DT*: THE CONTACT STATED WHILE DRIVING 15 MPH SHIFTING FROM FIRST TO SECOND GEAR THE CLUTCH FAILED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THEY REPLACED THE CLUTCH HOWEVER THE PROBLEM STILL EXISTS. THE MANUFACTURER WAS ALERTED. UPDATED 3/17/2006 - WHEN THE FIRST REPAIR WAS MADE THE INCORRECT CLUTCH WAS INSTAL…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 15 MPH SHIFTING FROM FIRST TO SECOND GEAR THE CLUTCH FAILED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THEY REPLACED THE CLUTCH HOWEVER THE PROBLEM STILL EXISTS. THE MANUFACTURER WAS ALERTED. UPDATED 3/17/2006 - WHEN THE FIRST REPAIR WAS MADE THE INCORRECT CLUTCH WAS INSTALLED IN THE CONSUMER'S VEHICLE BECAUSE THE ONLINE TSB WAS NOT UPDATED TO REFLECT THE NEW PART NUMBER. *NM
NHTSA ODI #10151630
Mileage unknown · Mar 2, 2006
Power Train
I AM HAVING TO REPLACE THE CLUTCH AND FLYWHEEL ON MY 2003 HYUNDAI TIBURON FOR THE 2ND TIME IN UNDER 3 YEARS. THE DEALER WILL NOT COVER THIS UNDER WARRANTY. UPON RESEARCHING THE NUMBER OF COMPLAINTS ABOUT THIS PROBLEM, THERE HAS GOT TO BE SOMETHING THAT CAN BE DONE. *NM
NHTSA ODI #10151624
70,000 miles · Feb 28, 2006
Power Train
1. EVENTS LEADING UP: THE CAR WAS DRIVEN 2. CLUTCH FAILURE. @ 70K MILES, THE CLUTCH FAILS. 3. NEED TO REPLACE THE CLUTCH ASSEMBLY. *NM
NHTSA ODI #10151431
6,000 miles · Feb 26, 2006
Power Train
NO EVENTS LEAD UP TO THE FAILURES. ALL FAILURES HAVE HAPPENED IN RUSH HOUR TRAFFIC AND HAS LEFT OWNER STRANDED ON THE INTERSTATE. DEALER REFUSED TO COVER 3 OF THE REPAIRS WHICH, COST US 2,000 EACH FAILURE. NOTHING HAS BEEN DONE TO CORRECT THE FAILURE. THE OLD PARTS ARE AVAILABLE IF NEEDED. THIS VEHICLE HAS BEEN A RECURRING …
Read full complaint
NO EVENTS LEAD UP TO THE FAILURES. ALL FAILURES HAVE HAPPENED IN RUSH HOUR TRAFFIC AND HAS LEFT OWNER STRANDED ON THE INTERSTATE. DEALER REFUSED TO COVER 3 OF THE REPAIRS WHICH, COST US 2,000 EACH FAILURE. NOTHING HAS BEEN DONE TO CORRECT THE FAILURE. THE OLD PARTS ARE AVAILABLE IF NEEDED. THIS VEHICLE HAS BEEN A RECURRING NIGHTMARE AND IS A MONEY PIT. *JB
NHTSA ODI #10151260
35,000 miles · Feb 24, 2006
Power Train
MY CLUTCH WENT OUT ON MY 2003 HYUNDAI TIBURON WITHOUT WARNING. MY CAR HAS 35000 MILES ON IT. SOMETHING HAS BROKEN OFF AND TAKEN OUT THE TRANSMISSION. I'VE BEEN READING MANY IDENTICAL CASE SCENARIOS FROM OTHER HYUNDAI TIB OWNERS. HYUNDAI WILL NOT COVER UNDER WARRANTY. THEY BLAME IT ON CLUTCH MISSUSE AND/OR DRIVING HABITS. *NM
NHTSA ODI #10151131
22,500 miles · Feb 22, 2006
Power Train
1. BOUGHT A 2003 HYUNDAI TIBURON V6, 6-SPD (MANUAL TRANSMISSION) -- EVENT: NO EVENT. SIMPLY DROVE THE CAR AS NORMAL. 2. LESS THEN 23,000 MILES MY CLUTCH GAVE OUT. 3. I HAD TO REPLACE THE CLUTCH ASSEMBLY, FLYWHEEL AND THROWOUT BEARING. PARTS AND LABOR COST ME OVER $1500 IN REPAIRS. LESS THE 23K MILES AND I HAD TO PAY OVE…
Read full complaint
1. BOUGHT A 2003 HYUNDAI TIBURON V6, 6-SPD (MANUAL TRANSMISSION) -- EVENT: NO EVENT. SIMPLY DROVE THE CAR AS NORMAL. 2. LESS THEN 23,000 MILES MY CLUTCH GAVE OUT. 3. I HAD TO REPLACE THE CLUTCH ASSEMBLY, FLYWHEEL AND THROWOUT BEARING. PARTS AND LABOR COST ME OVER $1500 IN REPAIRS. LESS THE 23K MILES AND I HAD TO PAY OVER $1500 FOR TRANSMISSION REPAIR. THIS IS A COMMON PROBLEM THAT OWNERS OF THIS YEAR, MAKE AND MODEL ARE EXPERIENCING. YET, HYUNDAI REFUSES TO DO ANYTHING ABOUT IT EXCEPT FORCE THEIR CUSTOMERS TO COMMIT TO A VERY EXPENSIVE CAR REPAIR EARLY IN THE LIFE OF THE VEHICLE. NO CAR UNDER NORMAL WEAR AND TEAR SHOULD HAVE AS MUCH WORK DONE AS MYSELF AND MANY OTHERS HAVE HAD TO DEAL WITH. THIS NEEDS TO BE SET UP AS A RECALL BY HYUNDAI AND THOSE OF US HAMMERED BY THIS SHOULD BE REIMBURSED. *NM
NHTSA ODI #10150868
32,000 miles · Feb 21, 2006
Power Train
DT*: THE CONTACT STATED WHILE SHIFTING FROM FOURTH TO FIFTH GEAR AT 55 MPH, THE CLUTCH MADE A GRINDING NOISE AND MALFUNCTIONED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. UPON INSPECTION, THE DEALERSHIP REPLACED THE TRANSMISSION AND THE CLUTCH. ALTHOUGH THE PROBLEM REOCCURRED, NO ADDITIONAL REPAIRS WERE MADE. T…
Read full complaint
DT*: THE CONTACT STATED WHILE SHIFTING FROM FOURTH TO FIFTH GEAR AT 55 MPH, THE CLUTCH MADE A GRINDING NOISE AND MALFUNCTIONED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. UPON INSPECTION, THE DEALERSHIP REPLACED THE TRANSMISSION AND THE CLUTCH. ALTHOUGH THE PROBLEM REOCCURRED, NO ADDITIONAL REPAIRS WERE MADE. THE MANUFACTURER WAS ALERTED.
NHTSA ODI #10150730
41,150 miles · Feb 17, 2006
Power Train
CLUTCH ON MY '03 TIBURON BURNT OUT AT 40K MILES. *JB
NHTSA ODI #10150486
37,000 miles · Feb 16, 2006
Power Train
MY CLUTCH IS REALLY SLIPPING BAD AND NEEDS TO BE REPLACED. I HAVE HEARD MANY PEOPLE WITH THIS COMPLAINT. I THINK THE ISSUE WITH THE HYUNDAI TIBURON CLUTCHES NEEDS TO BE LOOKED AT.*JB
NHTSA ODI #10150450
47,853 miles · Jan 19, 2006
Power Train
I'M JOINING THE 1,000 OR SO PEOPLE ON THIS SITE ALONE WHO OWN A 2003 HYUNDAI TIBURON GT V6 6 SPEED. MY CLUTCH WENT OUT AT 47,000 MILES AND IT'S GOING TO THE DEALER NEXT WEEK FOR WHAT I'M SURE WILL BE THEIR ATTEMPT TO SCREW ME OUT OF $2,000. I HAVE TWO QUESTIONS: HOW MANY OF THESE HAVE TO FAIL BEFORE THE GOV'T DOES SOMETHING? ALL…
Read full complaint
I'M JOINING THE 1,000 OR SO PEOPLE ON THIS SITE ALONE WHO OWN A 2003 HYUNDAI TIBURON GT V6 6 SPEED. MY CLUTCH WENT OUT AT 47,000 MILES AND IT'S GOING TO THE DEALER NEXT WEEK FOR WHAT I'M SURE WILL BE THEIR ATTEMPT TO SCREW ME OUT OF $2,000. I HAVE TWO QUESTIONS: HOW MANY OF THESE HAVE TO FAIL BEFORE THE GOV'T DOES SOMETHING? ALL OF THEM? SECOND QUESTION: WHERE DOES THE CEO OF HYUNDAI LIVE SO I CAN STICK HIS JUNK FLYWHEEL AND CLUTCH SOMEWHERE UNPLEASANT? *JB
HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT USED DURING THE WINTER MONTHS IN THESE JURISDICTIONS MAY RESULT IN INTERNAL CORROSION AND THINNING OF THE STEEL IN THE FRONT LOWER CONTROL ARMS. THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM'S UPPER AND LOWER PANELS BECOME PERFORATED. A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.
Consequence & remedy
Consequence: THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS INCORPORATING ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT LOWER CONTROL ARMS DO NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE FRONT LOWER CONTROL ARMS AND WILL TREAT THE FRONT LOWER CONTROL ARMS WITH RUST-PROOFING MATERIALS TO ARREST THE INTERNAL CORROSION PROCESS. THESE PROCEDURES WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 17, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
Consequence & remedy
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
Consequence & remedy
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.
Consequence & remedy
Consequence: CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.
ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT PASSENGER AIR BAG IS MOUNTED BENEATH THE RIGHT PORTION OF THE INSTRUMENT PANEL'S PADDED SURFACE. TEAR LINES ARE FORMED INTO THE UNDERSIDE OF THE INSTRUMENT PANEL'S PADDED SURFACE DURING THE PRODUCTION PROCESS OF THE INSTRUMENT PANEL TOP PAD. THESE TEAR LINES ALLOW A PORTION OF THE INSTRUMENT PANEL SURFACE TO FOLD UPWARD IF THE PASSENGER AIR BAG DEPLOYS.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE AIR BAG MAY NOT DEPLOY PROPERLY, POSSIBLY RESULTING IN SERIOUS INJURY TO THE RIGHT FRONT PASSENGER.
Remedy: HYUNDAI WILL REPLACE THE INSTRUMENT PANEL. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI OF AMERICA AT 1-800-633-5151, OR IF THE VEHICLE IS LOCATED IN PUERTO RICO, HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
ON CERTAIN SPORT UTILITY VEHICLES, THE DRIVER SEAT BELT BUCKLE WIRING COULD BE DAMAGED BY INTERFERENCE WITH THE DRIVER SEAT CUSHION HEIGHT ADJUSTER MECHANISM. DAMAGED DRIVER SEAT BELT BUCKLE WIRING COULD CAUSE THE SEAT BELT WARNING LAMP OR THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WIRING LAMP TO ILLUMINATE. IT COULD ALSO CAUSE THE AIR BAG FUSE (CAVITY NUMBER 5) TO OPEN, PREVENTING AIR BAG DEPLOYMENT. DAMAGED DRIVER SEAT BELT BUCKLE WIRING COULD CAUSE THE SEAT BELT WARNING LAMP OR THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WIRING LAMP TO ILLUMINATE. IT COULD ALSO CAUSE THE AIR BAG FUSE (CAVITY NUMBER 5) TO OPEN, PREVENTING AIR BAG DEPLOYMENT.
Consequence & remedy
Consequence: NONDEPLOYMENT OF AN SRS AIR BAG IN A CRASH WHERE AIR BAG DEPLOYMENT IS WARRANTED COULD INCREASE THE RISK OR SEVERITY OF INJURY IN A CRASH.
Remedy: DEALERS WILL INSTALL A NEW DRIVER SEAT BELT BUCKLE, IF NECESSARY, AND WILL PLACE A PROTECTIVE COVER OVER THE DRIVER SEAT BELT BUCKLE WIRING TO PREVENT DAMAGE FROM OCCURRING. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2003. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-899-981-0188.
ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKETS. ON VEHICLES THAT ARE NOT EQUIPPED WITH ABS, THE REAR BRAKE TUBES MAY CONTACT ONLY THE LEFT MOUNTING BRACKET. CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING BRACKETS COULD CAUSE WEAR AND CORROSION THAT COULD RESULT IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
ON CERTAIN PASSENGER VEHICLES, THE DRIVER SEAT BELT BUCKLE WIRING COULD BE DAMAGED BY INTERFERENCE WITH THE DRIVER SEAT CUSHION HEIGHT ADJUSTER MECHANISM.
Consequence & remedy
Consequence: DAMAGED DRIVER SEAT BELT BUCKLE WIRING COULD CAUSE THE SEAT BELT WARNING LAMP OR THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WIRING LAMP TO ILLUMINATE. IT COULD ALSO CAUSE THE AIR BAG FUSE (CAVITY NUMBER 5) TO OPEN, PREVENTING AIR BAG DEPLOYMENT. NONDEPLOYMENT OF AN SRS AIR BAG IN A CRASH WHERE AIR BAG DEPLOYMENT IS WARRANTED COULD INCREASE THE RISK OR SEVERITY OF INJURY IN A CRASH.
Remedy: DEALERS WILL INSTALL A NEW DRIVER SEAT BELT BUCKLE, IF NECESSARY, AND WILL PLACE A PROTECTIVE COVER OVER THE DRIVER SEAT BELT BUCKLE WIRING TO PREVENT DAMAGE FROM OCCURRING. OWNER NOTIFICATION BEGAN ON MARCH 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
ON CERTAIN PASSENGER VEHICLES, THE LEFT LOWER INSTRUMENT PANEL BRACKET WAS NOT INSTALLED.
Consequence & remedy
Consequence: IF THIS BRACKET HAS NOT BEEN INSTALLED, THERE MAY BE AN INCREASED LIKELIHOOD OF INJURY OR INCREASED SEVERITY OF INJURY IN A FRONTAL CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES TO DETERMINE IF THE BRACKET HAS BEEN INSTALLED. IF THE BRACKET HAS NOT BEEN INSTALLED, THE DEALER WILL INSTALL THE LEFT LOWER INSTRUMENT PANEL BRACKET. OWNER NOTIFICATION BEGAN MARCH 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 Hyundai Tiburon Problems, Complaints & Recalls | Skip That Year
Illustration