THE CRUISE CONTROL AND CHECK ENGINE LIGHTS COME ON AFTER HITTING A BUMP OR JUST RANDOMLY AND VEHICLE SPUTTERS AND SOMETIMES SHUTS OFF COMPLETELY! WE HAVE ALMOST BEEN KILLED SEVERAL TIMES FROM THE VEHICLE STALLING OUT!THIS HAS BEEN HAPPENING FOR ABOUT 5 MONTHS AND NO ONE COULD FIGURE IT OUT. I FINALLY GOT AN ELECTRICAL SPECIAL…
Read full complaint
THE CRUISE CONTROL AND CHECK ENGINE LIGHTS COME ON AFTER HITTING A BUMP OR JUST RANDOMLY AND VEHICLE SPUTTERS AND SOMETIMES SHUTS OFF COMPLETELY! WE HAVE ALMOST BEEN KILLED SEVERAL TIMES FROM THE VEHICLE STALLING OUT!THIS HAS BEEN HAPPENING FOR ABOUT 5 MONTHS AND NO ONE COULD FIGURE IT OUT. I FINALLY GOT AN ELECTRICAL SPECIALIST TO FIGURE IT OUT AND HE SAID IT IS A SHORT IN THE ENGINE WIRING HARNESS AND THE HARNESS NEEDS TO BE REPLACED AT A COST OF AROUND $1,600.00 HE SAID IT IS A FACTORY DEFECT AND ISUZU SHOULD REPLACE IT. ISUZU REFUSES TO DO SO EVEN THOUGH THERE ARE NUMEROUS REPORTS ON THE INTERNET OF THE SAME PROBLEM, PLUS ISUZU HAD A RECALL FOR THE EXACT SAME ISSUE WITH THE WIRING HARNESS ON THE 1998 RODEO, YET THEY WON'T DO ANYTHING. I AM AT THE END OF MY ROPE. I NOW HAVE A VEHICLE I STILL OWE 2 YEARS PAYMENTS ON AND I CAN'T SAFELY DRIVE IT! *TR
NHTSA ODI #10226050
10,300 miles · Oct 16, 2006
Vehicle Speed Control
I BOUGHT THE 2001 RODEO SPORT IN 2001, IT WAS FINE UNTIL RECENTLY WHEN I WAS DRIVING AND IT JUST TURNED OFF THEN I WAS ABLE TO RESTART IT NO PROBLEM. THEN THE NEXT DAY THE CRUISE CONTROL SET ITSELF WHEN I WAS TRYING TO ACCELERATE AND THEN IT WENT OFF AND THEN IT HAS ALSO JUST SET THE CRUISE CONTROL WITHOUT ME DOING ANYTHING AND …
Read full complaint
I BOUGHT THE 2001 RODEO SPORT IN 2001, IT WAS FINE UNTIL RECENTLY WHEN I WAS DRIVING AND IT JUST TURNED OFF THEN I WAS ABLE TO RESTART IT NO PROBLEM. THEN THE NEXT DAY THE CRUISE CONTROL SET ITSELF WHEN I WAS TRYING TO ACCELERATE AND THEN IT WENT OFF AND THEN IT HAS ALSO JUST SET THE CRUISE CONTROL WITHOUT ME DOING ANYTHING AND THEN THE CRUISE LIGHTS WENT OUT. ALSO THIS HAPPENS WHEN I GO OVER SPEED BUMPS AND SOMETIME WHEN I TURN CORNERS AND TODAY IT HAPPENED TWICE ON THE HIGHWAY AND I WAS FORCED TO PULL OVER. *NM
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. DURING THE MANUFACTURE OF CERTAIN FUEL RETURN HOSES, INCORRECT RUBBER MATERIAL FOR THE OUTER LAYER WAS USED.
Consequence & remedy
Consequence: THE FUEL RETURN HOSE DOES NOT MEET OZONE-RESISTANT SPECIFICATIONS, AND COULD ULTIMATELY CRACK, CAUSING FUEL LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE VEHICLE TO DETERMINE IF THE VEHICLE WAS EQUIPPED WITH AN INCORRECT HOSE. IF IT IS INCORRECT, DEALERS WILL REPLACE IT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
2001 Isuzu Rodeo Sport Problems, Complaints & Recalls | Skip That Year
Illustration