Electrical SystemEngine And Engine CoolingExterior Lighting
AT 4,000 MILES FRONT BRAKES WOULD FADE INTERMITTENTLY WHEN APPLIED. VEHICLE BEEN IN DEALER SHOP ON SEVERAL OCCASIONS, AND PROBLEM STILL REOCCURRING. *AK PROBLEMS WITH THE MASTER CYLINDER CAUSE BRAKE LIGHTS TO FLASH, FRONT BRAKES HAVE LOCKED UP THE FRONT WHEEL ON TWO OCCASIONS, REAR BRAKES HAVE FAILED COMPLETELY THREE OCCASIONS…
Read full complaint
AT 4,000 MILES FRONT BRAKES WOULD FADE INTERMITTENTLY WHEN APPLIED. VEHICLE BEEN IN DEALER SHOP ON SEVERAL OCCASIONS, AND PROBLEM STILL REOCCURRING. *AK PROBLEMS WITH THE MASTER CYLINDER CAUSE BRAKE LIGHTS TO FLASH, FRONT BRAKES HAVE LOCKED UP THE FRONT WHEEL ON TWO OCCASIONS, REAR BRAKES HAVE FAILED COMPLETELY THREE OCCASIONS, FRONT ROTOR WARPED, REAR MASTER CYLINDER HAS BEEN REPLACED, FRONT MASTER CYLINDER REPLACED, REAR BRAKE PADS REPLACED. TAPPING NOISE IN ENGINE, DRIVE BELT NOISY, OIL LEAK, ENGINE BACKFIRES. REAR TURN SIGNAL LENS COLLECTS MOISTURE. HANDLE BAR MASTER BAD. BLOWN CLUTCH DUE TO ASSEMBLED WRONG IN FACTORY. FUEL TANKS REPLACED DUE TO CRACKS AROUND MOUNTING BRACKETS CAUSED FUEL TO LEAK ON THE HOT ENGINE. SHOCKS SQUEAK. IGNITION SWITCH REPLACED. *SLC
NHTSA ODI #890209
Mileage unknown · Jun 1, 2001
Power Train
5 SPEED TRANSMISSION IS LEAKING FLUID. DEALER NOTIFIED, AND PROBLEM STILL REOCCURRING. FEEL FREE TO PROVIDE US WITH ANY FURTHER INFORMATION CONCERNING THIS MATTER . *AK
CERTAIN WINDSHIELDS THAT WERE SOLD AS STANDARD EQUIPMENT ON THESE MOTORCYCLES OR SOLD AS ACCESSORIES FOR ALL OTHER CHIEF MODELS MAY HAVE DEFECTIVE BRACKETS. THE BRACKETS THAT ATTACH THE WINDSHIELD TO THE MOTORCYCLE ARE FORMED SUCH THAT THE MOUNTING BOLTS ARE NOT FLUSH WITH THE BRACKET. THIS COULD PLACE EXCESSIVE STRESS ON THE BOLTS CAUSING THEM TO BREAK.
Consequence & remedy
Consequence: BROKEN MOUNTING BOLTS COULD LEAD TO THE WINDSHIELD COMING LOOSE AND EVEN FALLING OFF THE BIKE, POTENTIALLY STRIKING THE RIDER OR OTHERWISE CAUSING THE RIDER TO LOSE CONTROL OF THE MOTORCYCLE AND CRASH.
Remedy: DEALERS WILL REPLACE THE BRACKETS AND BOLTS ON THE WINDSHIELD. OWNER NOTIFICATION BEGAN MAY 30, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INDIAN MOTORCYCLE AT 1-888-899-2997.
ON CERTAIN MOTORCYCLES EQUIPPED WITH COMPUFIRE BRAND SERIES TYPE VOLTAGE REGULATORS, IF DAMAGED, THE VOLTAGE REGULATOR CAN BECOME STUCK IN AN OPEN MODE THAT ALLOWS BATTERY VOLTAGE TO FLOW BACK THROUGH THE REGULATOR.
Consequence & remedy
Consequence: THIS CONDITION CAN POTENTIALLY CAUSE THE REGULATOR TO CATCH ON FIRE.
Remedy: DEALERS WILL INSPECT THE MOTORCYCLE AND, IF NECESSARY, REPLACE THE REGULATOR. OWNER NOTIFICATION BEGAN FEBRUARY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INDIAN MOTORCYCLE AT 1-888-899-2997.
ON CERTAIN MOTORCYCLES, THE HANDLE BAR RISER TOP CLAMP COULD ALLOW EXCESSIVE MOVEMENT OF THE HANDLE BARS.
Consequence & remedy
Consequence: LOSS OF CONTROL OF THE MOTORCYCLE COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL FIT THE MOTORCYCLES WITH A NEW RISER TOP CLAMP. OWNER NOTIFICATION BEGAN MAY 31, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INDIAN MOTORCYCLE AT 1-408-846-7228.
ON CERTAIN MOTORCYCLES EQUIPPED WITH REAR SHOCK ABSORBERS MADE BY SWAY-A-WAY, THE BOLTS THAT MOUNT THE REAR SHOCK ABSORBERS TO THE SWING ARM COULD BREAK.
Consequence & remedy
Consequence: THIS COULD RESULT IN THE COLLAPSE OF THE REAR SUSPENSION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SHOCK ABSORBERS AND REPLACE THEM IF NECESSARY. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INDIAN AT 1-408-846-7228.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE02037 · Handlebar Loosening
Opened Mar 26, 2002 · Closed May 24, 2002
Status: closed (inferred from source dates) · Structure
ODI OPENED THIS INVESTIGATION AFTER RECEIVING ONE OWNER COMPLAINT REGARDING TWO INSTANCES OF HANDLEBAR LOOSENING ON A 2000 INDIAN CHIEF MODEL MOTORCYCLE.THIS WAS OCCURRING BECAUSE THE HANDLEBAR RISER CLAMP MATERIAL WAS TWW SOFT RESULTING IN INSUFFICIENT CLAMPING FORCE NECESSARY TO FULLY SECURE THE HANDLEBAR IN CERTAIN FORESEEABLE MANEUVERS.INDIAN IS RECALLING THE SUBJECT VEHICLES TO REPLACE THE INFERIOR RISER CLAMP WITH ANOTHER OF MORE ROBUST MATERIAL.
PE01039 · Rear Suspension Collapse
Opened Nov 21, 2001 · Closed Apr 30, 2002
Status: closed (inferred from source dates) · Suspension
SIX MANUFACTURER INCIDENTS OF BROKEN REAR SUSPENSION SHOCK ABSORBER MOUNTING BRACKETS AND FORTY-TWO OF BROKEN SHOCK BOLTS.THE ORIGINAL SWAY-AWAY REAR SHOCK ABSORBERS (IDENTIFIED BY A BLACK HOUSING) ARE NOT ADEQUATE FOR THE SUBJECT BIKES' GVWR.SHOCK BOTTOMING (I.E., COIL BIND) CONSEQUENTLY OCCURS AT THE UPPER RANGE OF THE MACHINE'S WEIGHT CARRYING CAPACITY AND THE RESULTING LOADS BREAK THE SHOCK MOUNTING BRACKETS AND/OR BOLTS.INDIAN IS RECALLING THE SUBJECT MOTORCYCLES TO INSTALL SHOCK ABSORBERS FROM PROGRESSIVE SUSPENSION.THE PROGRESSIVES HAVE A GREATER LOAD CARRYING CAPABILTY AND MAY BE IDENTIFIED BY THE GOLD COLOR.WITH INDIAN'S RECALL, ODI IS CLOSING THIS PE.
1999 Indian Chief Problems, Complaints & Recalls | Skip That Year
Illustration