NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
35 reportsClear category filter91,800 miles · Mar 2, 2011
Service Brakes, HydraulicSuspension
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT WAS DRIVING 5 MPH AND WHILE APPLYING THE BRAKES, THE VEHICLE WOULD NOT RESPOND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DISCOVERED THAT THE REAR SHOCK BRACKETS WERE RUSTED AND FRACTURED FROM THE VEHICLE. WHEN THE FAILURE OCCURRED, THE BRACKETS STRUCK THE …
Read full complaint
TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT WAS DRIVING 5 MPH AND WHILE APPLYING THE BRAKES, THE VEHICLE WOULD NOT RESPOND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DISCOVERED THAT THE REAR SHOCK BRACKETS WERE RUSTED AND FRACTURED FROM THE VEHICLE. WHEN THE FAILURE OCCURRED, THE BRACKETS STRUCK THE BRAKE LINES AND CAUSED A LOSS OF BRAKE FLUID AND BRAKING POWER. THE MECHANIC REPAIRED THE BRAKE LINES BUT THE RUSTED SHOCK BRACKET WAS NOT REPAIRABLE. THE CONTACT ATTEMPTED TO CALL BOTH THE DEALER AND MANUFACTURER BUT WAS UNSUCCESSFUL. THE FAILURE MILEAGE WAS 91,800.
NHTSA ODI #10386215
90,000 miles · Aug 11, 2008
Electrical SystemService Brakes, Hydraulic
TL*THE CONTACT OWNS A 2000 ISUZU RODEO. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE VIBRATED AND JERKED WHEN THE BRAKE PEDAL WAS DEPRESSED. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY STATED THAT THE FRONT BRAKES WERE OVERHEATED AND CRACKED. …
Read full complaint
TL*THE CONTACT OWNS A 2000 ISUZU RODEO. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE VIBRATED AND JERKED WHEN THE BRAKE PEDAL WAS DEPRESSED. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY STATED THAT THE FRONT BRAKES WERE OVERHEATED AND CRACKED. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON FOUR SEPARATE OCCASIONS FOR IDENTICAL FAILURES. RECENTLY, THE MECHANIC STATED THAT THE FAILURES WERE RELATED TO A DEFECT WITH THE ANTILOCK BRAKE SYSTEM UNIT AND ELECTRICAL ISSUES. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND CURRENT MILEAGE WAS 91,313.
NHTSA ODI #10237699
500 miles · Feb 13, 2008
EquipmentFuel System, GasolineFuel System, OtherCrashInjury
I TOOK THE DEALER ISUZU TO LEMON LAW AND I WAS TOLD IT WORKS AS DESIGNED. THE JURY WAS SO STUPID IT WAS UN BELIEVABLE, THEY ALL CAME UP TO MY WIFE AND I AND SAID MAKE SURE YOU TAKE THE CAR TO THE DEALERS TO GET IT FIXED. AHHHHHHHHHHHHH ISN'T THAT WHY I AM HERE IN COURT? GOOD LUCK PEOPLE ARE STUPID AND WE ARE STUCK DRIVING AN UN…
Read full complaint
I TOOK THE DEALER ISUZU TO LEMON LAW AND I WAS TOLD IT WORKS AS DESIGNED. THE JURY WAS SO STUPID IT WAS UN BELIEVABLE, THEY ALL CAME UP TO MY WIFE AND I AND SAID MAKE SURE YOU TAKE THE CAR TO THE DEALERS TO GET IT FIXED. AHHHHHHHHHHHHH ISN'T THAT WHY I AM HERE IN COURT? GOOD LUCK PEOPLE ARE STUPID AND WE ARE STUCK DRIVING AN UNSAFE CARE BECAUSE CONSUMER REPORTS WILL NOT GET INVOLVED. LEMON CARS FOR SALE ANY ISUZU CHEAP (RELATED VEHICLE INFORMATION: MODEL YEAR=2000, MAKE=ISUZU, MODEL=RODEO). *TR
NHTSA ODI #10217902
Mileage unknown · Jan 12, 2008
Service Brakes, Hydraulic
I HAVE 2000 ISUZU RODEO, AND WHEN THE BRAKES ARE APPLIED THE VEHICLE DOES NOT STOP!! THE BRAKES HAVE BEEN REPLACED TWICE EVERY YEAR SINCE WE HAVE OWNED THE VEHICLE. WE BOUGHT THE VEHICLE NEW IN OCTOBER 2000. THE BRAKES ARE CONSTANTLY BEING ADJUSTED ALMOST MONTHLY. THE MECHANIC AT "EXPERT TIRE" ON MCNIEL ST, WICHITA FALLS TX.…
Read full complaint
I HAVE 2000 ISUZU RODEO, AND WHEN THE BRAKES ARE APPLIED THE VEHICLE DOES NOT STOP!! THE BRAKES HAVE BEEN REPLACED TWICE EVERY YEAR SINCE WE HAVE OWNED THE VEHICLE. WE BOUGHT THE VEHICLE NEW IN OCTOBER 2000. THE BRAKES ARE CONSTANTLY BEING ADJUSTED ALMOST MONTHLY. THE MECHANIC AT "EXPERT TIRE" ON MCNIEL ST, WICHITA FALLS TX. HAVE ENCOUNTERED THE SAME PROBLEMS WITH OTHER ISUZU RODEOS AND HAVE DIRECTED US TO BRING THE VEHICLE TO THE ISUZU DEALERSHIP. I CAN NOT BELIEVE THAT THIS MAJOR SAFETY ISSUE HAS NOT BEEN ADDRESSED. THE MECHANIC AT EXPERT TIRE BELIEVES THAT ABS SYSTEM HAS A RECALL BUT WE HAVE NEVER BEEN NOTIFIED NOR IS IT LISTED ON THE ISUZU RODEO RECALL WEB SITE. *TR
NHTSA ODI #10214584
79,300 miles · Dec 20, 2005
Power TrainService Brakes, HydraulicVehicle Speed ControlCrash
VEHICLE ACCELERATED WHILE COASTING CAUSING VEHICLE TO FISH-TAIL AND SPIN OUT. ONCE VEHICLE CORRECTED BRAKES/ABS DID NOT ENGAGE (NO PULSE IN BRAKE PEDAL NO SQUEALING TIRES) RESULTING IN VEHICLE CAREENING OF THE ROAD. *JB
NHTSA ODI #10145675
Mileage unknown · Feb 13, 2004
Service Brakes, Hydraulic
WHILE DRIVING 55 MPH ABS BRAKING LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON UNTIL THE VEHICLE WAS TURNED OFF. CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO FLOOR. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT ABS MODULE NEEDED TO BE REPLACED. *AK
NHTSA ODI #10059126
31,750 miles · Feb 6, 2004
Service Brakes, Hydraulic
200 ISUZU RODEO--BRAKING PROBLEM--PEDAL GOES TO FLOOR-EXTENDED BRAKING TIME, BRAKES HAVE COMPLETELY FAILED ONE TIME. HAVE HAD GRINNDING NOISE WHEN APPLYING BRAKES OVER SMALL BUMPS, WITH LOSS OF BRAKES. THE CAR HAS BEEN TO 3 INDEPENDENT MECHANICS TO HAVE BRAKES CHECKED AND ALL SAY PADS AND ROTORS ARE FINE, BUT BRAKING IS STILL…
Read full complaint
200 ISUZU RODEO--BRAKING PROBLEM--PEDAL GOES TO FLOOR-EXTENDED BRAKING TIME, BRAKES HAVE COMPLETELY FAILED ONE TIME. HAVE HAD GRINNDING NOISE WHEN APPLYING BRAKES OVER SMALL BUMPS, WITH LOSS OF BRAKES. THE CAR HAS BEEN TO 3 INDEPENDENT MECHANICS TO HAVE BRAKES CHECKED AND ALL SAY PADS AND ROTORS ARE FINE, BUT BRAKING IS STILL VERY DIFFICULT. *AK
NHTSA ODI #10056670
Mileage unknown · Dec 9, 2003
Service Brakes, Hydraulic
00 ISUZU RODEO ABS ISSUES I FIND THE ABS KICKING IN WHEN RUNNING OVER SMAL BUMP AND ROCKY SURFACES. THIS IS MY WIFES AUTOMOBILE, AND I HAVE BEEN DRIVING IT FOR ABOUT A MONTH NOW, AND REALLY BELIEVE THAT THESE BRAKES ARE POTENTIALLY DANGEROUS. *AK
NHTSA ODI #10049468
30,000 miles · Oct 24, 2003
Service Brakes, Hydraulic
WHEN APPLYING THE BRAKES AT 3 MPH, THE PEDAL WENT TO THE FLOOR BEFORE STOPPING. THE VEHICLE WAS TAKEN TO A REPAIR SHOP AND THE DEALER STATED THERE WAS NOTHING WRONG WITH THE BRAKE SYSTEM. PLEASE PROVIDE ANY FURTHER INFORMATION AND COMPLETE THE QUESTIONNAIRE.
NHTSA ODI #10044663
52,000 miles · Sep 10, 2003
Service Brakes, Hydraulic
WHEN DRIVING AND APPLYING THE BRAKES THEY DID NOT STOP AT A SAFE DISTANCE. ON TWO OCCASIONS VEHICLE WENT THROUGH THE INTERSECTION, ALMOST CAUSING AN ACCIDENT. THIS HAPPENED TO THE CONSUMER ONCE AND TO THE CONSUMER'S DAUGHTER ONCE. THE MANUFACTURER AND DEALER WERE NOTIFIED.*AK
NHTSA ODI #10039713
Official recalls
3Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Aug 9, 2002
ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER-SIDE AIR BAG INFLATOR MODULES WERE MANUFACTURED AND SHIPPED WITHOUT A NECESSARY COMPONENT KNOWN AS A CHECK VALVE PIN.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT INFLATE PROPERLY OR SUFFICIENTLY RESULTING IN AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST OR SEPTEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
Feb 22, 2001
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH THE INFLATORS IN THE PASSENGER SIDE AIR BAG MODULES HAVING THE WRONG AMOUNT OF GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, TOO MUCH GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG UNIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Illustration