IllustrationVEHICLE FIRE.
1991 Isuzu Trooper
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Isuzu Trooper do not stand out strongly from the model-year median of 25.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trooper years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 57 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Wheels. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports15 fire reports3 injury reports
Engine And Engine Cooling complaints
13 reportsUNDER HOOD FIRE, CAUSE UNKNOWN. *AK CONSUMER STATES THERE WAS NO COLLSION, NO WARNING, LIGHTS ON THE PANEL WERE ACTIVATED AND THERE WAS NO SUDDEN ACCELERATION.DECELERATION NOTICED, NO NOISES, CONSUMER WAS AT STOP LIGHT AND NOTICED BLACK SMOK FROM THE ENGINE AND HE PROMPTLY TURNED OFF ENGINE AND RELEASED THE HOOD, CONSUMER …
Read full complaint
UNDER HOOD FIRE, CAUSE UNKNOWN. *AK CONSUMER STATES THERE WAS NO COLLSION, NO WARNING, LIGHTS ON THE PANEL WERE ACTIVATED AND THERE WAS NO SUDDEN ACCELERATION.DECELERATION NOTICED, NO NOISES, CONSUMER WAS AT STOP LIGHT AND NOTICED BLACK SMOK FROM THE ENGINE AND HE PROMPTLY TURNED OFF ENGINE AND RELEASED THE HOOD, CONSUMER OBSERVED THE FIRE IN ITS ENTIRETY, STARTING FROM THE ENGINE MOVING TO THE BACK OF THE VEHICLE PRIOR TO INCIDENT CONSUMER HAD NUMEROUS PROBLEMS RIGHT REAR BUMPER, BRAKE LIGHTS WERE NOT WORKING FUSES HAD TO BE REPLACED, REAR ARM REST, ENTIRE HYDRALIC SYSTEM NEEDED TO BE REPLACED ROTORS WARPED, EXHAUST WAS SLIGHTLY BENT, MOUNTS WERE BALANCED, BACK SEAT SLIDE FOWARD WHEN BRAKES ARE BEING APPLIED, RIGHT HEAD LIGHT INOPERABLE, SIDE TURN SIGNAL INOPERABLE, FUEL INJECTION SERVICED..*JB
ENGINE SEIZED WHILE DRIVING THE VEHICLE, OIL PUMP IS NOT PUMPING SUFFICIENT OIL INTO ENGINE. TT
Official recalls
290V166000 · Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings
Sep 20, 1990
IMPROPERLY INSTALLED HOSE ON THE OIL COOLER COULD COME IN CONTACT WITH THE EXHAUST MANIFOLD AND COULD MELT.
Consequence & remedy
Consequence: ENGINE OIL COULD LEAK OUT WITH POTENTIAL FOR ENGINESEIZURE AND DAMAGE AND COULD RESULT IN A FIRE.
Remedy: PROPERLY INSTALL COOLER HOSE CLIP TO PREVENT CONTACT WITH EXHAUST MANIFOLD.
90V167000 · Power Train:automatic Transmission
Sep 20, 1990
PUTTING IN MORE TRANSMISSION OIL THAN SPECIFIED CAN CAUSE OIL TO BLEED THROUGH AIR GROOVE ON TO THE EXHAUST MANIFOLD IF OIL TEMPERATURE RISES.
Consequence & remedy
Consequence: THIS COULD CAUSE SMOKE EMISSION FROM THE MANIFOLD, WHICHCOULD IGNITE RUBBER HOSES AND RESULT IN A FIRE.
Remedy: REPLACE OIL LEVEL GAUGE AND NOTIFY OWNERS TO USE ONLY THE SPECIFIED AMOUNT OF AUTOMATIC TRANSMISSION FLUID.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5DP92015 · Engine Compartment Fires
Opened Jul 30, 1992 · Closed Nov 25, 1992
Status: closed (inferred from source dates) · Engine And Engine Cooling
ENGINE COMPARTMENT FIRES
EA92018 · Heater Core Failure
Opened Jun 2, 1992 · Closed Apr 2, 1993
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP92005 · Defective Heater Cores
Opened Mar 3, 1992 · Closed Jun 2, 1992
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
DEFECTIVE HEATER CORES
EA91033 · Rear Door Hinge Separation
Opened Jul 15, 1991 · Closed Jul 28, 1992
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE91046 · Rear Door Hinge Separation
Opened Feb 19, 1991 · Closed Jul 15, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available