2020 Hyundai Santa Fe

Twice while driving in traffic my vehicle’s engine randomly shut off. This left me in very unsafe conditons as one as at a busy intersection which resulted in cars going around me while I attempted to restart my vehicle. The problem hasn’t been reproduced by a dealership. The vehicle hasn’t been inspected. No warning lights or dtc. First failure was 6ish weeks ago.

Prior to these occasions, the Hyundai Santa Fe was constantly needing oil added. On top of that, starting on [XXX], my 2020 Hyundai Santa Fe coded with a check engine light blinking in the upper right corner of the dashboard. I was on [XXX] in NW Indiana on my way to a meeting. The SUV would not accelerate past 2,000 rpm and bogged down on a national interstate sending me into a panic. I had my car towed back to my house. I called my brother in law, [XXX] , who sold me the vehicle in November 2020, to get advice on what to do next. I was told to have the vehicle towed to the nearest dealership. After having my car sit there for two weeks, Webb Hyundai finally looked at it. They upgraded the knock sensor software and had the knock sensor replaced. With the plethora of things that I asked to be repaired or looked at, they only fixed the knock sensor. Due to an extended warranty, I paid $100. Two days later, the SUV got a flat tire. The SUV sat for a week or week and a half due to a flat tire and the place not having it in stock. [XXX] driving back from getting my new tire put on in Valparaiso, Indiana, the vehicle coded again on [XXX]. It caused another very dangerous situation as the vehicle slows to 2,000 rpms. Once again, I had the SUV towed back to my home in Cedar Lake, Indiana. It sat for a few days while I was deciding my next move. This time, I had the vehicle towed to Gerald Hyundai, where my brother in law works and where the vehicle was originally purchased. The vehicle arrived [XXX], 2024. The SUV only sat for one day before telling me all the work that needed to be done. Some of the charges were covered by the extended warranty. Total bill was $540. The work was done on May 13, 2024. I could not pick up the vehicle until the weekend. However, my other car was in an accident, so I did not make it until [XXX] 2024. Shortly after picking up my vehicle, the SUV coded again on [XXX] going back to Indiana. More to follow.. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C

On Interstate 95 in Virginia, multiple times, going ~68-70 MPH the vehicle automatically applied the brakes causing an unsafe situation with a momentary loss of control. Multiple times this has happened with no other vehicle or obstacle in front of, or beside me. It has happened now for no reason causing the loss of control of the vehicle. We have reported this to Hyundai and they cannot find any fault code, or record of the incident. Our understanding is that this is a widespread problem with this vehicle and system, but also includes other vehicles with the same technology. We are afraid this may end up causing serious damage, injuries or fatality(ies). We have asked Hyundai to turn the system off, and they have refused. They have no solution, and we have spent time and money on this.

The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle suddenly lost motive power. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that one bolt on the fuel pump was sheared off and another was extremely loose. The vehicle was repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 63,000.

I purchased this vehicle in early 2023. I was driving on the interstate and received a TINY rock chip that immediately cracked across my entire windshield in April of 2023 resulting in my replacing the windshield. I have since received two TINY rock chips one on 11/25/23 and one on 01/03/24 resulting in immediate cracks. the rock chips are barely visible and as soon as it was heard each time, the windshield cracked considerably. The windshield is faulty and defective. I have driven the same interstate for the last 10 years and have never had this issue with any other vehicle.

The contact owns a 2020 Hyundai Santa Fe. The contact stated while attempting to drive from a complete stop, the accelerator pedal was depressed, but the vehicle failed to respond. The contact stated that he shifted to park(P), turned off, and restarted the vehicle, and the vehicle responded as needed. The contact stated that the failure had recurred 5 times while driving. Additionally, the contact stated that the immobilizer warning light was illuminated. The vehicle was taken to the dealer three times; however, the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 30,595.

The contact owns a 2020 Hyundai Santa Fe. The contact stated while driving at an undisclosed speed, the check engine warning light flashed on the instrument panel, prompting her to pull into a parking area and contact Roadside Assistance. The vehicle was towed to the dealer, who diagnosed a failure with the knock sensor. The vehicle was repaired, but the failure reoccurred. The vehicle was again towed to the dealer, who diagnosed a general failure with the engine, requiring a replacement engine. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 14,500.