Electrical SystemEngine And Engine CoolingPower Train
AUTOMATIC TRANSMISSION; WHEN APPLING GEAR IN REVERSE THERE IS A HARD BANGING NOISE COMING FROM TRANSMISSION. TRANSMISSION HAS BEEN REPLACED THREE TIMES. DEALERSHIP WAS AWARE OF PROBLEM.*AK CHECK ENGINE LIGHT ILLUMINATED, DEALER REPLACED FAULTY O2 SENSOR. FAULTY BATTERY CAUSING VEHICLE TO CRANK SLOW. DRIVER DOOR WINDOW MO…
Read full complaint
AUTOMATIC TRANSMISSION; WHEN APPLING GEAR IN REVERSE THERE IS A HARD BANGING NOISE COMING FROM TRANSMISSION. TRANSMISSION HAS BEEN REPLACED THREE TIMES. DEALERSHIP WAS AWARE OF PROBLEM.*AK CHECK ENGINE LIGHT ILLUMINATED, DEALER REPLACED FAULTY O2 SENSOR. FAULTY BATTERY CAUSING VEHICLE TO CRANK SLOW. DRIVER DOOR WINDOW MOVES SLOW, DEALER LUBRICATED GLASS CHANNEL. OUTER CV BOOT REPLACED, IT WAS CRACKED. SOLENOID VALVE FAULTY CAUSING POOR GAS MILEAGE. *SLC
NHTSA ODI #895469
Mileage unknown · Sep 28, 2000
Unknown Or OtherVehicle Speed Control
WHEN DRIVING VEHICLE JERKS AND RPM LINE GOES UP IN DOWN. THEN VEHICLE STARTS SLOWING DOWN, AND WILL SHUTDOWN. ENGINE CHECK LIGHT STAYS ON. DEALERSHIP IS AWARE OF THE PROBLEM. CONSUMER HAS TO KEEP VEHICLE IN NEUTRALTO KEEP IT IN ORDER. *AK
NHTSA ODI #871768
Mileage unknown · Feb 17, 1999
Electrical SystemEngine And Engine CoolingPower Train
ENGINE NOISE AND LEAKAGE DUE TO THREE COLLAPSED LIFTERS AND FRONT CRANKS SEAL LEAKING, DAMAGE TO BELT FROM OIL.
VEHICLE DESCRIPTION: ACCENT GT MODEL VEHICLES EQUIPPED WITH DOHC ENGINES MANUFACTURED FROM DECEMBER 19, 1996 THROUGH JUNE 30, 1997; 1998 ACCENT MODEL VEHICLES MANUFACTURED FROM MAY 6, 1997 THROUGH JUNE 25, 1998; 1997 SONATA VEHICLES MANUFACTURED FROM AUGUST 1, 1996 THROUGH JULY 9, 1997 AND 1998 SONATA VEHICLES PRODUCED FROM JULY 9, 1997 THROUGH APRIL 24, 1998. THE EVAPORATIVE EMISSION CONTROL SYSTEMS MAY APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. MINOR FUEL TANK DISTORTION COULD RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER COULD NOTICE A GASOLINE ODOR.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF IT IS CRACKED, A NEW FUEL TANK WILL BE INSTALLED. A NEW FUEL FILLER CAP THAT DECREASES THE AMOUNT OF VACUUM INSIDE THE FUEL TANK WILL ALSO BE INSTALLED. NOTE: THE 1997-1998 SONATA FUEL TANKS HAVE ALSO EXPERIENCED CRACKING. HOWEVER, AT THIS TIME, THE CAUSE FOR THE CRACKING HAS NOT BEEN IDENTIFIED. THIS PORTION OF THE CAMPAIGN WILL BEGIN AFTER HYUNDAI HAS DETERMINED THE CAUSE AND CORRECTIVE PROCEDURE.
THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER ELECTRICAL CONTACTS WERE CONTAMINATED DURING ASSEMBLY.
Consequence & remedy
Consequence: THIS CONTAMINATION INTERFERES WITH THE ELECTRICAL CIRCUIT CONTINUITY AND PREVENTS THE WINDSHIELD WIPER MOTOR FROM OPERATING. INOPERATIVE WINDSHIELD WIPERS CAN CONTRIBUTE TO REDUCED VISIBILITY DURING INCLEMENT WEATHER INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REMOVE THE CONTAMINANTS FROM THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER CONTACTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1997 Hyundai Sonata Problems, Complaints & Recalls | Skip That Year
Illustration