NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
274 reports100,000 miles · Apr 27, 2011
StructureSuspension
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT THE REAR OF THE FRAME EXHIBITED EXCESSIVE RUST. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE THE VEHICLE REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION:REAR) AND WAS ADVISED THAT THE VEHICLE WAS UNSAFE TO DRIVE BECAUSE OF THE RUST. THE MANUFA…
Read full complaint
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT THE REAR OF THE FRAME EXHIBITED EXCESSIVE RUST. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE THE VEHICLE REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION:REAR) AND WAS ADVISED THAT THE VEHICLE WAS UNSAFE TO DRIVE BECAUSE OF THE RUST. THE MANUFACTURER WAS CONTACTED REGARDING THE FAILURE AND STATED THAT THEY WOULD ONLY REPAIR THE LOWER LINK BRACKETS WHICH WAS COVERED UNDER THE RECALL. THE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10398043
122,079 miles · Apr 27, 2011
Suspension
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH WHEN SHE HEARD AN ABNORMAL POP OUTSIDE OF THE VEHICLE. THE CONTACT NOTICED THAT THE REAR DRIVER SIDE LOWER BRACKET WAS DETACHED AND CAUSING DAMAGE TO THE FRAME. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR REPAIRS UNDER NHTSA CAMPAIGN ID N…
Read full complaint
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH WHEN SHE HEARD AN ABNORMAL POP OUTSIDE OF THE VEHICLE. THE CONTACT NOTICED THAT THE REAR DRIVER SIDE LOWER BRACKET WAS DETACHED AND CAUSING DAMAGE TO THE FRAME. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION: REAR). THE LOWER LINK BRACKET WAS REPLACED UNDER THE RECALL; HOWEVER, THE DAMAGED FRAME WAS NOT INCLUDED IN THE REMEDY. THE DEALER WAS NOTIFIED AND THEY WOULD NOT ACCEPT LIABILITY FOR THE FRAME REPAIR. THE FAILURE MILEAGE WAS 122,079.
NHTSA ODI #10398002
106,000 miles · Apr 21, 2011
Structure
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION:REAR) WHERE THE DEALER REPLACED THE LOWER BRACKETS. AFTER THE REPAIRS, THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP…
Read full complaint
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION:REAR) WHERE THE DEALER REPLACED THE LOWER BRACKETS. AFTER THE REPAIRS, THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE FILLER TANK WAS DESTROYED AND THE FRAME WAS COMPLETELY CORRODED. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 106, 000.
NHTSA ODI #10397027
64,000 miles · Apr 20, 2011
Structure
2000 ISUZU RODEO RECALL NO10V-436. BRACKETS INSTALLED BY DEALERSHIP; HOWEVER, STILL FEEL THE VEHICLE IS UNSAFE TO DRIVE BECAUSE THE ENTIRE FRAME IS RUSTED UNDERNEATH. HAVE PARKED THE VEHICLE. *TR
NHTSA ODI #10396907
Mileage unknown · Apr 13, 2011
Suspension
TL*THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT WAS DRIVING APPROXIMATELY 10 MPH IN THE DRIVEWAY, AND HEARD A LOUD POPPING NOISE OUTSIDE OF THE VEHICLE; SUDDENLY THE REAR END OF THE VEHICLE COLLAPSED TO THE GROUND. THE VEHICLE WAS TOWED TO AN INDEPENDENT AUTO REPAIR SHOP WHERE THEY STATED THAT THE REAR MOUNTING POINT BRACKET…
Read full complaint
TL*THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT WAS DRIVING APPROXIMATELY 10 MPH IN THE DRIVEWAY, AND HEARD A LOUD POPPING NOISE OUTSIDE OF THE VEHICLE; SUDDENLY THE REAR END OF THE VEHICLE COLLAPSED TO THE GROUND. THE VEHICLE WAS TOWED TO AN INDEPENDENT AUTO REPAIR SHOP WHERE THEY STATED THAT THE REAR MOUNTING POINT BRACKET FRACTURED. THE TECHNICIAN PERFORMED A TEMPORARY FIX. THERE WAS A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 10V436000 (SUSPENSION: REAR). THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE VIN WAS INCLUDED IN THE RECALL; HOWEVER, THEY ADVISED THAT THE RECALL REMEDY WAS NOT NECESSARY. THE CONTACT STATED THE VEHICLE EXHIBITED THE IDENTICAL FAILURE AS MENTIONED IN THE RECALL AND THE VEHICLE SHOULD BE REPAIRED. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.
NHTSA ODI #10395766
100,000 miles · Apr 11, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT THE VEHICLE WAS CONSUMING ONE QUART OF OIL PER WEEK. THE OIL WAS NOT LEAKING NOR MIXING WITH ANY OTHER FLUIDS BUT WOULD BURN OFF WHEN TRANSFERRED THROUGH THE CYLINDERS. THE VEHICLE WAS INSPECTED BY A MECHANIC WHO STATED THAT THE FAILURE COULD POTENTIALLY CAUSE THE …
Read full complaint
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT THE VEHICLE WAS CONSUMING ONE QUART OF OIL PER WEEK. THE OIL WAS NOT LEAKING NOR MIXING WITH ANY OTHER FLUIDS BUT WOULD BURN OFF WHEN TRANSFERRED THROUGH THE CYLINDERS. THE VEHICLE WAS INSPECTED BY A MECHANIC WHO STATED THAT THE FAILURE COULD POTENTIALLY CAUSE THE ENGINE TO FAIL. THE VEHICLE WAS NOT REPAIRED. THE ENGINE LATER FAILED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 123,000.
NHTSA ODI #10395439
123,000 miles · Mar 29, 2011
Suspension
TL*THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT SHE RECEIVED NHTSA CAMPAIGN ID NUMBER 10V436000 SUSPENSION:REAR IN DECEMBER OF 2010, AND THAT THE DEALER WAS UNABLE TO PERFORM THE REPAIR IN DECEMBER, BECAUSE THE PART WAS NOT AVAILABLE. ON MARCH 27, 2011 WHILE DRIVING 25 MPH THE VEHICLE PULLED TO THE RIGHT. THE CO…
Read full complaint
TL*THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT SHE RECEIVED NHTSA CAMPAIGN ID NUMBER 10V436000 SUSPENSION:REAR IN DECEMBER OF 2010, AND THAT THE DEALER WAS UNABLE TO PERFORM THE REPAIR IN DECEMBER, BECAUSE THE PART WAS NOT AVAILABLE. ON MARCH 27, 2011 WHILE DRIVING 25 MPH THE VEHICLE PULLED TO THE RIGHT. THE CONTACT HAD TO DRIVE ONTO THE ROAD SIDE AND HAVE THE VEHICLE TOWED TO THE DEALER. THE TOWING COMPANY ADVISED THE CONTACT THAT THE REAR AXLE FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 123,000.
NHTSA ODI #10393584
Mileage unknown · Mar 28, 2011
Structure
I HAVE A 2000 ISUZU RODEO, I WAS ONLINE LOOKING FOR A PART TO REPLACE WHEN I STUMBLED UPON THE NEWEST RECALL OF THE REAR MOUNTING BRACKETS RUSTING OFF OF THE FRAME. I IMMEDIATELY BROUGHT MY CAR TO THE CLOSEST ISUZU SERVICE CENTER WITHOUT THE RECALL LETTER THAT I AM SUPPOSED TO GET FROM ISUZU, YET STILL HAVEN'T. THE DEALER BROUGH…
Read full complaint
I HAVE A 2000 ISUZU RODEO, I WAS ONLINE LOOKING FOR A PART TO REPLACE WHEN I STUMBLED UPON THE NEWEST RECALL OF THE REAR MOUNTING BRACKETS RUSTING OFF OF THE FRAME. I IMMEDIATELY BROUGHT MY CAR TO THE CLOSEST ISUZU SERVICE CENTER WITHOUT THE RECALL LETTER THAT I AM SUPPOSED TO GET FROM ISUZU, YET STILL HAVEN'T. THE DEALER BROUGHT MY CAR IN AND WITHIN A 30MIN IT WAS BACK OUT IN THE PARKING LOT. THE DESK MANAGER SAID I NEED A STAGE 4 REPAIR FOR THE BRACKETS BUT THEN TOLD ME THEY WOULD CALL WHEN THEY HAD THE AVAILABILITY; THEY SAID IT WOULD AT LEAST TWO MONTHS BEFORE THEY COULD FIT ME IN! I ASKED IF IT WAS SAFE TO DRIVE AND THE GUY SIMPLY SAID IT SHOULD BE ALRIGHT, WHAT KIND OF RESPONSE IS THAT. I TOOK IT TO MY MECHANIC WHO THEN PUT IT UP ON THE LIFT AND THE WHOLE VEHICLE FRAME IS RUSTED! THERE IS NO WAY NEW BRACKETS ARE GOING TO MAKE ANYTHING BETTER. PIECES OF FRAME ARE JUST FALLING OFF MY TRUCK. THIS IS A HUGE SAFETY ISSUE AND NEEDS TO BE FIXED, JUST REPLACING THE MOUNTING BRACKETS IS ABSOLUTELY POINTLESS AND DOESN'T ADDRESS THE REAL ISSUE BEING THE WHOLE FRAME'S DEFECTIVENESS. *TR
NHTSA ODI #10393075
91,800 miles · Mar 2, 2011
Service Brakes, HydraulicSuspension
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT WAS DRIVING 5 MPH AND WHILE APPLYING THE BRAKES, THE VEHICLE WOULD NOT RESPOND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DISCOVERED THAT THE REAR SHOCK BRACKETS WERE RUSTED AND FRACTURED FROM THE VEHICLE. WHEN THE FAILURE OCCURRED, THE BRACKETS STRUCK THE …
Read full complaint
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT WAS DRIVING 5 MPH AND WHILE APPLYING THE BRAKES, THE VEHICLE WOULD NOT RESPOND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DISCOVERED THAT THE REAR SHOCK BRACKETS WERE RUSTED AND FRACTURED FROM THE VEHICLE. WHEN THE FAILURE OCCURRED, THE BRACKETS STRUCK THE BRAKE LINES AND CAUSED A LOSS OF BRAKE FLUID AND BRAKING POWER. THE MECHANIC REPAIRED THE BRAKE LINES BUT THE RUSTED SHOCK BRACKET WAS NOT REPAIRABLE. THE CONTACT ATTEMPTED TO CALL BOTH THE DEALER AND MANUFACTURER BUT WAS UNSUCCESSFUL. THE FAILURE MILEAGE WAS 91,800.
NHTSA ODI #10386215
120,000 miles · Feb 17, 2011
Fuel System, GasolineStructure
TL*THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT IN 2008 WHILE DRIVING 65 MPH, THE VEHICLE STALLED. A LOCAL MECHANIC REPLACED THE FUEL PUMP BUT THE FAILURE CONTINUED. THE ENGINE WOULD NOT START SO THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO STATED THAT THE FUEL PUMP AND SUBFRAME HAD HOLES DUE TO CORROSION. THE C…
Read full complaint
TL*THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT IN 2008 WHILE DRIVING 65 MPH, THE VEHICLE STALLED. A LOCAL MECHANIC REPLACED THE FUEL PUMP BUT THE FAILURE CONTINUED. THE ENGINE WOULD NOT START SO THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO STATED THAT THE FUEL PUMP AND SUBFRAME HAD HOLES DUE TO CORROSION. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED THE CONTACT TO HAVE THE VEHICLE TOWED TO AN AUTHORIZED DEALER. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 150,000.
NHTSA ODI #10383130
Official recalls
3Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Aug 9, 2002
ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER-SIDE AIR BAG INFLATOR MODULES WERE MANUFACTURED AND SHIPPED WITHOUT A NECESSARY COMPONENT KNOWN AS A CHECK VALVE PIN.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT INFLATE PROPERLY OR SUFFICIENTLY RESULTING IN AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST OR SEPTEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
Feb 22, 2001
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH THE INFLATORS IN THE PASSENGER SIDE AIR BAG MODULES HAVING THE WRONG AMOUNT OF GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, TOO MUCH GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG UNIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Illustration