EVER SINCE I HAVE PURCHASED THE CAR, THE LEFT TURN SIGNAL HAS STAYED ON, EVEN WHEN THE CAR IS OFF, AND THE KEY IS REMOVED. IT NEVER TURNS OFF. I'VE DONE RESEARCH, AND IT IS A FAULTY "BODY CONTROL MODULE", AND EVERYWHERE I TURN, PEOPLE ARE HAVING THIS PROBLEM. THE PART IS ANYWHERE ABOVE $600.00 TO REPLACE, AND SHOULDN'T JUST GO …
Read full complaint
EVER SINCE I HAVE PURCHASED THE CAR, THE LEFT TURN SIGNAL HAS STAYED ON, EVEN WHEN THE CAR IS OFF, AND THE KEY IS REMOVED. IT NEVER TURNS OFF. I'VE DONE RESEARCH, AND IT IS A FAULTY "BODY CONTROL MODULE", AND EVERYWHERE I TURN, PEOPLE ARE HAVING THIS PROBLEM. THE PART IS ANYWHERE ABOVE $600.00 TO REPLACE, AND SHOULDN'T JUST GO FAULTY ON THOUSANDS OF CARS, IT IS AN EXTREME SAFETY RISK. *TR
NHTSA ODI #10223101
72,000 miles · Oct 18, 2007
Exterior Lighting
ONE WEEK AFTER PURCHASING A USED 2003 HYUNDAI TIBURON I WAS PREPARING TO MAKE A RIGHT TURN AND PULLED THE TURN SIGNAL ON. AFTER EXITING THE TURN, TURN SIGNAL STAYED ON . FLASHER RELAY ATTACHED TO BCM FUSED NOT ALLOWING THE BULBS TO TURN OFF EVEN AFTER TURNING THE VEHICLE OFF. ONLY TEMPORARY FIX FOR PROBLEM IS TO REMOVE FUSE FR…
Read full complaint
ONE WEEK AFTER PURCHASING A USED 2003 HYUNDAI TIBURON I WAS PREPARING TO MAKE A RIGHT TURN AND PULLED THE TURN SIGNAL ON. AFTER EXITING THE TURN, TURN SIGNAL STAYED ON . FLASHER RELAY ATTACHED TO BCM FUSED NOT ALLOWING THE BULBS TO TURN OFF EVEN AFTER TURNING THE VEHICLE OFF. ONLY TEMPORARY FIX FOR PROBLEM IS TO REMOVE FUSE FROM CIRCUIT, IN-TURN DISABLING BOTH TURN SIGNALS AND HAZARD LIGHTS. PERMANENT FIX IS TO REPLACE BCM, FUSE PANEL, AND MAIN POWER JUNCTION ON VEHICLE, THIS COSTS NEAR $1000 TO REPAIR AND FOR THOSE THAT CAN'T AFFORD THAT AMOUNT ARE LEFT DRIVING WITHOUT TURN SIGNALS OR HAZARD LIGHTS CREATING A SAFETY HAZARD FOR THEMSELVES AND OTHERS ON THE ROAD AROUND THEM DUE TO THE FACT THAT THEY CANNOT INFORM OTHER DRIVERS OF LANE CHANGES OR TURNS. THIS MAY RESULT IN ACCIDENTS, TICKETS, OR FAILED SAFETY INSPECTIONS. I CONTACTED HYUNDAI AND THE REPRESENTATIVE I TALKED TO KNEW OF THE PROBLEM. AFTER RESEARCHING THIS ON THE INTERNET IT APPEARS TO BE A COMMON PROBLEM, THERE HAVE BEEN MANY POST ABOUT THIS ISSUE AND NONE HAVE HAD SOLID SOLUTIONS WITHOUT DISASSEMBLING THE COMPUTER AND REPLACING THE RELAY THAT IS SODERED TO THE MAIN COMPUTER BOARD. *TR
NHTSA ODI #10206256
44,000 miles · Aug 30, 2007
Air BagsExterior LightingLatches/locks/linkages
CLUTCH FAILED AT 44,000 MILES AFTER BUYING CAR USED. SERVICE DEPARTMENT WOULD NOT FIX , STATED IT WAS WEAR AND TEAR. COST $1500 TO FIX. AIRBAG LIGHT STAYS ON, PAST 65,000 SO SERVICE DEPARTMENT WONT FIX IT UNLESS I PAY FOR IT. HATCH BACK LATCH WONT WORK, $200 TO FIX THAT. HEADLIGHTS BURN OUT EVERY OTHER MONTH. BROUGHT CAR TO SER…
Read full complaint
CLUTCH FAILED AT 44,000 MILES AFTER BUYING CAR USED. SERVICE DEPARTMENT WOULD NOT FIX , STATED IT WAS WEAR AND TEAR. COST $1500 TO FIX. AIRBAG LIGHT STAYS ON, PAST 65,000 SO SERVICE DEPARTMENT WONT FIX IT UNLESS I PAY FOR IT. HATCH BACK LATCH WONT WORK, $200 TO FIX THAT. HEADLIGHTS BURN OUT EVERY OTHER MONTH. BROUGHT CAR TO SERVICE CENTER BECAUSE OF A NOISE IN THE FRONT OF CAR. SAID THEY COULDNT HEAR ANYTHING. 2000 MILES OVER MY WARRENTEE BROUGHT CAR BACK BECAUSE IT WAS GETTING WORSE, SAID IT WAS FRONT WHEEL ASSEMBLY AND WOULD COST $1000 TO FIX. DURING COLD WEATHER EMERGENCY BRAKE STICKS TOOK IT IN AND THEY COULDNT FIND ANYTHING WRONG, GO FIGURE. SEATS WONT LATCH SOMETIMES AFTER LETTING SOMEONE OUT FROM THE BACK. IS THERE A END TO THE PROBLEMS THAT I HAVE WITH THIS HYUNDAI.
NHTSA ODI #10201189
Mileage unknown · Sep 8, 2006
Exterior Lighting
REPETITIVE PROBLEM WITH HIGH BEAM HEADLIGHTS ACTIVATING WHEN THE SIGNAL LIGHTS ARE UTILIZED. APPEARS TO BE A SHORT IN THE SWITCH. *NM
HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT USED DURING THE WINTER MONTHS IN THESE JURISDICTIONS MAY RESULT IN INTERNAL CORROSION AND THINNING OF THE STEEL IN THE FRONT LOWER CONTROL ARMS. THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM'S UPPER AND LOWER PANELS BECOME PERFORATED. A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.
Consequence & remedy
Consequence: THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS INCORPORATING ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT LOWER CONTROL ARMS DO NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE FRONT LOWER CONTROL ARMS AND WILL TREAT THE FRONT LOWER CONTROL ARMS WITH RUST-PROOFING MATERIALS TO ARREST THE INTERNAL CORROSION PROCESS. THESE PROCEDURES WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 17, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
Consequence & remedy
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
Consequence & remedy
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.
Consequence & remedy
Consequence: CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.
ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT PASSENGER AIR BAG IS MOUNTED BENEATH THE RIGHT PORTION OF THE INSTRUMENT PANEL'S PADDED SURFACE. TEAR LINES ARE FORMED INTO THE UNDERSIDE OF THE INSTRUMENT PANEL'S PADDED SURFACE DURING THE PRODUCTION PROCESS OF THE INSTRUMENT PANEL TOP PAD. THESE TEAR LINES ALLOW A PORTION OF THE INSTRUMENT PANEL SURFACE TO FOLD UPWARD IF THE PASSENGER AIR BAG DEPLOYS.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE AIR BAG MAY NOT DEPLOY PROPERLY, POSSIBLY RESULTING IN SERIOUS INJURY TO THE RIGHT FRONT PASSENGER.
Remedy: HYUNDAI WILL REPLACE THE INSTRUMENT PANEL. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI OF AMERICA AT 1-800-633-5151, OR IF THE VEHICLE IS LOCATED IN PUERTO RICO, HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
ON CERTAIN SPORT UTILITY VEHICLES, THE DRIVER SEAT BELT BUCKLE WIRING COULD BE DAMAGED BY INTERFERENCE WITH THE DRIVER SEAT CUSHION HEIGHT ADJUSTER MECHANISM. DAMAGED DRIVER SEAT BELT BUCKLE WIRING COULD CAUSE THE SEAT BELT WARNING LAMP OR THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WIRING LAMP TO ILLUMINATE. IT COULD ALSO CAUSE THE AIR BAG FUSE (CAVITY NUMBER 5) TO OPEN, PREVENTING AIR BAG DEPLOYMENT. DAMAGED DRIVER SEAT BELT BUCKLE WIRING COULD CAUSE THE SEAT BELT WARNING LAMP OR THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WIRING LAMP TO ILLUMINATE. IT COULD ALSO CAUSE THE AIR BAG FUSE (CAVITY NUMBER 5) TO OPEN, PREVENTING AIR BAG DEPLOYMENT.
Consequence & remedy
Consequence: NONDEPLOYMENT OF AN SRS AIR BAG IN A CRASH WHERE AIR BAG DEPLOYMENT IS WARRANTED COULD INCREASE THE RISK OR SEVERITY OF INJURY IN A CRASH.
Remedy: DEALERS WILL INSTALL A NEW DRIVER SEAT BELT BUCKLE, IF NECESSARY, AND WILL PLACE A PROTECTIVE COVER OVER THE DRIVER SEAT BELT BUCKLE WIRING TO PREVENT DAMAGE FROM OCCURRING. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2003. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-899-981-0188.
ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKETS. ON VEHICLES THAT ARE NOT EQUIPPED WITH ABS, THE REAR BRAKE TUBES MAY CONTACT ONLY THE LEFT MOUNTING BRACKET. CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING BRACKETS COULD CAUSE WEAR AND CORROSION THAT COULD RESULT IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
ON CERTAIN PASSENGER VEHICLES, THE DRIVER SEAT BELT BUCKLE WIRING COULD BE DAMAGED BY INTERFERENCE WITH THE DRIVER SEAT CUSHION HEIGHT ADJUSTER MECHANISM.
Consequence & remedy
Consequence: DAMAGED DRIVER SEAT BELT BUCKLE WIRING COULD CAUSE THE SEAT BELT WARNING LAMP OR THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WIRING LAMP TO ILLUMINATE. IT COULD ALSO CAUSE THE AIR BAG FUSE (CAVITY NUMBER 5) TO OPEN, PREVENTING AIR BAG DEPLOYMENT. NONDEPLOYMENT OF AN SRS AIR BAG IN A CRASH WHERE AIR BAG DEPLOYMENT IS WARRANTED COULD INCREASE THE RISK OR SEVERITY OF INJURY IN A CRASH.
Remedy: DEALERS WILL INSTALL A NEW DRIVER SEAT BELT BUCKLE, IF NECESSARY, AND WILL PLACE A PROTECTIVE COVER OVER THE DRIVER SEAT BELT BUCKLE WIRING TO PREVENT DAMAGE FROM OCCURRING. OWNER NOTIFICATION BEGAN ON MARCH 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
ON CERTAIN PASSENGER VEHICLES, THE LEFT LOWER INSTRUMENT PANEL BRACKET WAS NOT INSTALLED.
Consequence & remedy
Consequence: IF THIS BRACKET HAS NOT BEEN INSTALLED, THERE MAY BE AN INCREASED LIKELIHOOD OF INJURY OR INCREASED SEVERITY OF INJURY IN A FRONTAL CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES TO DETERMINE IF THE BRACKET HAS BEEN INSTALLED. IF THE BRACKET HAS NOT BEEN INSTALLED, THE DEALER WILL INSTALL THE LEFT LOWER INSTRUMENT PANEL BRACKET. OWNER NOTIFICATION BEGAN MARCH 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 Hyundai Tiburon Problems, Complaints & Recalls | Skip That Year
Illustration