Vehicle: 2019 Hyundai Santa Fe, VIN [XXX] , exterior Quartz White Pearl. Component: Exterior factory paint (paint/trim). Complaint: This vehicle exhibits a systemic, progressive factory paint defect — excessive peeling and bubbling of the white finish that spreads from one body panel to the next. This is a known defect across …
Read full complaint
Vehicle: 2019 Hyundai Santa Fe, VIN [XXX] , exterior Quartz White Pearl. Component: Exterior factory paint (paint/trim). Complaint: This vehicle exhibits a systemic, progressive factory paint defect — excessive peeling and bubbling of the white finish that spreads from one body panel to the next. This is a known defect across this vehicle generation; Hyundai acknowledged it by issuing Warranty Extension Z05 (TSB 25-BD-004H), which extends paint coverage to 10 years/unlimited miles for affected white-paint vehicles including the 2019 Santa Fe. Hyundai repaired the hood under this warranty in 2025, during which the vehicle was out of service for 77 consecutive days. Since that repair, the defect has migrated to the adjacent fender and has also appeared on a door, demonstrating that it is spreading across the vehicle. Hyundai has offered to repaint only the single currently-visible panel rather than addressing the systemic defect. I am filing this complaint to document the defect and its progression, and to support the public record regarding factory paint failure on these vehicles. No crash, injury, or fire has resulted. The vehicle is owned by my spouse; I am submitting as authorized representative. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11739369
Mileage unknown · May 11, 2026
Unknown Or Other
Hyundai recently had a service campaign that was issued to address an emissions related issue in CA. The service campaign was 9C2 and the TSB was 25-01-087H. After this software update was applied to my vehicle the engine is now sluggish on a cold start and the transmission is shifting differently at low speeds and low gears. …
Read full complaint
Hyundai recently had a service campaign that was issued to address an emissions related issue in CA. The service campaign was 9C2 and the TSB was 25-01-087H. After this software update was applied to my vehicle the engine is now sluggish on a cold start and the transmission is shifting differently at low speeds and low gears. It appears that the performance of my vehicle has been compromised. There is a Hyundai forum where many Santa Fe owners are experiencing the same issues after the software update. I have notified the service advisor at my local Hyundai dealership.
NHTSA ODI #11737086
Mileage unknown · Mar 2, 2026
StructureUnknown Or Other
The trunk hatch is no longer functioning. The car beeps, but does not unlatch. Once the gate is manually open from a latch inside the trunk, it will not close by pushing the gate close button. It just stopped working. I went into the grocery store, and when I returned with groceries, it stopped working. Hyundai says it's out…
Read full complaint
The trunk hatch is no longer functioning. The car beeps, but does not unlatch. Once the gate is manually open from a latch inside the trunk, it will not close by pushing the gate close button. It just stopped working. I went into the grocery store, and when I returned with groceries, it stopped working. Hyundai says it's out of warranty and will cost $1800 to repair.
NHTSA ODI #11721567
Mileage unknown · Feb 7, 2026
EnginePower TrainUnknown Or Other
Since December my car has been burning oil at a fast rate. My husband has already had to add an additional 4 quarts since my last service 3000 miles ago. I have read and heard from others with a Santa Fe that they are having to replace their engines because of this. They are under warranty. Unfortunately I am not. I’ve already d…
Read full complaint
Since December my car has been burning oil at a fast rate. My husband has already had to add an additional 4 quarts since my last service 3000 miles ago. I have read and heard from others with a Santa Fe that they are having to replace their engines because of this. They are under warranty. Unfortunately I am not. I’ve already dealt with a white paint issue with Hyundai. I called couple weeks ago and was told someone would email me and they have not. I’m not sure where to turn now.
NHTSA ODI #11716394
Mileage unknown · Jun 26, 2025
Unknown Or Other
Rear backup camera not working. Put car in reverse gear multi function screen goes black
NHTSA ODI #11669527
Mileage unknown · Mar 30, 2025
Unknown Or OtherWheels
A year after I purchased vehicle the paint started peeling off the wheel. When I took it to the dealership they kept telling me they were still addressing problem and would get back to me. Contacted them several times and they still didn’t have the problem solved. Then the dealership changed ownerships. New dealership says not t…
Read full complaint
A year after I purchased vehicle the paint started peeling off the wheel. When I took it to the dealership they kept telling me they were still addressing problem and would get back to me. Contacted them several times and they still didn’t have the problem solved. Then the dealership changed ownerships. New dealership says not their problem. And it was too late at this point. I also have the paint on my hood of my car peeling. Both of these problems are gonna be very expensive to repair! I see this is a known problem. Hyundai needs to be accountable. I live in Auburn Al
NHTSA ODI #11651609
Mileage unknown · Mar 16, 2025
Forward Collision AvoidanceUnknown Or Other
Car turns off at lights /stop signs. Automatic break system activates. Have to wait at least five minutes to be able to restart car z same happens after driving and parking. Turbo and battery were replaced. I make sure not to use the automatic on/off feature which make issue worse. This is my fourth attempt to contact you. I …
Read full complaint
Car turns off at lights /stop signs. Automatic break system activates. Have to wait at least five minutes to be able to restart car z same happens after driving and parking. Turbo and battery were replaced. I make sure not to use the automatic on/off feature which make issue worse. This is my fourth attempt to contact you. I cannot trade car in bc of mileage and still owing $. I love me vehicle and just want issue recognized and taken care off.
NHTSA ODI #11648536
Mileage unknown · Feb 13, 2025
Unknown Or OtherVisibility/wiper
Wipers are in the office position, but suddenly go up and down 2 inches, while off, and won't turn on. It snowed the day before, but wasn't while I was driving. Also, my hood is peeling. I have white paint.
NHTSA ODI #11642629
Mileage unknown · Feb 10, 2025
Unknown Or Other
Auto stop/go disables car’s ability to resume driving after stopping at a light etc. This is without activating feature. You have open and close door and press button on/off over and over. Turbo was changed bc mechanic assumed it was the problem. Now it is happening after reaching destination and then attempting to leave if not…
Read full complaint
Auto stop/go disables car’s ability to resume driving after stopping at a light etc. This is without activating feature. You have open and close door and press button on/off over and over. Turbo was changed bc mechanic assumed it was the problem. Now it is happening after reaching destination and then attempting to leave if not sitting long enough. New battery and $2000 turbo!
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Hyundai Motor America (Hyundai) is recalling certain 2019 Hyundai Santa Fe vehicles. The Side Curtain Air Bag (SCAB) mounting bolts may interfere with and damage the air bags during deployment.
Consequence & remedy
Consequence: In the event of a crash, if the air bags become damaged during deployment they may not inflate properly, increasing the risk of injury.
Remedy: Hyundai will notify owners, and dealers will install a protective cover over the SCAB installation bolts, free of charge. The recall began December 3, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 177.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2019 Hyundai Santa Fe Problems, Complaints & Recalls | Skip That Year
Illustration