDE AND OUTSIDE OF THE VEHICLE. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHCILE WAS TAKEN TO JAGUAR HONOLULU (888 KAPIOLANI BLVD, HONOLULU, HI 96813, (808) 592-5108) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL FLANGE AND GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THE FAILURE WAS LIKE THE FAILURE LISTED IN NHTSA CAMPAIGN NUMBER: 20V081000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS CONTACTED HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 96,000.
WHEN MY CAR STARTED UP I NOTICE THAT THE SCREEN ON THE STEREO SYSTEM WAS JUST FLASHING AND NEVER CAME ON ALSO THE CAR STARTED OVER HEATING AND CHECK ENGINE LIGHT CAME ON ALSO THERE IS HAS LEAKING FROM THE RIGHT REAR PASSENGER SIDE DOOR BELOW CAR IS IN THE SHOP NOW WITH $2,745 DOLLARS WORTH OF WORK BEING DONE TO IT
TL* THE CONTACT OWNS A 2010 JAGUAR XF. THE CONTACT STATED THAT WHILE AT DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND DRIVE BACK TO THE RESIDENCE. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE HOWEVER, NO…
Read full complaint
TL* THE CONTACT OWNS A 2010 JAGUAR XF. THE CONTACT STATED THAT WHILE AT DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND DRIVE BACK TO THE RESIDENCE. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE HOWEVER, NO ASSISTANCE WAS PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
TL* THE CONTACT OWNS A 2010 JAGUAR XF. WHILE DRIVING APPROXIMATELY 25 MPH, THE CHECK ENGINE INDICATOR SUDDENLY ILLUMINATED AND THE VEHICLE TURNED OFF. THE VEHICLE WAS TOWED TO THE LOCAL DEALER (JAGUAR OF FREEPORT, 146 W. SUNRISE HWY, FREEPORT, NY) WHERE IT WAS DIAGNOSED THAT THE AIR INJECTION PUMP WAS FAULTY AND NEEDED TO BE REP…
Read full complaint
TL* THE CONTACT OWNS A 2010 JAGUAR XF. WHILE DRIVING APPROXIMATELY 25 MPH, THE CHECK ENGINE INDICATOR SUDDENLY ILLUMINATED AND THE VEHICLE TURNED OFF. THE VEHICLE WAS TOWED TO THE LOCAL DEALER (JAGUAR OF FREEPORT, 146 W. SUNRISE HWY, FREEPORT, NY) WHERE IT WAS DIAGNOSED THAT THE AIR INJECTION PUMP WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED THREE DAYS LATER. THE VEHICLE WAS TOWED BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FAILURE WAS DUE TO A FUEL LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.
MY VEHICLE HAS LESS THAN 59K MILES AND THE CHECK ENGINE LIGHT IS ON. I WAS TOLD THE CAR IS RUNNING TOO COOL. THERE IS AN ISSUE WITH THE COOLANT SYSTEM, FUEL SYSTEM ETC. THE CAR DRIVES FINE HOWEVER, THE DEALERSHIP NEEDS TO REPLACE HOSES, HOUSINGS, ETC. TO THE TUNE OF $1382 I HAVE NEVER HEARD OF A CAR RUNNING TOO COOL.. THIS…
Read full complaint
MY VEHICLE HAS LESS THAN 59K MILES AND THE CHECK ENGINE LIGHT IS ON. I WAS TOLD THE CAR IS RUNNING TOO COOL. THERE IS AN ISSUE WITH THE COOLANT SYSTEM, FUEL SYSTEM ETC. THE CAR DRIVES FINE HOWEVER, THE DEALERSHIP NEEDS TO REPLACE HOSES, HOUSINGS, ETC. TO THE TUNE OF $1382 I HAVE NEVER HEARD OF A CAR RUNNING TOO COOL.. THIS IS A MANUFACTURING ISSUE. ALSO, THE HEADLINER ATTACHED TO THE SUNROOF HAS FALLED DUE TO HEAT AND I UNDERSTAND THIS IS A COMMON PROBLEM WITH THESE JAGUARS.
CAR SUDDENLY STOP ACCELERATING IN THE MIDDLE OF THE FREEWAY. I HAD TO PULL TO THE SIDE WICH WAS HARD SINCE POWER STEERING AND EVERYTHING WAS NOT WORKING SINCE ENGINE SEEM TO SHUT OFF. ENDED UP FIGURING OUT THAT IT HAD RAN OUT OF FUEL BUT GAS GAUGE SHOWED AROUND 1/4 LEFT AND NO FUEL LOW WARNING EVER SHOWED.
WAS DRIVING DOWN INTERSTATE AND LIGHT CAME ON SAYING COOLANT LOW, AIR CONDITIONER WAS STILL BLOWING COLD, BUT I TURNED OFF AIR, MAYBE 3 MINUTES LATER, LOSS ACCELERATION POWER, BLACK SMOKE BILLOWING OUT OF PIPES AND UNDER HOOD AND LIGHT CAME ON SAYING LOW PERFORMANCE TURN ENGINE OFF. IMMEDIATELY PULLED CAR ON SIDE OF HIGHWAY. NO…
Read full complaint
WAS DRIVING DOWN INTERSTATE AND LIGHT CAME ON SAYING COOLANT LOW, AIR CONDITIONER WAS STILL BLOWING COLD, BUT I TURNED OFF AIR, MAYBE 3 MINUTES LATER, LOSS ACCELERATION POWER, BLACK SMOKE BILLOWING OUT OF PIPES AND UNDER HOOD AND LIGHT CAME ON SAYING LOW PERFORMANCE TURN ENGINE OFF. IMMEDIATELY PULLED CAR ON SIDE OF HIGHWAY. NO WARNING CAR WAS RUNNING HOT. CAR WAS DISABLED WOULD NOT START LATER AND COMPUTER READING STILL REGISTERED COOL. GAS WAS SMELLING ALL THOUGH THE CAR AND PROCEEDED TO LEAK FROM UNDER CAR AFTER TOWED AWAY. AT THE DEALERSHIP, THE CAR HAD GAS LEAKING UNDER IT ON THE GROUND WHEN I WENT TO RETRIEVE ITEMS OUT OF CAR. DEALERSHIP SAID IT WOULD COST 36,000. PLUS TO FIX. CAR IS STILL SITTING AT DEALERSHIP WITH NO SOLUTION. I FELT WE WERE FORTUNATE TO GET OUT OF CAR ALIVE BECAUSE I FELT IT COULD HAVE EXPLODED. DEALERSHIP SAYS IT WAS WATER PUMP, BUT ENGINE WAS NEVER TORN DOWN TO DETERMINE THAT.
PULLING OUT OF A PARKING LOT INTO ONCOMING TRAFFIC, CAR WAS DRIVING FINE THEN ALL OF A SUDDEN IT SNAPPED INTO RESTRICTED PERFORMANCE MODE, SLOWED MY CAR DOWN TO 15MPH ON A BUSY STREET, AND ALMOST GOT HIT BY OTHER CARS DUE TO MY SUDDEN DECLINE IN SPEED. TOOK THE CAR BACK TO THE DEALERSHIP FOR ASSESSMENT AND THEIR RECOMMENDATION I…
Read full complaint
PULLING OUT OF A PARKING LOT INTO ONCOMING TRAFFIC, CAR WAS DRIVING FINE THEN ALL OF A SUDDEN IT SNAPPED INTO RESTRICTED PERFORMANCE MODE, SLOWED MY CAR DOWN TO 15MPH ON A BUSY STREET, AND ALMOST GOT HIT BY OTHER CARS DUE TO MY SUDDEN DECLINE IN SPEED. TOOK THE CAR BACK TO THE DEALERSHIP FOR ASSESSMENT AND THEIR RECOMMENDATION IS TO REPLACE THE ENGINE FOR $32,000.00. I BOUGHT THE CAR FOR $26,000.00 IN JANUARY 2014 FROM GALPIN HONDA IN MISSION HILLS AND I CURRENTLY OWE $24,000.00 ON IT. I JUST DON'T SEE HOW THIS COULD BE RIGHT.
TL* THE CONTACT OWNS A 2010 JAGUAR XF. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE ENGINE PERFORMANCE FAILURE WARNING INDICATOR ILLUMINATED AND THE VEHICLE BEGAN TO DECELERATE. THE VEHICLE STALLED AND WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT ALL EIGHT FUEL INJECTOR…
Read full complaint
TL* THE CONTACT OWNS A 2010 JAGUAR XF. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE ENGINE PERFORMANCE FAILURE WARNING INDICATOR ILLUMINATED AND THE VEHICLE BEGAN TO DECELERATE. THE VEHICLE STALLED AND WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT ALL EIGHT FUEL INJECTORS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 59,236.
Official recalls
1020V081000 · Fuel System, Gasoline
Feb 13, 2020
Jaguar Land Rover North America, LLC (Jaguar) is recalling certain 2010 XF vehicles equipped with 4.2L engines. The fuel tank outlet flange may crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may increase the risk of a fire.
Remedy: Jaguar will notify owners, and dealers will replace the fuel outlet flange, free of charge. The recall began June 29, 2020. Owners may contact Jaguar customer service at 1-800-452-4827. Jaguar's number for this recall is H283.
18V009000 · Air Bags:frontal:passenger Side:inflator Module
Jan 8, 2018
Jaguar Land Rover North America, LLC (Jaguar) is recalling certain 2013 Jaguar XF vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Unless included in "Zone A" above, Jaguar is recalling certain 2010 Jaguar XF vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Unless included in Zone A and Zone B above, Jaguar is recalling certain 2009 MY Jaguar XF vehicles, originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Jaguar will notify owners, and dealers will replace the front passenger air bag assemblies, free of charge. The recall began June 27, 2018. Owners may contact Jaguar customer service at 1-800-452-4827. Jaguar's number for this recall is J071.
18V010000 · Air Bags:frontal:passenger Side:inflator Module
Jan 8, 2018
Jaguar Land Rover North America, LLC (Jaguar) is recalling certain 2014-2015 Jaguar XF vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Unless included in "Zone A" above, Jaguar is also recalling certain 2011-2015 Jaguar XF vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Unless included in Zone A and Zone B above, Jaguar is also recalling certain 2010-2015 Jaguar XF vehicles, originally sold, or ever registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Jaguar will notify owners, and dealers will replace the front passenger air bag assembly, free of charge. The recall began June 27, 2018. Owners may contact 1-800-452-4827. Jaguar's number for this recall is J072.
16V373000 · Air Bags:frontal:passenger Side:inflator Module
May 27, 2016
Jaguar Land Rover North America, LLC (Jaguar) is recalling certain model year 2009-2011 Jaguar XF vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. Vehicles not originally sold or ever registered in these states are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Jaguar will notify owners, and dealers will replace the passenger frontal air bag assemblies, free of charge. The recall began March 2017. Owners may contact Jaguar Land Rover customer service at 1-800-452-4827. Jaguar's number of this recall is J069.
16V187000 · Fuel System, Gasoline
Apr 4, 2016
Jaguar Land Rover North America, LLC (Jaguar) is recalling certain model year 2010 Jaguar XF vehicles manufactured December 17, 2008, to April 15, 2009. The affected vehicles have a fuel tank with an outlet flange that may crack, allowing fuel to leak onto the ground.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may increase the risk of a fire.
Remedy: Jaguar will notify owners, and dealers will replace the fuel outlet mounting flange, free of charge. The recall began on May 11, 2016. Owners may contact Jaguar customer service at 1-800-452-4827. Jaguar's number for this recall is J059.
12V521000 · Fuel System, Gasoline; Fuel System, Gasoline:storage:tank Assembly
Oct 26, 2012
Jaguar is recalling certain model year 2010-2012 XF vehicles equipped with a 5.0L gasoline engine. The affected vehicles may have a fuel tank fuel outlet flange that may crack.
Consequence & remedy
Consequence: The cracked flange may result in fuel leakage onto the ground. This leaking fuel, in the presence of an ignition source, may result in a vehicle fire.
Remedy: Jaguar will notify owners, and dealers will replace the affected fuel tank fuel outlet flanges, free of charge. The recall began on December 20, 2012. Owners may contact Jaguar at 1-800-452-4827.
Additional source detail variants (2)
Fuel System, Gasoline
Jaguar is recalling certain model year 2010-2012 XF vehicles equipped with a 5.0L gasoline engine. The affected vehicles may have a fuel tank fuel outlet flange that may crack.
Consequence: The cracked flange may result in fuel leakage onto the ground. This leaking fuel, in the presence of an ignition source, may result in a vehicle fire.
Remedy: Jaguar will notify owners, and dealers will replace the affected fuel tank fuel outlet flanges, free of charge. The recall began on December 20, 2012. Owners may contact Jaguar at 1-800-452-4827.
Fuel System, Gasoline:storage:tank Assembly
Jaguar is recalling certain model year 2010-2012 XF vehicles equipped with a 5.0L gasoline engine. The affected vehicles may have a fuel tank fuel outlet flange that may crack.
Consequence: The cracked flange may result in fuel leakage onto the ground. This leaking fuel, in the presence of an ignition source, may result in a vehicle fire.
Remedy: Jaguar will notify owners, and dealers will replace the affected fuel tank fuel outlet flanges, free of charge. The recall began on December 20, 2012. Owners may contact Jaguar at 1-800-452-4827.
11V168000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Mar 14, 2011
JAGUAR IS RECALLING CERTAIN MODEL YEAR 2010 XK AND XF VEHICLES MANUFACTURED FROM JUNE 27, 2009, THROUGH MARCH 10, 2010. THE POWER ASSIST STEERING (PAS) PIPES HAVE BEEN SUPPLIED WITH ZINC-NICKEL PLATING THAT DOES NOT MEET FULLY THE CORROSION PROTECTION REQUIREMENTS OF JAGUAR'S ENGINEERING SPECIFICATION. AFTER AN EXTENDED PERIOD OF TIME IN SERVICE, CORROSION OF THE PAS PIPES WILL OCCUR THAT MAY LEAD TO PIN-HOLING OF THE PIPE.
Consequence & remedy
Consequence: PIN-HOLING OF THE PAS PIPES COULD ALLOW PRESSURIZED POWER STEERING FLUID TO LEAK INTO THE UNDER-HOOD AND ENGINE BAY AREA. A LOSS OF POWER STEERING FLUID WILL RESULT IN A LOSS OF POWER ASSIST STEERING. ALSO, THAT FLUID MAY IGNITE IF IT COMES INTO CONTACT WITH AN IGNITION SOURCE OR A SURFACE AT SUFFICIENTLY HIGH ENOUGH TEMPERATURE, CAUSING A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE POWER STEERING FLUID PIPES WITH PARTS MANUFACTURED TO THE REQUIRED CORROSION PROTECTION SPECIFICATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGED. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JUNE 6, 2011. OWNERS MAY CONTACT JAGUAR AT 1-800-452-4827.
10V332000 · Engine And Engine Cooling
Jul 22, 2010
JAGUAR IS RECALLING CERTAIN MODEL YEAR 2010-2011 JAGUAR XK AND MODEL YEAR 2010 XF V8 5.OL GASOLINE ENGINE VEHICLES. THE IN-TANK ELECTRIC FUEL PUMP MAY NOT BE CORRECTLY ACTIVATED AS THE FUEL PUMP RELAY IS NOT ENERGIZED FOLLOWING A VEHICLE START UP CYCLE. AN INADEQUATE SUPPLY OF FUEL TO THE ENGINE COULD RESULT.
Consequence & remedy
Consequence: FUEL STARVATION TO THE ENGINE LEADS TO ENGINE STUMBLE FOLLOWED BY ENGINE CUT OUT WITH MINIMAL WARNING AND COULD POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL DOWNLOAD REVISED SOFTWARE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE AUGUST 30, 2010. OWNERS MAY CONTACT JAGUAR AT 1-800-452-4827.
09V424000 · Fuel System, Gasoline:delivery
Nov 2, 2009
JAGUAR IS RECALLING CERTAIN MODEL YEAR 2010 VEHICLES. THE FUEL TRANSFER PIPE IN THE FUEL TANK MAY BE KINKED. THIS MAY RESTRICTS FUEL BEING TRANSFERRED FROM ONE SIDE OF THE FUEL TANK TO THE FUEL PUMP CAUSING FUEL STARVATION AT LOW FUEL LEVELS.
Consequence & remedy
Consequence: FUEL STARVATION TO THE ENGINE CAN CAUSE THE ENGINE TO STALL WITHOUT WARNING AND COULD POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL HAVE THE FUEL TANK ASSEMBLY REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 30, 2009. OWNERS MAY CONTACT JAGUAR AT 1-800-452-4827.
09V316000 · Equipment:other:labels
Aug 7, 2009
JAGUAR IS RECALLING 34 MODEL YEAR 2010 XF VEHICLES FOR FAILING TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE RECOMMENDED TIRE PRESSURE ON THE TIRE PLACARD LABEL DOES NOT CORRESPOND WITH THE TIRES FITTED TO THE VEHICLE.
Consequence & remedy
Consequence: CUSTOMERS MAY INFLATE TIRES TO AN INCORRECT PRESSURE DUE TO THIS TIRE PRESSURE MISLABELING. FAILURE TO INFLATE TIRES TO THE CORRECT PRESSURES CAN LEAD TO LOSS OF VEHICLE STABILITY AND INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL BE INSTRUCTED TO INSPECT THE TIRE PLACARD LABEL. IF THE RECOMMENDED PRESSURE ON THE TIRE PLACARD LABEL DOES NOT CORRESPOND WITH THE TIRES FITTED TO THE VEHICLE, THAT LABEL WILL BE REMOVED AND REPLACED WITH A LABEL STATING THE CORRECT RECOMMENDED TIRE PRESSURE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 19, 2009. OWNERS MAY CONTACT JAGUAR AT 1-800-452-4827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ19004 · Fuel Tank Flange Leak
Opened Jun 28, 2019 · Closed Nov 5, 2020
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
In October 2012, Jaguar Land Rover LLC (JLR) submitted a Defect Information Report (DIR) to NHTSA describing a defect condition that could result in pressurized fuel leaks around the fuel supply line connection on the upper surface of the fuel tank assemblies of approximately 4,152 model year (MY) 2010 Jaguar XF vehicles equipped with 5.0L engines and manufactured between April 2009 and January 2010 (Recall 12V-521). The DIR indicated that the fuel system operating pressures of 5.0L gasoline engine XF vehicles may exceed the design specification under certain conditions, which may result in cracks in the fuel tank outlet flange. In January 2010, JLR changed the design of the tank outlet flange from the original version with no internal ribs, part number 9X23-9A309-AC (?AC flange?), to a revised part with internal ribbing reinforcing the area of the flange at the base of the fuel supply port where the cracks were occurring (?AD flange?). The scope of 12V-521 included 43 MY 2011-2012 XF vehicles with 5.0L engines that were equipped with the AC flanges as service replacement parts. In addition, in March 2016, JLR recalled 28 additional MY 2010 XF vehicles built with 5.0L engines and AC flanges that were inadvertently excluded from 12V-521 (Recall 16V-187). The AD flange was later replaced in production by the AE flange, which had internal ribbing like the AD flange and was used by JLR as the remedy part for 12V-521 and 16V-187. All the subject fuel tank flanges (AC, AD & AE) were supplied to JLR by Continental AG (now Vitesco Technologies). By October 2019, JLR had completed the recall remedies for 12V-521 and 16V-187 in 4,080 vehicles, resulting in an overall completion rate of 97 percent.On June 28, 2019, ODI opened RQ19-004 to investigate the scope and remedy for recalls 12V-521 and 16V-187, based on 30 complaints alleging fuel odor or leakage from the tank flange, including 19 in MY 2010 XF 4.2L vehicles equipped with the AC flange and 11 in MY 2010 through 2012 XF 5.0L vehicles equipped with revised flanges (AD/AE flanges) either as original equipment or as remedy parts under the subject recalls.ODI?s analysis of field data gathered under RQ19-004 identified a total of 51 complaints and field reports and 272 warranty claims related to fuel leakage from cracked flanges in the subject vehicles. Thirty-three (33) of the complaints and field reports and 200 of the warranty claims involved MY 2010 XF 4.2L equipped with the unreinforced AC flange, resulting in a complaint rate of 11.4 incidents per thousand vehicles (IPTV) and a claim rate of 6.9 percent. Twelve (12) of the complaints and field reports and 61 of the warranty claims involved MY 2010 ? 2012 XF 5.0L vehicles equipped with AD/AE flanges as original equipment parts, resulting in a complaint rate of 0.8 IPTV and a claim rate of 0.4 percent. Six (6) of the complaints and 11 of the warranty claims involved vehicles remedied under 12V-521 or 16V-187, resulting in a complaint rate of 1.5 IPTV and a claim rate of 0.3 percent.On February 13, 2020, JLR notified NHTSA that it was recalling approximately 2,907 model year MY 2010 Jaguar XF vehicles equipped with 4.2L engines and the AC flange to remedy a fuel tank flange cracking defect (Recall 20V-081). With this recall, there are no remaining products equipped with the unreinforced AC flange that are not under recall. Like the prior recalls, the remedy for 20V-081 involves replacing the AC flange with a modified part with the internal ribbing reinforcement (AE flange).ODI's analysis indicates that Recall 20V-081 addresses the scope concerns with tank flange cracking in the subject vehicles. Based on this analysis, this invest