2018 Hyundai Tucson

Approximately one month ago I had a high pressure fuel pump installed in my 2018 Hyundai Tucson. While driving on the highway, about ten minutes from home, my car suddenly burst into flames. There were no warning lights in the cockpit. There was no smoke in the cabin. Another motorist flagged me down. I got out of the vehicle just in time for it to become fully engulfed in flame. It burned down on the highway. Police and fire responded. Insurance is investigating. If I was inside the vehicle, I would have certainly died.

The oil consumption issue has begun. At about 75k miles, my 2018 Hyundai Tucson 1.6L Turbo is burning oil at an insane rate. And there is no indicator of it occurring (no codes or anything on the dash) until it's too late. Hyundai is now WELL KNOWN, and aware, for this problem and it is a catastrophic safety issue because of the possibility of the engine seizing and disabling the vehicle. It isn't negligence on the consumers part either, especially when timely and consistent oil changes are being done. *NOTE* My vehicle has had the transmission (6 speed dual clutch) replaced at around 30k miles and is having the same issue again (at 75k miles). So first the transmission and now the engine!

I bought this car 6 months ago. I did not know it had a recall on the engine. The engine just died a week ago. I brought it to hyundai and the confirmed it was a recall and go ahold of corporate. Corporate is refusing to fix the recall because they said "I should have brought it in at the original recall in 2020." I did not own the car there and I was not aware of the recall at all. [XXX] is my husband he is the other owner of the car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have experienced two near-fatal incidents involving a sudden, uncommanded loss of motive power while traveling at highway speeds (approx. 70 MPH). On February 11, 2026, the vehicle entered "Limp Home Mode" without warning, dropping speed to 60 MPH and 2000 RPM in heavy traffic. This caused an immediate and dangerous speed differential, nearly resulting in a high-speed rear-end collision. Simultaneously, the AC system disabled, indicating a severe engine protection event. Manufacturer Negligence: The vehicle was taken to Courtesy Hyundai of Tampa twice for this issue (Code P0087). They performed a "Knock Sensor" replacement and cleared data points, assuring me the vehicle was safe. The failure recurred immediately. I subsequently took the vehicle to Brandon Hyundai on February 13, 2026. Despite my reports of near-fatal highway failures, Brandon Hyundai was instructed by Hyundai Corporate to merely repeat the "Knock Sensor" replacement—a repair that had already failed to resolve the dangerous condition. Critical Safety Admission: On 02/23/2026, Brandon Hyundai Service Advisor Abel Gomez explicitly admitted that this repair is "not a fix, it is a temporary thing until it shows again," yet stated they must follow Corporate’s directive to release the car. Requested Action: Hyundai is knowingly releasing a vehicle with a recurring, life-threatening defect (P0087/Sudden Power Loss) by performing "band-aid" sensor swaps instead of addressing the high-pressure fuel system or internal engine failure. This practice is a direct violation of the Safety Act. I request an immediate investigation into Hyundai’s refusal to perform permanent repairs on GDI engines displaying these catastrophic failure codes.

I am writing this letter to formally document a series of catastrophic safety failures and gross negligence regarding my 2018 Hyundai Tucson. On two separate occasions, including as recently as Wednesday, February 11, 2026, I narrowly escaped a fatal high-speed collision because this vehicle entered "Engine Protection Mode" while traveling at highway speeds. Incident Timeline: Previous Service: I have visited Courtesy Hyundai of Tampa twice for engine-related symptoms and code P0087. They replaced the knock sensor and assured me the vehicle was safe. Safety Incident (Feb 11, 2026): While driving on the highway, the vehicle suddenly lost power, dropping to 60mph and 2000 RPM (Limp Mode) in heavy traffic. This sudden deceleration nearly caused a high-speed rear-end collision. Current Status: The vehicle is currently at Brandon Hyundai (as of Feb 13, 2026). I have been told a review will take 3-5 business days, leaving me without safe transportation or a loaner vehicle. Negligence and Liability: Courtesy Hyundai of Tampa was aware of the recurring P0087 code and engine performance issues. By clearing codes or replacing minor sensors (knock sensor) without addressing the underlying high-pressure fuel or internal engine failure, they released a dangerous, defective product onto the road. This vehicle is clearly covered under the Theta II GDI Engine Settlement and Service Campaign 966. The local dealerships are willfully avoiding a necessary engine replacement to save on internal costs, despite knowing the vehicle is prone to sudden failure. Demand for Action: Immediate Loaner Vehicle: I require a safe rental/loaner vehicle immediately, paid for by Hyundai, while my car is being inspected. Full Engine Replacement: I am demanding a full engine replacement as previously indicated by technicians should the light return. Expedited Review: I am extremely unsatisfied to be told again I have to wait "3-5 business days" for a safety-critical evaluation of a vehicle that has alre

My 2018 Hyundai Tucson experienced sudden catastrophic engine failure when a connecting rod threw while driving. The engine burned through its oil and the vehicle became inoperable. Hyundai denied warranty coverage for this engine failure because I had not completed the 2021 KSDS (Knock Sensor Detection System) recall. I was never notified of this recall. The KSDS recall is a software update intended to detect engine knock. It does not prevent mechanical engine failure. Denying warranty coverage due to a software update that I was unaware of raises safety concerns, as engine failure can occur suddenly while driving and creates risk of crash or injury. This appears related to known engine issues in Hyundai vehicles. I am concerned this is a broader safety defect affecting other consumers.

While driving on a public road, the vehicle experienced multiple simultaneous, dangerous malfunctions: Dashboard Warnings: All lights illuminated, including engine (flashing), ABS, traction control, airbag, TPMS, and parking brake, which stayed on though disengaged. Engine & Transmission: Tachometer fluctuated wildly in park; engine revved without accelerator input. Shifting to drive/reverse caused unexpected “kicks.” Vehicle sometimes failed to move when pressing gas, requiring engine restart. Driving Issues: Speedometer read 0 or jumped inconsistently. RPM continued erratically while maintaining speed without accelerator. Steering became extremely difficult. I immediately determined the vehicle was unsafe to drive and returned home with it, which was only a couple miles away. Follow-Up: Hyundai advised dealership diagnosis; they suggested a backup camera module will resolve the issues I experienced in entirety, but also in the same email stated that they could not guarantee it would resolve all of the issues I experienced. This is the second major engine/powertrain failure: first approximately ~70,000 miles (full engine replacement), current approximately ~95,000 miles (approximately ~25,000 miles post-replacement). Recurrence indicates a serious, unresolved safety defect. I am deeply concerned for passenger safety, including children. Other owners report similar issues; the attorney general’s office advised reporting to NHTSA. Summary of Safety Risks: sudden loss of control/power, erratic acceleration, dashboard failures, steering resistance, unpredictable handling, recurrence of major defect. I am submitting this report to NHTSA to request investigation of these recurring defects. I do have video documentation of all of this, as well as ALL written communication with Hyundai National Consumer Affairs and the dealership. I am having a hard time uploading them because of the file limits. Please let me know if any of this will be helpful to you.

Purchased 9/5/25 at 76,280 and oil change light shown by 10/1/25 when i received an oil change at Valvoline and was told of my engine issues at 77,733 miles. Car then looked at by Elizabeth Auto Sales [XXX] and confirmed oil consumption at no fault of my own and metal shavings in oil. Car then towed to #1 Cochran Hyundai Monroeville [XXX] and looked at by Dale. Oil change and oil consumption test started and confirmed of burning more than 1 qt per 1k miles. 2/4/2026 engine test cleaning requested and denied. Car stalls at random times can possible cause an accident. yes the problem was produced to the dealership purchased from which was Kenny Ross Subaru Irwin pa 15642. Yes the problem was confirmed by Hyundai on 11/7/25. Only warning was the oil change light flashing which forced me to get an oil change less than a month of purchasing on 10/1/25 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2018 Hyundai Tucson experienced repeated no-start conditions. The vehicle was initially diagnosed by Randy Wise Hyundai in Flint, Michigan, and I paid approximately $776 for tune-up services that did not resolve the issue. Shortly afterward, the vehicle continued to fail to start. The dealership later determined the starter had failed and provided an estimate of approximately $985 for replacement. Hyundai Motor America denied goodwill assistance and reimbursement for the prior misdiagnosed repair and stated the starter replacement is customer-pay. The vehicle’s inability to start caused loss of reliable transportation and safety concerns due to being stranded. I am submitting this complaint to document starter failure and potential diagnostic issues affecting vehicle safety.