HYDROLIC LIFTERS STICK, VERY LOUD AND NOTICABLE ENGINE NOISE. THEY HAVE STUCK SINCE SHORTLY AFTER PURCHASE OF VEHICLE. THEY UNSTICK IMMEDIATELY AFTER SYNTHETIC OIL CHANGE, BUT ONLY FOR A BRIEF PERIOD OF TIME.*AK DEALERSHIP(S) USED THIS WINDOW OF TIME TO THIER ADVANTAGE TO AVOID REPAIRING VEHICLE UNDER WARRANTY, SENDING CONSUME…
Read full complaint
HYDROLIC LIFTERS STICK, VERY LOUD AND NOTICABLE ENGINE NOISE. THEY HAVE STUCK SINCE SHORTLY AFTER PURCHASE OF VEHICLE. THEY UNSTICK IMMEDIATELY AFTER SYNTHETIC OIL CHANGE, BUT ONLY FOR A BRIEF PERIOD OF TIME.*AK DEALERSHIP(S) USED THIS WINDOW OF TIME TO THIER ADVANTAGE TO AVOID REPAIRING VEHICLE UNDER WARRANTY, SENDING CONSUMER AWAY TO SEE IF IT WORKS. MANAUFACTURER RECOMMENDS SYNTHETIC OIL TO CORRECT. DOES NOT WORK. SEVERAL INCIDENTS. COUNTLESS FAILURES. WILL PAY OUT OF POCKET FOR NEW LIFTERS, APPROXIMATELY $1,800.00.
NHTSA ODI #10112633
Mileage unknown · Jul 17, 2002
Engine And Engine Cooling
A HIDEOUS, LOUD NOISE COMES FROM UNDERNEATH THE CHASSIS. THE DEALER TOLD ME IT COMES FROM THE MUFFLER. IT WAS REPORTED TO THE DEALER WHILE THE VEHICLE WAS STILL UNDER WARRANTY. THE DEALER AND MANUFACTURER REFUSE TO CORRECT THE PROBLEM. THE DEALER TELLS ME THAT IT WOULD COST IN EXCESS OF $800 TO FIX THE PROBLEM. THIS IS A MA…
Read full complaint
A HIDEOUS, LOUD NOISE COMES FROM UNDERNEATH THE CHASSIS. THE DEALER TOLD ME IT COMES FROM THE MUFFLER. IT WAS REPORTED TO THE DEALER WHILE THE VEHICLE WAS STILL UNDER WARRANTY. THE DEALER AND MANUFACTURER REFUSE TO CORRECT THE PROBLEM. THE DEALER TELLS ME THAT IT WOULD COST IN EXCESS OF $800 TO FIX THE PROBLEM. THIS IS A MANUFACTURING DEFECT AND SHOULD BE FIXED EITHER BY THE DEALER OR THE MANUFACTURER. THERE SHOULD HAVE BEEN A SERVICE BULLETIN OR A RECALL ON THIS PROBLEM, BECAUSE THE DEALER, WHEN I MENTIONED THE PROBLEM THE VERY FIRST TIME, PICKED UP ON IT RIGHT AWAY.*AK
THE LEFT FRONT BRAKE LINES WERE INSTALLED IMPROPERLY AT THE ASSEMBLY LINE RESULTING IN INSUFFICIENT CLEARANCE BETWEEN THE BRAKE LINE AND AN UPPER CONTROL ARM OF THE SUSPENSION.
Consequence & remedy
Consequence: THE LINE CAN BE DAMAGED DURING VEHICLE OPERATION AND CAN RESULT IN BRAKE FLUID LEAKAGE, REDUCED BRAKE EFFECTIVENESS, AND INCREASED STOPPING DISTANCES.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE BRAKE LINE AND THE UPPER CONTROL ARM. IF THE CLEARANCE IS NOT ACCORDING TO SPECIFICATIONS, THE BRAKE LINE WILL BE REPLACED.
THESE VEHICLES WERE MANUFACTURED WITHOUT A LOCK WASHER AND/OR SCREWS IN THE FRONT HUB.
Consequence & remedy
Consequence: THE BEARING ADJUSTMENT NUT CAN LOOSEN, RESULTING IN TOO MUCH FREE PLAY BETWEEN THE WHEEL AND AXLE. THE BEARING CAN SEIZE, CAUSING THE WHEEL TO LOCK AFFECTING VEHICLE DIRECTIONAL CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT HUBS TO DETERMINE IF THE LOCK WASHER AND SCREWS WERE PROPERLY INSTALLED. IF NOT, THEY WILL MAKE THE NECESSARY REPAIRS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1997 Isuzu Trooper Problems, Complaints & Recalls | Skip That Year
Illustration