Air Bags. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports1 fire reports0 injury reports

Fuel System, Other complaints

1 reports

Clear category filter

Mileage unknown · Dec 29, 2006

Fuel System, GasolineFuel System, OtherPower Train

Read full complaint

I BOUGHT THE 2004 HYUNDAI XG350 IN FEBRUARY 05. IN SUMMER OF 06 I BEGAN HAVING PROBLEMS WITH THE DIGITAL READING OF MILES TOGO BEFORE "E". IT DOES NOT RESET WHEN GAS HAS BEEN PUT IN, IT TAKES A FEW TURNS OF THE KEY TO REGISTER. I WAS DRIVING MY SON TO SCHOOL ONE MORNING AND AS I TRIED TO ACCELERATE TO GO UP A HILL THE CAR BEGAN TO STUDDER, CHECK ENGINE LIGHT APPEARED,IT FELT LIKE SOMETHING WASNT CATCHING IN ORDER FOR THE VEHICLE TO MOVE. WHEN I STOPPED A THE RED LIGHT AND SLOWLY TOOK MY FOOT OFF THE BRAKE IT WOULD LUNGE FORWARD. I ENDED UP HAVING TO HAVE IT TOWED TO THE DEALER. OF COURSE THE PROBLEM DIDNT HAPPEN WHEN THEY TEST DROVE. THEY CHANGED THE SENSOR AND IT HASNT BEEN SYMPTOM FREE. STILL SLOW TO RESET GAS MILEAGE, STILL STUDDERS, CHECK ENGINE LIGHT. WHEN IT STARTS TO STUDDER I AM ABLE TO DRIVE UNDER 60MPH, SHIFTING DRIVE 1-2-3 LIKE A STICK SHIFT. ONCE I TRY TO GO OVER 60 MILES PER HOUR (HIGHWAY) CAN NOT DO IT WITHOUT CONTINUOUS STUDDER.

NHTSA ODI #10177291

Official recalls

09V124000 · Suspension

Apr 16, 2009

HYUNDAI IS RECALLING 188,282 MY 2001-2004 SONATA AND MY 2001-2004 XG300 AND XG350 VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUB-FRAME ON THE VEHICLES, AND MAY RESULT IN THINNING OR PERFORATION OF THE SUB-FRAME STEEL. THE CORROSION IS FREQUENTLY VISIBLE AND OFTEN DISCOVERED DURING INSPECTION OR ROUTINE MAINTENANCE, AND OWNERS MAY ALSO HEAR NOISES OR NOTICE TIRE MISALIGNMENT AND STEERING PULL. IF THESE SIGNALS ARE UNDETECTED OR UNHEEDED, THE CORROSION MAY PROGRESS AND THE FORWARD MOUNTING OF THE LOWER CONTROL ARM MAY DETACH FROM THE SUB-FRAME.

Consequence & remedy

Consequence: IF THAT HAPPENS, THE VEHICLE MAY LOSE DRIVE POWER TO THE WHEELS, AND THE FRONT WHEEL MAY MAKE CONTACT WITH THE FENDER OR WHEEL WELL, THEREBY INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL MEASURE THE THICKNESS OF THE FRONT SUB-FRAME AND INSPECT THE FRONT SUB-FRAME FOR CORROSION DAMAGE AND, IF NECESSARY, THE FRONT SUB-FRAME WILL BE REPLACED WITH A NEW SUB-FRAME THAT INCORPORATES ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT SUB-FRAME DOES NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE SUB-FRAME AND WILL TREAT THE SUB-FRAME WITH RUST-PROOFING MATERIAL TO STOP THE CORROSION PROCESS. THIS PROCEDURE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.