IllustrationVehicle began running sluggish, gas smell noticed. Vehicle was due for oil change, took car in for oil change to AAA and mentioned gas smell. AAA identified gas leaking from fuel pump posing immediate safety issue that needed to be resolved.
2020 Hyundai Santa Fe
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2020 Hyundai Santa Fe do not stand out strongly from the model-year median of 212.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Santa Fe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 44 of 209 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports9 fire reports12 injury reports
Vehicle Speed Control complaints
5 reportsFrequent intermittent dash warning lights, no speed indicated, no tach indicated, cycles through warnings of safety systems malfunctioning. No lane departure, no adaptive cruise, no cruise, no forward collision warning, no blind spot warning. The disabling of these systems puts all drivers at risk. Dealership replaced front …
Read full complaint
Frequent intermittent dash warning lights, no speed indicated, no tach indicated, cycles through warnings of safety systems malfunctioning. No lane departure, no adaptive cruise, no cruise, no forward collision warning, no blind spot warning. The disabling of these systems puts all drivers at risk. Dealership replaced front camera and windshield to fix this issue. Not fixed, continues to alarm at random times while driving.
I was backing out of a parking spot and suddenly the car accelerated backwards into a wall. The floor mat was NOT on the accelerator pedal. Obviously, I might have accidently pressed the gas pedal. But, I strongly believe I did not. For me to be mistaken, all three of the following would have to be true: 1) I would have had …
Read full complaint
I was backing out of a parking spot and suddenly the car accelerated backwards into a wall. The floor mat was NOT on the accelerator pedal. Obviously, I might have accidently pressed the gas pedal. But, I strongly believe I did not. For me to be mistaken, all three of the following would have to be true: 1) I would have had to put my foot on the accelerator by mistake, even though I am of sound mind and body, I was not distracted, and I have been driving for decades without having done such a thing. 2) I would have had to continue holding my foot to the gas pedal even as I felt myself racing backwards. 3) Having slammed into the wall, I would have had to be unaware that I had caused the accident. That all three conditions were true seems highly unlikely. (Not impossible. Just unlikely.) I can't imagine stepping on the gas when I meant to step on the brake and then not realizing that I was doing so and then not remembering that I had done so. Cars have computers and computers sometimes have bugs. It seems more likely that a computer glitch caused the crash. And, I suspect that, if it has happened to others, they did not report it because they assume they would not be believed. (When I told a friend of mine what had happened, he told me that, on two separate occasions, he applied the brakes on his Hyundai (a different model) only to have the engine rev up and "fight" his braking. He had to press harder on the brakes to stop his vehicle.) Question: does the onboard computer record all of the car's and computer's activities? (Note: I called the police, who came to document what had happened. I don't believe he filed an official report, but if you need what he recorded, let me know.)
I was driving on an interstate highway at approximately 75 mph. I had cruise control activated. Suddenly the car dramatically slowed down, accompanied by rapid beeping noise. Luckily, there was no one close behind me.
On May 17th, I had an oil change completed on my 2020 Hyundai Santa Fe at a Hyundai dealership. On May 18th, I was parking my Santa Fe in a parking lot with which I am very familiar. I parked in front of the building, but realized that I had not pulled up far enough to the curb. I went to pull up a couple feet and as I started…
Read full complaint
On May 17th, I had an oil change completed on my 2020 Hyundai Santa Fe at a Hyundai dealership. On May 18th, I was parking my Santa Fe in a parking lot with which I am very familiar. I parked in front of the building, but realized that I had not pulled up far enough to the curb. I went to pull up a couple feet and as I started to put my foot on the gas pedal, I heard the engine roar and take off. I hit the brake, but it didn't stop, and I drove through the window and into the building. I was stunned. I have been driving for 44 years, and I have never had an accident that has been my fault. I was in shock that the car would not stop. I thought there might be a recall regarding this issue, but there wasn't. A friend told me he though he read somewhere that Kia and Hyundai were having acceleration issues. I went online and I was shocked that there are so many reports of sudden unintended acceleration and my Santa Fe was one of those vehicles. I saw one website where over 60 people with Santa Fe's have had similar issues. I was very lucky that I did not injure or kill anyone. Hyundai needs to investigate these instances, before more people are injured or killed. I feel these vehicles need to be recalled immediately. I have contacted Hyundai USA and opened a case file. After the extensive repairs to my vehicle were complete, I took my car to the dealership and instructed them to replace the throttle body assembly. To NHTSA: Please grant Defect Petition DP21-003 and investigate these issues.
Official recalls
223V181000 · Trailer Hitches
Mar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
21V00M000 · Visibility:windshield
Dec 28, 2021
Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Santa Fe, 2021 Sonata, and Elantra vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.
Consequence & remedy
Consequence: A windshield that detaches from a vehicle during a crash can increase the risk of injury.
Remedy: Dealers will remove and reinstall the front windshield panel, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 216.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.