2016 Hyundai Tucson

The contact owns a 2016 Hyundai Tucson. The contact stated that the vehicle would not start. The vehicle was towed to an independent mechanic who diagnosed that the starter had failed and needed to be replaced. The starter was replaced. The independent mechanic also informed the contact that the brake pedal needed to be replaced, and the rear trailing arm was corroded and could fracture while driving. There were no warning lights illuminated. The independent mechanic stated that the suspension front spring and coil spring could damage the tire overtime. The contact became aware that the VIN was included in NHTSA Campaign Number: 20V543000 (Service Brakes, Hydraulic). The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 37,861.

3 safety concerns with the vehicle- 1) - the front passenger side door will not open from time to time when unlocked- you need to crank on the out side and inside handle at times to get the door to open. This is a concern if I were to ever get into an accident. The locking mechanism has had to be repaired on both rear doors for the same issue- potentially keeping a passenger from exiting the vehicle in the case of an emergency. 2) the car jerks when accelerating from a complete stop every single time you drive - and you have to put your foot way down (like slamming down) on the gas pedal in order to get up to the right speed… (I have never had to do this in the other 4 vehicles we own - only in the Hyundai) 3) oil consumption concern. The car is using way too much oil then it should. I change the oil every 5000 miles and it is going into Hyundai 2/4/2022 in West Allis, WI for an oil change - (and to get the passenger door fixed) I had to add oil on 2/2/2022 because the oil level warning light came on - and it was almost empty. I’ll be requesting an oil consumption test. This should be covered by Hyundai due to this being a safety concern with the engine. This has been the worst vehicle e have ever owned. I have 3 daughters that drive this vehicle and it scares me thinking that if one were to ever get into an accident that they or one of their friends would be seriously injured - for either A- not being able to get out of the vehicle or B- the engine starting on fire due to the oil consumption problem.

The car vibrates, shakes, when stopped; hesitates, shakes, vibrates on accelerating from stopping, in traffic at stoplights. Incident becomes unsafe in traffic, etc. Reported to Dealer (Horne Hyundai, Mesa, AZ, 85120) and took car in for troubleshooting, diagnostics, or repair(s); twice, 1 st on Jan. 19, 2022, Dealer duplicated the same problem; Dealer technician performed 7 Type Judder Test, Vehicle Failed. Performed Transmission (TCU) update, Vehicle Passed, performed test drive, vehicle passed. Dealer acknowledged the same issue with vehicle; however reported to customer that it passed the Judder Test. Vehicle released to customer, no further testing or logic improvement. Customer drove vehicle home and incident occured again, less than 24 hrs from Dealer troubleshooting the incident. Customer returned vehicle to Dealer on Jan. 31, 2022; with the same issue; vibrating, hesitating, when stopping, and accelerating at stop lights, etc. Safety Issue in traffic. Dealer acknowledged the same issue again. Dealer technician again performed 7 Type Judder test. Judder detected. Performed Dual Clutch Transmission Detection and TCU Software updates, proceeded to test for Judder, Vehicle Passed. Returned vehicle to customer. Customer conferred with Dealer Service Manager about the vehicle issues, and was unable to resolve any further testing or next logical repair issues. Dealer suggested the customer contact the Manufacturer for further issues; unable to satisfy customer complaints of this issue and documented issues with previous recall of 41,000 Hyundai Tucson DCT issues and problems. Dealer could not reconcile with customer on why this VIN number was not included in the recall #149 for Hyundai Tucson vehicles; suggesting we report to NHTSA for the safety issue. This DCT issue is recurring with recurring "reprogramming by the Dealer(s) never really repairing anything, just software updates. Invoices 358494 (2) Horne Hyundai, Apache Junction, AZ 85120

1. January 7, 2022 my vehicle began to lose engine power, as I began to try and find a place to pull over safely, the car stalled. It would not immediately start again for several hours. It had to be pushed out of the way. The engine failed due to wear of connecting rod bearings with no previous indication of engine issues. 2. Due to the sudden stall and having to push the vehicle to a safe location, myself and passengers could have easily been hit by another vehicle. 3. A dealership has confirmed the failed rod bearings. 4. The vehicle's engine has been inspected and photos taken by the dealership and submitted to Hyundai corporate. 5. It was not until the car stalled that the oil light illuminated. When I started the car back up several hours later, all lights were gone and no error codes were present. There was no previous warning lights before this incident.

The contact owns a 2016 Hyundai Tucson. The contact stated that soon after purchasing the vehicle, the vehicle would stall upon depression of the accelerator pedal as the RPM's would loudly rev. The contact took the vehicle back to the independent used auto shop where the vehicle was purchased and was informed that they would not service the transmission or offer any additional assistance. Upon investigation, the contact discovered NHTSA Campaign Number: 16V628000 (Power Train, Electrical System) which he linked to the failure. The manufacturer had been notified of the failure but provided no assistance. The contact called a local dealer and made an appointment for service. The vehicle was not repaired. The failure mileage was approximately 92,000.

The engine has Rod Bearing failure. The engine is a Gamma GDI 1.6 L engine- the same engine that was recalled from the Veloster, for this problem but the Tuscon was not included in the recall. Hyundai has stated they recalled the Gamma GDI 1.6 L due to metal shavings being left in the engine during production that overtime created wear on the rod bearings leading to failure and engine failure. (Which is exactly what is wrong with my vehicle) Hyundai has said they will not fix my engine, and that it is out of warranty. It has been inspected by 2 local mechanics who have confirmed the diagnosis, I have called Hyundai corporate and the local Hyundai dealerships who have provided no help and requested $250 to even look at my vehicle. The oil light came on right before the engine started knocking and it was taken directly to a mechanic. I purchased this vehicle 1 year ago from a reputable used car dealership who will not help me either, the vehicle is now out of warranty, and I still owe $17,000 on the loan. A new engine is $10,000. Hyundai needs to step up and fix this issue.

Failed intake valve/compression valve. It is currently at the dealer I bought it from. I was driving in traffic and it had no power at all. I was almost rear ended several times trying to coast off the road. The dealer took the engine apart and put it back together 3 times and informed me that it will need a new motor. There were no warnings at all before this happened. The dealer nor Hyundia has tried to work with me on the cost. The purchase price was $14,000 and they want to charge $8000 for a new motor. I am still paying for the SUV that isnt running.

All of the window regulators have gone out now 3 within a few months, don't know how there isn't a recall yet. Seems there is a lot of complaints in forums. All within 3 months definitely sounds sus. Most think it's due to the plastic wheel the regulator spins on. The heat melts it over time. I only have 49,000 miles on the car at this time. They want 2,300 to fix it.'

The contact's son owns a 2016 Hyundai Tucson. The contact stated that while his son was driving at an undisclosed speed, the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was towed to the dealer, and the dealer replaced the spark plugs; however, the failure recurred. The vehicle was then towed to Wiesner Hyundai (1645 Interstate 45 N, Conroe, TX 77304) and diagnosed with engine failure, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact to take the vehicle to a dealer. The failure mileage was 107,727.