IllustrationAT TIMES WHEN COMING TO A STOP WITH FOOT ON BRAKE VEHICLE MOTOR REVS AND LURCHES HARD TO KEEP STOPPED AND YOU AT TIMES WIND UP IN THE MIDDLE OF AN INTERSECTION. I PURCHASED THE CAR FROM MY SISTER BECAUSE SHE WAS TO SCARED TO DRIVE IT. VEHICLE WAS TAKEN TO ISUZU DEALER TWICE BUT STILL HAS THE PROBLEM. *KB
2000 Isuzu Rodeo
Owner reports · Recalls · Investigations
More warning signs than most Rodeo years
Owner complaints for the 2000 Isuzu Rodeo are substantially higher than the model-year median of 89.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rodeo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1825–50K
3450–75K
3375–100K
55100–150K
18150K+
165 reports with mileage · 109 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports7 fire reports11 injury reports
Power Train complaints
18 reportsI BOUGHT THIS 2000 ISUZU RODEO IN 2002, AND HAVE HAD TO INSTALL 2 AUTOMATIC TRANSMISSION..MY MILEAGE IS JUST OVER 102000. ANY HELP OR RECALL FOR THIS PROBLEM. *TR
2000 ISUZU RODEO---@ 62,131 MILES TRANSMISSION WAS SLIPPING AND SMOKE CAME OUT FROM UNDER HOOD VEHICLE WHILE TRAVELING ON THE HIGHWAY. VEHICLE WAS TOWED TO DEALER. TOLD IT WAS A PROBLEM WITH THE INTERNAL TRANSMISSION. TRANSMISSION WAS REPLACED AT NO CHARGE UNDER THE MANUFACTURER 10 YEAR/120,000 MILE POWER TRAINMISSION WARRAN…
Read full complaint
2000 ISUZU RODEO---@ 62,131 MILES TRANSMISSION WAS SLIPPING AND SMOKE CAME OUT FROM UNDER HOOD VEHICLE WHILE TRAVELING ON THE HIGHWAY. VEHICLE WAS TOWED TO DEALER. TOLD IT WAS A PROBLEM WITH THE INTERNAL TRANSMISSION. TRANSMISSION WAS REPLACED AT NO CHARGE UNDER THE MANUFACTURER 10 YEAR/120,000 MILE POWER TRAINMISSION WARRANTY. AGAIN @ 92,204 MILES THE VEHICLE WAS JERKING WHILE SHIFTING GEARS AND TRANSMISSION LIGHT CAME ON. VEHICLE WAS TAKEN TO DEALER. DEALER DETERMINED THE PROBLEM TO BE THE INHIBITOR SWITCH RELATED TO THE EXTERNAL TRANSMISSION. INHIBITOR SWITCH WAS REPLACED, BUT NOT COVERED UNDER THE POWER TRAIN WARRENTY BECAUSE IT WAS PART OF THE EXTERNAL TRANSMISSION. AGAIN @ 98,489 MILES THE TRANSMISSION WAS SLIPPING WHILE DRIVING. AFTER COMING TO A STOP, THE VEHICLE WOULD NOT ACCELERATE, UNABLE TO DRIVE OVER 20MPH. VEHICLE WAS TAKEN TO DEALER. THE PROBLEM WAS AGAIN DETERMINED TO BE THE INTERNAL TRANSMISSION. TRANSMISSION WAS REPLACED FOR THE 2ND TIME @ NO CHARGE UNDER THE MANUFACTURER 10YEAR/120,000 MILE POWER TRAIN WARRANTY. *AK
VEHICLE ACCELERATED WHILE COASTING CAUSING VEHICLE TO FISH-TAIL AND SPIN OUT. ONCE VEHICLE CORRECTED BRAKES/ABS DID NOT ENGAGE (NO PULSE IN BRAKE PEDAL NO SQUEALING TIRES) RESULTING IN VEHICLE CAREENING OF THE ROAD. *JB
DT: THE VEHICLE WAS PARKED WITH THE GEAR SHIFTER IN THE PARK POSITION AND THE KEY WAS NOT IN THE IGNITION. CONSUMER'S SON, WHO WAS 2 YEARS OLD, WAS SITTING IN THE BACK SEAT. CHILD WAS NOT RESTRAINED IN A CHILD SAFETY SEAT. CONSUMER WENT INSIDE THE HOUSE FOR A MINUTE AND WHEN HE RETURNED THE CAR ROLLED AND CRASHED AT THE END …
Read full complaint
DT: THE VEHICLE WAS PARKED WITH THE GEAR SHIFTER IN THE PARK POSITION AND THE KEY WAS NOT IN THE IGNITION. CONSUMER'S SON, WHO WAS 2 YEARS OLD, WAS SITTING IN THE BACK SEAT. CHILD WAS NOT RESTRAINED IN A CHILD SAFETY SEAT. CONSUMER WENT INSIDE THE HOUSE FOR A MINUTE AND WHEN HE RETURNED THE CAR ROLLED AND CRASHED AT THE END OF CONSUMER'S NEIGHBOR'S YARD, STRIKING A TREE. THERE WAS A MODERATE INCLINE IN THE DRIVEWAY ABOUT 45 DEGREE ANGLE. THERE WAS SUBSTANTIAL DAMAGE TO VEHICLE. UPON INSPECTION OF THE VEHICLE IT WAS NOTED THAT THE GEAR SHIFT WAS IN THE THIRD POSITION. DID REFER TO THE OWNER'S MANUAL. CALLED DEALER , WHO REFERRED CONSUMER TO CUSTOMER SERVICE OF ISUZUI. THEY OFFERED NO ASSISTANCE. AT THIS TIME, NO REPAIRS WERE MADE. CONSUMER HAD VEHICLE TOWED TO A LOCAL MECHANIC SHOP. *AK
MY TRANSMISSION IS ABOUT TO GO OUT. I WAS TOLD THEY HAD A 5 YEAR/60,000 MILE WARRENTY, SO WHEN I CALLED THE ISUZU THERE WAS NOTHING THEY COULD DO, SINCE MY WARRENTY EXPRIRED 45 DAYS BEFORE. I ONLY HAVE 44,000 MILES ON IT, AND DON'T HAVE THE MONEY TO REPLACE IT. I REALLY FEEL THAT ISUZU SHOULD STAND BY THE PRODUCT AND TAKE R…
Read full complaint
MY TRANSMISSION IS ABOUT TO GO OUT. I WAS TOLD THEY HAD A 5 YEAR/60,000 MILE WARRENTY, SO WHEN I CALLED THE ISUZU THERE WAS NOTHING THEY COULD DO, SINCE MY WARRENTY EXPRIRED 45 DAYS BEFORE. I ONLY HAVE 44,000 MILES ON IT, AND DON'T HAVE THE MONEY TO REPLACE IT. I REALLY FEEL THAT ISUZU SHOULD STAND BY THE PRODUCT AND TAKE RESPONSIBILTY THAT THERE IS AN ISSUE WITH THE TRANSMISSION FAILING.
OUR CAR BROKE DOWN ON THANKSGIVING AND WE FOUND OUT THE FOLLOWING MONDAY THAT THE ENTIRE TRANSMISSION WENT OUT. FORTUNATELY WE HAVE AN EXTENDED WARRANTY THAT WILL HELP WITH OUR COSTS OF REPLACING THE TRANSMISSION FOR A BRAND NEW ONE. HOWEVER, THE CLUTCH WAS DAMAGED AND HAS TO BE REPLACED ALSO AND WE ARE STILL WAITING TO RECEIV…
Read full complaint
OUR CAR BROKE DOWN ON THANKSGIVING AND WE FOUND OUT THE FOLLOWING MONDAY THAT THE ENTIRE TRANSMISSION WENT OUT. FORTUNATELY WE HAVE AN EXTENDED WARRANTY THAT WILL HELP WITH OUR COSTS OF REPLACING THE TRANSMISSION FOR A BRAND NEW ONE. HOWEVER, THE CLUTCH WAS DAMAGED AND HAS TO BE REPLACED ALSO AND WE ARE STILL WAITING TO RECEIVE THE REPLACEMENT TRANSMISSION THAT HAS TO BE SHIPPED FROM CALIFORNIA. THIS VEHICLE IS SITTING JUST OVER 82,000 MILES, (FAR TOO FEW MILES TO HAVE SUCH BIG PROBLEMS). *JB
TRANSMISSION PROBLEMS RENDER THIS VEHICLE COMPLETELY UNSAFE. *BF TRANSMISSION SEAL LEAKING AND NEEDED TO BE REPLACED. THE FOUR WHEEL DRIVE LIGHT CONTINUALLY FLASHES AND DOES NOT STAY ON. THE VEHICLE ALSO HAS A SHIMMY AT 50 MPH. THE ENGINE KEY BECAME STUCK IN THE LOCK CYLINDER.
WHILE BRAKES ARE FULLY DEPRESSED THE VEHICLE MOVES FORWARD. RETURNED VEHICLE TO DEALER THREE TIMES PRIOR TO WARRANTY EXPIRING. MECHANIC STATED THAT THEY COULD NOT DUPLICATE. NOW, AND FOR THE PAST TWELVE MONTHS, WHEN THE GEAR SHIFT (BETWEEN THE SEATS) IS IN DRIVE ON THE INDICATOR PANEL (DASH BOARD) IT INDICATED THE VEHICLE IS …
Read full complaint
WHILE BRAKES ARE FULLY DEPRESSED THE VEHICLE MOVES FORWARD. RETURNED VEHICLE TO DEALER THREE TIMES PRIOR TO WARRANTY EXPIRING. MECHANIC STATED THAT THEY COULD NOT DUPLICATE. NOW, AND FOR THE PAST TWELVE MONTHS, WHEN THE GEAR SHIFT (BETWEEN THE SEATS) IS IN DRIVE ON THE INDICATOR PANEL (DASH BOARD) IT INDICATED THE VEHICLE IS IN NEUTRAL AND SOMETIMES REVERSE. *AK
WHEN PUTTING THE VEHICLE IN DRIVE CONSUMER NOTICED THAT THE PANEL GAVE THE WRONG INFORMATION, ON WHAT GEAR THE VEHICLE WAS IN. THIS CAUSED THE TRANSMISSION TO SLIP. CONSUMER CONTACTED THE DEALERSHIP ABOUT THIS ISSUE. *AK
Official recalls
310V436000 · Suspension:rear
Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
02V213000 · Air Bags:frontal
Aug 9, 2002
ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER-SIDE AIR BAG INFLATOR MODULES WERE MANUFACTURED AND SHIPPED WITHOUT A NECESSARY COMPONENT KNOWN AS A CHECK VALVE PIN.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT INFLATE PROPERLY OR SUFFICIENTLY RESULTING IN AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST OR SEPTEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
01V055000 · Air Bags:frontal
Feb 22, 2001
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH THE INFLATORS IN THE PASSENGER SIDE AIR BAG MODULES HAVING THE WRONG AMOUNT OF GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, TOO MUCH GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG UNIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.