NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
274 reportsMileage unknown · May 13, 2004
Fuel System, Other
BAD FUEL SENDING UNIT! HUNDREDS OF PEOPLE HAVE DEFECTIVE FUEL SENDING UNITS ON THEIR 1998-2000 ISUZU RODEOS! THE COMPANY SHOULD BE FORCED TO FIX THIS FREE WITH A RECALL! I SHOULDN'T HAVE TO PAY $250 TO FIX A PROBLEM ON MY 2000 RODEO THAT THEY KNEW ABOUT FOR 2 YEARS BEFORE MY CAR WAS BUILT. THE GAS GAUGE SHOWS EMPTY WHEN THE TANK…
Read full complaint
BAD FUEL SENDING UNIT! HUNDREDS OF PEOPLE HAVE DEFECTIVE FUEL SENDING UNITS ON THEIR 1998-2000 ISUZU RODEOS! THE COMPANY SHOULD BE FORCED TO FIX THIS FREE WITH A RECALL! I SHOULDN'T HAVE TO PAY $250 TO FIX A PROBLEM ON MY 2000 RODEO THAT THEY KNEW ABOUT FOR 2 YEARS BEFORE MY CAR WAS BUILT. THE GAS GAUGE SHOWS EMPTY WHEN THE TANK IS 1/4 TANK, AND THE CHECK ENGINE LIGHT COMES ON.*AK
NHTSA ODI #10072528
38,000 miles · Apr 7, 2004
Electrical System
THE LIGHT TO MAKEUP MIRROR ON THE PASSENGER SIDE FLICKERS OR DOESN'T TURN ON AT ALL. NOT A BIG PROBLEM.. JUST MAKES THE CAR SEEM IMPERFECT.*AK
NHTSA ODI #10065685
41,700 miles · Mar 23, 2004
Fuel System, Gasoline
VEHICLE SPORADICLY STALLS WHEN SLOWING TO STOP OR WHEN ALREADY STOPPED. THE VEHICLE "BUCKS" WHEN ACCELERATING FROM STOPPED POSITION. ALL DASH LIGHTS COME ON WHEN THE VEHICLE STALLS. AFTER A FEW MINUTES OF REST, VEHICLE WILL START AND DASH LIGHTS TURN OFF. NOTHING WILL REGISTER IN THE COMPUTER SYSTEM. THROTTLE BODY HAS BEEN CLEA…
Read full complaint
VEHICLE SPORADICLY STALLS WHEN SLOWING TO STOP OR WHEN ALREADY STOPPED. THE VEHICLE "BUCKS" WHEN ACCELERATING FROM STOPPED POSITION. ALL DASH LIGHTS COME ON WHEN THE VEHICLE STALLS. AFTER A FEW MINUTES OF REST, VEHICLE WILL START AND DASH LIGHTS TURN OFF. NOTHING WILL REGISTER IN THE COMPUTER SYSTEM. THROTTLE BODY HAS BEEN CLEANED, FUEL FILTER HAS BEEN CHANGED. MECHANIC CANNOT DUPLICATE PROBLEM. ALL SIGNS POINT TO BAD INTAKE MANIFOLD GASKET BUT MECHANIC REFUSES TO REPLACE EVEN AT OWNERS REQUEST. THIS PROBLEM HAS HAPPENED 7 TIMES IN THE 3 MONTHS I HAVE OWNED IT.*AK
NHTSA ODI #10063674
72,000 miles · Mar 22, 2004
Fuel System, Other
THE FUEL GAUGE DOES NOT WORK AND RESULTS IN THE CHECK ENGINE LIGHT REMAINING ON. IT IS DIFFICULT TO KNOW HOW MUCH GAS IS IN THE TANK (MUST TRACK MILES). BUT, MORE IMPORTANTLY, THE 'CHECK ENGINE' LIGHT MAY BE MASKING A REAL PROBLEM THAT I AM NOT AWARE OFF. *AK
NHTSA ODI #10063620
Mileage unknown · Feb 13, 2004
Service Brakes, Hydraulic
WHILE DRIVING 55 MPH ABS BRAKING LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON UNTIL THE VEHICLE WAS TURNED OFF. CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO FLOOR. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT ABS MODULE NEEDED TO BE REPLACED. *AK
NHTSA ODI #10059126
31,750 miles · Feb 6, 2004
Service Brakes, Hydraulic
200 ISUZU RODEO--BRAKING PROBLEM--PEDAL GOES TO FLOOR-EXTENDED BRAKING TIME, BRAKES HAVE COMPLETELY FAILED ONE TIME. HAVE HAD GRINNDING NOISE WHEN APPLYING BRAKES OVER SMALL BUMPS, WITH LOSS OF BRAKES. THE CAR HAS BEEN TO 3 INDEPENDENT MECHANICS TO HAVE BRAKES CHECKED AND ALL SAY PADS AND ROTORS ARE FINE, BUT BRAKING IS STILL…
Read full complaint
200 ISUZU RODEO--BRAKING PROBLEM--PEDAL GOES TO FLOOR-EXTENDED BRAKING TIME, BRAKES HAVE COMPLETELY FAILED ONE TIME. HAVE HAD GRINNDING NOISE WHEN APPLYING BRAKES OVER SMALL BUMPS, WITH LOSS OF BRAKES. THE CAR HAS BEEN TO 3 INDEPENDENT MECHANICS TO HAVE BRAKES CHECKED AND ALL SAY PADS AND ROTORS ARE FINE, BUT BRAKING IS STILL VERY DIFFICULT. *AK
NHTSA ODI #10056670
24,000 miles · Jan 21, 2004
Vehicle Speed Control
ON 8/8/01, I WAS DRIVING ON THE INTERSTATE AND WINTER LIGHT CAME ON THEN CAR STALLED OUT AND VEHICLE STARTED SHAKING. CAR SHAKING AND LIGHT DIDN'T GO OFF UNTIL CAR WAS SHUT OFF THEN RESTARTED. TOOK TO DEALER AND THEY CHANGED ACCELERATOR SENSOR. *AK 09/10/02, TOOK VEHICLE TO DEALER BECAUSE CD PLAYER BROKE, WHEELS PEELING,DOOR P…
Read full complaint
ON 8/8/01, I WAS DRIVING ON THE INTERSTATE AND WINTER LIGHT CAME ON THEN CAR STALLED OUT AND VEHICLE STARTED SHAKING. CAR SHAKING AND LIGHT DIDN'T GO OFF UNTIL CAR WAS SHUT OFF THEN RESTARTED. TOOK TO DEALER AND THEY CHANGED ACCELERATOR SENSOR. *AK 09/10/02, TOOK VEHICLE TO DEALER BECAUSE CD PLAYER BROKE, WHEELS PEELING,DOOR POPPING WHEN OPENED, VEHICLE CUTS OFF AND STALLS WHILE DRIVING. DEALER REPLACED CD PLAYER, WHEELS, BUSHING IN DOOR, AND REPLACED MASS AIR FLOW SENSOR. 10/10/02, SPEEDODOMETER NOT READING PROPERLY, VEHICLE STILL CUTS OFF AND STALLS WHILE DRIVING. DEALER FOUND CODE P0102 AIR FLOW METER MALFUNCTION, AND REPLACED IT. BUT COULD NOT INDICATE REASON SPEEDODOMETER WAS NOT READING. 01/13/04, CAR STILL STALLING AND CUTTING OFF, DEALER REPLACED PLUGS AND INJECTORS. PROBLEM STILL OCCURRING. TAKING BACK TO DEARLER TODAY ON 01/21/04
NHTSA ODI #10054567
58,000 miles · Jan 4, 2004
Air BagsCrashInjury
DURING A 40 MPH CRASH INTO A CONCRETE CENTER DIVIDER ON A INTERSTATE IN WHICH THE VEHICLE MADE CONTACT WITH THE FRONT AND DRIVER FRONT AREA, CAUSING EXTENSIVE DAMAGES. INCLUDING PUSHING BUMPER,GRILLE,HEADLIGHTS AND HOOD UP INTO THE ENGINE COMPARTMENT. TO MY SHOCK THE AIRBAGS DID NOT DEPLOY. WHAT IS UP WITH THIS? DO THEY JUST…
Read full complaint
DURING A 40 MPH CRASH INTO A CONCRETE CENTER DIVIDER ON A INTERSTATE IN WHICH THE VEHICLE MADE CONTACT WITH THE FRONT AND DRIVER FRONT AREA, CAUSING EXTENSIVE DAMAGES. INCLUDING PUSHING BUMPER,GRILLE,HEADLIGHTS AND HOOD UP INTO THE ENGINE COMPARTMENT. TO MY SHOCK THE AIRBAGS DID NOT DEPLOY. WHAT IS UP WITH THIS? DO THEY JUST TELL YOU THEY ARE THERE AND THEY DON'T WORK WHEN YOU NEED THEM??? I WILL NOT PURCHASE ANOTHER ISUZU PRODUCT AND AM SEEKING A CLAIM AGAINST ISUZU TO FIND OUT WHAT THE PROBLEM MIGHT BE. THANK YOU FOR YOUR TIME!! *LA
NHTSA ODI #10052346
52,102 miles · Dec 21, 2003
Fuel System, Other
THE FUEL GUAGE DOES NOT ALWAYS REGISTER THE CORRECT FUEL LEVEL. IT SELDOMS REGISTERS A FULL TANK AFTER FILLING. THE QUAGE WILL DROP TO THE 1/4 TANK OR BELOW LEVEL, THE LOW FUEL AND SERVICE ENGINE LITES WILL COME ON. THIS MAY PERSIST FOR SEVERAL DAYS OR RESET SEVERAL TIMES A DAY. *AK
NHTSA ODI #10050866
Mileage unknown · Dec 9, 2003
Service Brakes, Hydraulic
00 ISUZU RODEO ABS ISSUES I FIND THE ABS KICKING IN WHEN RUNNING OVER SMAL BUMP AND ROCKY SURFACES. THIS IS MY WIFES AUTOMOBILE, AND I HAVE BEEN DRIVING IT FOR ABOUT A MONTH NOW, AND REALLY BELIEVE THAT THESE BRAKES ARE POTENTIALLY DANGEROUS. *AK
NHTSA ODI #10049468
Official recalls
3Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Aug 9, 2002
ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER-SIDE AIR BAG INFLATOR MODULES WERE MANUFACTURED AND SHIPPED WITHOUT A NECESSARY COMPONENT KNOWN AS A CHECK VALVE PIN.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT INFLATE PROPERLY OR SUFFICIENTLY RESULTING IN AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST OR SEPTEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
Feb 22, 2001
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH THE INFLATORS IN THE PASSENGER SIDE AIR BAG MODULES HAVING THE WRONG AMOUNT OF GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, TOO MUCH GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG UNIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Illustration