2019 Hyundai Tucson

The component involved is the engine and associated knock detection system (KSDS). The system triggered a P1326 code indicating abnormal engine knock associated with a known defect condition. On February 14, 2023, while driving on the freeway, the vehicle suddenly entered reduced power (“limp mode”) and lost acceleration capability in active traffic. This created a safety risk, as the vehicle was unable to maintain speed with surrounding traffic or accelerate as needed for normal driving conditions. There were no sufficient warnings prior to the event to allow safe planning or avoidance of the loss of power condition. The system activation itself (P1326 and limp mode) was the first indication of the severity of the issue. The problem has been reproduced multiple times, with repeated P1326 events occurring after the initial incident. The condition has been inspected and partially confirmed by a Hyundai dealership. In March 2026, dealership records documented that oil contamination was causing catalytic converter failure, indicating ongoing engine-related deterioration consistent with the defect condition identified by the knock detection system. Despite these findings, the underlying engine condition has not been resolved. The KSDS system is designed to detect a potentially serious engine defect and limit engine power to prevent further damage. However, it does not correct the underlying defect. As a result, the vehicle may continue to operate with a known compromised condition that can trigger reduced power unexpectedly. This creates an ongoing safety concern. A vehicle that can suddenly lose acceleration due to a known defect presents a risk to the driver, passengers, and other motorists, particularly during freeway driving, merging, or other situations requiring normal engine performance. The vehicle remains available for inspection upon request.

The vehicle was brought in just after a month of owning it due to it was accelerating slow and driving bad salesmans sent it to Hyundai dealership for diagnosis and it came back that the motor needed to be replaced due to recall vehicle was in repair shop for over 3 months to get a new motor once returned the very next day the check engine light came back on so I brung it back to the Hyundai dealership per Hub City's salesmans instruction to have vehicle diagnosis again. Hyundai advised that the vehicle needed a catalyst converter among other codes detected on vehicle.

’ve replaced the catalytic converter two times , the check engine light is on so it says I need another catalytic converter, that was in June 2024. The car was at the shop yesterday, needs catalytic converter and oil is pooling all throughout the car , fumes from the exhaust are coming back into the car which makes me physically ill. The engine revs and slows down by itself, it goes through oil on such a regular basis that I have to carry a full size jug of oil with me at all times because I need to put it in before I leave work and when I am on my way back home , the dipstick will be dry.

On 05/11/2024, I accelerated onto the freeway at which point my vehicle would no longer go past 50 mph with the pedal to the floor. I had my two small children in the car at the time. It was dangerous as cars around us were going 65+ mph. The check engine light started blinking when this was occurring. Prior to that the check engine light had been on because the dealership claimed they didn’t know why it was triggering and that they have to take my engine out and replace it just to explore the issue. I don’t have the money for that. It has a knocking sound, a pungent fuel smell and it still won’t accelerate. I only have 85k miles on the car.

Almost got killed!!! This car is dangerous!!! I feel lucky I can still write to you. Hyundai 2019 Tucson (TL) 2.0L has been plagued by a recall and related known defects that create dangerous and life-threatening situations on the highways 3 times in 10 months for us!!! Vehicle year, make & model: Hyundai 2019 Tucson (TL) 2.0L car Approximate mileage: Current ~37,000 How many repairs visits to the dealer? total 4 (First time was Hyundai recall, 3 times Check engineer light flash on interstate highway and the car went to limp mode and reduced speed drastically) A short description of the problem: Car has been plagued by a recall and related known defects that create dangerous and life-threatening situations on highway. 1). Recall on [XXX] (with only 19395 miles on it); 2). [XXX]. The car only had 22036 miles on it, on [XXX] near San Francisco; 3). [XXX] while driving on [XXX] north of Portland; 4). [XXX] during the afternoon pre rush hour traffic before 3:00 PM on highway [XXX] near Tigard (currently undergoing road construction with no shoulder, and many cars driving at high speed) Almost hit by a car behind me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have a Hyundai Tuscon 2019, which was pre-certified by Hyundai. This particular car was part of a lawsuit because of a knock sensor issue. The lawsuit information is here: [XXX] The knock sensor failing is not really what causes the safety issue. The engine symptoms when the sensor fails is the issue. The engine goes into "safety mode" which limits the car to a significant slower speed. The problem is that Hyundai has now tried to fix this issue twice on my vehicle, and the knock sensor continues to fail. To be clear, they've replaced the sensor twice. Based on the lawsuit, the court mandated them to fix the knock sensor. They have done that free of charge, but the sensor continues to fail. To me this sounds like a manufacture issue. It is incredibly dangerous when you're on a highway and the sensor fails. It happened to me, and it was almost catastrophic. The car slowed down and there is nothing you can do about it. I noticed there was something wrong very quickly and put my hazards on. If I didn't, I may not be writing you here. You could easily get into a significant accident, and from that could lead to injury or loss of life. I am asking for a review of this. I have my service records as well as recorded conversations with Hyundai corporate regarding this issue. Service records are attached. I live very close to NHTSA HQ and willing to come in if necessary. To me, this is concerning enough for that.. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

At approximately 69000 miles my engine stalled as I was pulling onto a highway and would not accelerate beyond a low mph. I turned back into gas station I had left and checked the oil. It did not register any oil and had a burning smell. There were never any dash lights indicating low oil. I put almost 2 quarts in vehicle. I then proceeded to drive as it seemed okay. I have had oil changes where the technicians have told me I was low on oil even though it was a normal time frame for oil change. I recently checked my oil just right as my oil change is due and the oil level did not register, nor were there any low oil indicators on dash. I had to add a quart of oil. This poses a hazard/safety problem. If not checked more often than normal, oil could go low and stall again. If pulling into a busy traffic area and a stall occurs, there could be an accident etc not to mention damage to the motor/engine itself. I have to frequently check the oil levels which should not have to happen for a vehicle with 70k+ miles.

I have been experiencing serious safety issues with the 2019 Hyundai Tucson I purchased that have been ongoing since February of 2023. The check engine light comes on, begins to flash, and the car goes into 'limp mode' and will not allow me to accelerate faster than 45/50 mph. Consequently, it will further stall on hills due to the inability to accelerate. Below is a brief timeline of this incident: - February 21: Bring in vehicle to dealer as recommended for oil change, tire rotation, cabin air filter, and a recall. The recall issue was as follows: 966 engine monitoring logic, 22-01-028H-1, caused by ecm update, 966 campaign, ecm update op code 10d021r9.3 - February: 24: Check engine light comes on, flashing, and unable to accelerate past 45-50 mph. - February 27: Return to dealer and bring in vehicle for check engine/no acceleration issue. - March 2: Pick up vehicle from dealer - March 8: Check engine light comes on again, flashing, and unable to accelerate past 45-50 mph. - March 9: Return to dealer and bring in vehicle for check engine/no acceleration issue. - April 5: Pick up vehicle from dealer - April 8: Check engine light comes on again, flashing, and unable to accelerate past 45-50 mph. - April 10: Return to dealer and bring in vehicle for check engine/no acceleration issue - April 25: Pick up vehicle from dealer - May 3: Check engine light comes on again, flashing, and unable to accelerate past 45-50 mph. - May 4: Return to dealer and bring in vehicle for check engine/no acceleration issue; car is still at dealer as of May 25

The contact owns a 2019 Hyundai Tucson. The contact stated that while his wife was driving at low speeds, pulling into a parking spot on an incline, the vehicle accelerated and failed to stop. Then the vehicle traveled through several 15-gallon pots with trees, a patio, elliptical machines, and a wooden fence. The driver veered to the left, went down a mountain approximately 30 feet, continued down the hill, and crashed into a pine tree where it came to a halt. The occupant in the front passenger seat sustained a concussion. The driver sustained injuries to her lip and medical attention was provided. There were no warning lights illuminated. The vehicle was towed to the police station. A police report was filed. There was no reported fire. The driver's side front and passenger side front air bags were deployed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, who provided claim number 21135585, and had the vehicle inspected but indicated the brake pedal had not been depressed but no additional assistance was provided. The failure mileage was approximately 27,000.