2016 Hyundai Tucson

On Sunday, February 26, 2023, as I was en route to my home in Liberty Hill, Texas, I heard a noise from what seemed to be under the hood. The noise sounded somewhat like a card in bike spokes. No warning lights were lit. When I arrived home, I had a neighbor listen to the noise. His opinion was that it sounded like the rods & to take it to a mechanic. I had a friend take me to the nearest garage/mechanic on Monday to make an appointment. I took my car to Cross Tech Automotive at 8 am on February 28. The 5 miles to Cross Tech was the only time I drove the car after the initial noise on Sunday 2/26/2023. The technician remarked that it was crazy that no warning lights were on, given the noise made by my car. After the car was examined, I was told that my car had no oil in it. I had routine oil changes done throughout the time I owned the car since late 2015. In fact, I’d asked the mechanics to do an oil change while the car was in their facility. There were never any oil on my driveway to alert me to a problem. There had been no sign of any problem until the noise I heard 2 days prior. And never a warning light of any kind. I was given an estimate of $12,000.00 to replace the motor, including labor. Because it didn’t make sense to spend $12,000 on a vehicle that was likely worth $15,000 prior to this problem, it was necessary to buy a different car. After doing an internet search, I discovered that excess oil consumption appears to be a problem with 2016 Hyundai Tucsons, among other Hyundais and Kias. I was never made aware of any issues by Hyundai Motor Company. The technician who diagnosed the problem wrote a brief description of what he found. I can provide this description. The invoice was for the diagnosis not repairs of any kind.

Engine light came on Feb 26th car started shaking got it towed to the dealership morning of Feb 27th Was told: Foiled oil returning ring caused oil consumption, burning oil overheated valves and caused cylinder wall damage and 4 valves to burn holes in them leading to low engine compression and loss of power. Engine needs to be replaced to fully correct the issue. Hyundai is refusing to cover the cost because I am 2nd owner, even though my car has under 100,000 miles on it.

The vehicle engine stopped working while on the interstate. The oil, battery and engine lights all came on with no warning. I was able to safely pull aside in order to avoid an accident. The vehicle was towed to the dealership where it was diagnosed to be an engine block failure. After doing my research I learned that Hyundai had a Theta Engine Settlement from 2021 however my 2016 Hyundai Tucson was not listed in the settlement. The years that were affected skipped 2016 and 2017. Online I have found many 2016 owners with the same issue. The vehicles built in 2016 and 2017 also needed to be reviewed for faulty engine blocks. This is a safety hazard. My vehicle has been in the dealership awaiting a new engine for over 7 weeks. Hyundai says that part is on backorder. There has been so many vehicles in need of a new engine due to the faulty block that the manufacturer can't keep up. And we are stuck paying car rental fees.

My car is currently around 126,000 miles. I got a tune up last year. About a week ago the car started to jumping and driving very slowly while I was on the highway. The check engine light started flashing so I pulled over. After a few minutes I attempted to drive up and the car made it. I spoke with my mechanic and scheduled to bring it into him after getting the check engine light code read. The codes were related to a misfire on spark plug 2 and 4. I then had those replaced. When picking up the car, my mechanic let me know that the engine was producing metal shaving and they were getting on the spark plugs which was causing the issues to keep according. He let me know I would probably need a new motor. After doing some research I found Hyundai Tucson around my same year have a similar issue with the motor going out very early in the cars life. I’m not sure why they weren’t already included but I believe the 2016 Hyundai Tucson need to be investigated for the issues as well. The car is only worth $7,000 with a working motor so it doesn’t make sense to buy a new engine but I still own payment on this vehicle and it’s completely unfair for Hyundai to vehicles like this and not take accountability. I’m planning to get the code read on the car again and actually write down the number so I can reference it here for you information.

I am referring to two notices; see attached. Inability to accelerate from a Stop and Rough idle in drive. The dealership, DeMontrond Hyundai Service Center will not repair as a recall. Please advise. Thank you, [XXX] [XXX] [XXX]. Due to this problem, the car is hesitant to accelerate which causes problems INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The Hyundai engine is defective and consumes oil at a rate of 5 quarts every 3,000 miles. It ran completely out of oil and left me stranded on the highway in rush hour traffic 3 hours from home. Several people were put at risk! No warning lights; no check engine and no oil light until the car stalled completely. I was able to add oil and get the car in limp mode to the dealership where they ran oil consumption tests, and it failed due to being 106k miles. The car was returned to me and I was told to watch the oil. Weeks later the car broke down again in the middle of the road. The spark plug tips were burnt completely off and there was a dime sized hole in a valve. Multiple mechanics outside of Hyundai agree that both the plugs and the valve damage are a direct result of the defective engine. Again, Hyundai has denied all claims and refuses to acknowledge any wrongdoing on their part, despite the amount of claims, lawsuits and upset customers stacked against them.

There was a previous recall with some of these vehicles where car seems to have acceleration problem after being at stop and the vehicle has difficulty accelerating and shifting gears. This has happened while in the middle of traffic and driving which could have caused an accident. Not sure if it is something with the transmission or what the issue is. The vehicle has been taken twice to Hyundai Service centers and they cannot seem to find a problem but yet it still exists and is a safety hazard when suddenly the car stops accelerating after a stop. This seems to happen randomly and more often now. This was a previous recall for other same make, model and year vehicles but somehow ours was not included and I feel it is potentially having the same or similar issue. The vehicle is available for inspection. All the check engine and lights come on when the vehicle is turned off and then eventually turn off.

My vehicle is burning excessive amounts of oil and no leaks can be found. Almost one quart every 750 to 1,000 miles. The turbo went bad recently and had to be replaced at a cost of $1,400 which, I'm told, is possibly due to the oil consumption problem. All services have been done at Hyundai dealership every 3,000 - 5,000 miles. I travel the interstate every day and am worried about engine failure in rush-hour traffic. Dealership indicates the only thing they can do is replace engine at a cost of at least $12,000!!

On December 27, 2022 I was driving on the highway (Interstate 64 in Illinois westbound exit 16) and my car's engine failed at around noon. It was working fine that morning. The car started giving a rattling sound and wasn't speeding up and the "low oil pressure" light came on. I got off the highway and as I was turning into a Valvoline the car completely stopped. It has been at a Hyundai dealership in St. Louis for the last month and a half and they do not feel this is something they are responsible for.