2019 Hyundai Santa Fe

2019 Santa Fe with 80,000 miles showed signs of excessive oil consumption. Service was scheduled with licensed Hyundai franchise service center. Known oil consumption issues on Theta II engines for that year. Testing requires 3 steps. First step is to change the oil and document levels. Engine is tested for 1000 miles then returned to service center. After 1000 miles, service center reports 2.5 qts of oil per 1000 miles. Hyundai corporate was contacted where they approved warranty work for the vehicle. Step two requires Combustion Chamber Cleaning. During this portion of the work, service center calls about fire that took place immediately after a test drive. Dealership states engine and components destroyed.

Update Re: ODI Complaint Number: 11759237 Subsequent Actions and Manufacturer Refusal to Remediate Safety Defect: ​Following the [XXX], acute safety incident—where the vehicle lost motive power and entered severe limp mode on [XXX] immediately upon release from Sheehy Hyundai of Chantilly—the vehicle remained in dealer custody for 11 days (August 20–August 31, 2026). ​Failure to Diagnose Core Defect: Despite recurring total power loss, active diagnostic trouble code P00AF00 (Turbocharger Boost Control Module Performance), and four consecutive turbocharger destructions within 20,000 miles, the authorized dealership refused to conduct internal engine diagnostics, drop the oil pan, inspect the oil filter, or perform borescope checks. ​Physical Contamination Documented: On August 29, 2026, an on-site physical inspection confirmed sparkling metallic particulate suspended in the engine oil on the dipstick and substantial oil blow-by/intrusion into the turbocharger air intake line. ​Formal Denial of Safety/Warranty Coverage: On August 31, 2026, dealership management and Hyundai Motor America (Consumer Affairs Case #[XXX]) formally denied warranty assistance and refused engine teardown under the Theta II Lifetime Engine Warranty Settlement. Coverage was declined citing "outside influence" due to an aftermarket turbocharger assembly, while Hyundai refused to investigate the underlying engine failure contaminating and destroying the forced-induction system. ​Evidence Preservation: On August 31, 2026, the vehicle was towed to an independent facility to mitigate road hazards, conduct teardown diagnostics, and preserve the engine oil/filter for ISO-accredited spectrographic laboratory analysis. ​The manufacturer released an unsafe vehicle into traffic on August 20, 2026, and subsequently refused to investigate or remedy a documented internal engine failure that creates sudden, recurring loss of motive power. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle suffers from recurring, sudden loss of motive power and transitions into engine "limp mode" while driving in active, heavy traffic. This severe drivability defect has occurred on four separate occasions under Diagnostic Trouble Code (DTC) P00AF00 (Turbocharger/Supercharger Boost Control "A" Module Performance) and related boost/MAP faults (P0234). During these episodes, the vehicle abruptly loses acceleration capability without warning, creating an acute collision risk when navigating highway traffic and intersections. The turbocharger assembly has required replacement three separate times due to recurring oil contamination from the engine crankcase. Despite meticulous maintenance (documented synthetic oil changes every 3,000–5,000 miles since new), the manufacturer and dealership have repeatedly blamed peripheral turbo components rather than diagnosing or repairing the root cause (I suspect excessive engine crankcase pressure/piston ring blow-by based on the significant oil deposition on the turbo, map sensor, and pooling in the intake line).

COMPLAINT SUMMARY: [XXX] / ENGINE THERMAL FIRE RISK / WARRANTY DECEPTION My 2019 Hyundai Santa Fe (2.4L GDI Engine) is experiencing severe powertrain degradation under the known Theta II engine defect class-action framework. On November 7, 2025, the vehicle logged a Permanent Diagnostic Trouble Code (DTC) P1326 via an independent scan, indicating catastrophic internal rod bearing wear. On XXX, the vehicle was brought to Hyundai of Milledgeville for safety recall verification. Instead of executing the mandatory corporate-directed Bearing Clearance Test (BCT) to replace the failing engine block, the service department committed technical campaign malpractice. The technician forced the 9C2 ECU Software Update directly over the locked mechanical fault to suppress the dashboard warning lights and alter the vehicle's ROM ID parameter limits. When caught via a photograph of their active GDS diagnostic tablet showing 7 historical system faults, the service manager provided a truncated printed report hiding Page 1 and omitting the critical P1326 powertrain code count to evade a warranty engine replacement. Due to these unmitigated delays, the vehicle has suffered severe consequential safety damage. The advanced engine degradation and oil consumption have flooded the exhaust system, melting the catalytic converter substrate and triggering a new DTC P042000 (Catalyst Efficiency) fault immediately after the dealer visit. The extreme engine vibrations have also damaged the transmission's torque converter clutch (DTC P074100). The dealership refused a service loaner and knowingly sent a disabled consumer and an elderly passenger away in an active, failing vehicle that presents a sudden stall-on-highway hazard and a severe thermal exhaust fire risk under extreme summer heat conditions. Hyundai Motor America Corporate has failed to provide emergency towing or alternative mobility accommodations despite a registered corporate case file. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(

On March 04, 2026, I took my 2019 Hyundai Santa Fe to the local dealer for oil change service. As part of that service visit, they performed Hyundai recall 9C1 which was supposed to lower tailpipe emissions. The next morning, and ever since, my vehicle ran differently. The engine had several 1000rpm surges and was sluggish at other times. This behavior has continued. Particularly when I first start out in the morning and the engine is cold. Never after the engine is warmed up. A visit to the Hyundai forum shows a growing list of other Hyundai owners who are experiencing the same issues. This recall is defective and should be corrected.

My 2019 Hyundai Santa Fe 2.4L (VIN: [XXX]) is experiencing a severe safety defect involving rapid engine oil starvation. The vehicle recently failed an official oil consumption test conducted by Fred Beans Hyundai of Abington, where it was documented that the engine consumed 1 quart of oil in just 881 miles (PA Request #XXX). This vehicle is equipped with the Theta II engine, which currently has active warranty extensions (TXXC and TXXI) specifically covering connecting rod bearing failure. Despite the documented severe oil loss—which is the primary known cause of connecting rod bearing wear and sudden engine seizure—Hyundai Corporate (Case #XXX) is refusing to evaluate the vehicle under these warranties. They have improperly classified my claim as a denied "goodwill" request and are refusing to perform a connecting rod bearing clearance test to determine if the bearings have been damaged by this starvation. Because Hyundai refuses to perform the required diagnostic safety protocols, the vehicle must be driven in an oil-starved condition. This poses an imminent and severe safety risk of sudden engine seizure, stalling, and complete loss of motive power at highway speeds without warning, which could result in a catastrophic crash. The manufacturer is ignoring their own failure thresholds and putting driver safety at risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine is burning a tremendous amount of motor oil. Dealer does acknowledge engine is burning oil. No warning lights on. Told burning motor oil is normal for a hyundai engine. Engine can seize during driving with no warning and is a safety issue. Front struts are also failing. No warning and is a safety issue: Currently trying to get dealer to cover defective components under warranty. Nothing has been repaired or resolved as of yet.

Engine continuously burns oil excessively and the dealership is falsifying the oil consumption test. At my local oil change shop, there is no oil left on dipstick at 3,000 mile interval. When I took it to dealer for consumption test, they checked dipstick after 1,000 miles and it was OVER THE FULL LEVEL. How can the oil be over the full level? This indicates they overfilled it to begin with and invalidated the test. Hyundai corporate is doing everything they can do avoid addressing this issue with the 2.4 engine in these models. Additionally, the transmission already failed less than 70k miles on the car.

we took it in to be looked at after it had a o2 sensor go bad I changed the sensor and checked fluids I noticed the oil was a touch low and it had metal on the dipstick. I took in to dealership for repair / replacement and Hyundai denied the claim. Even after I have video proof from the dealer technician saying there is metal and bearing material in the oil. I took it to another dealership and they found metal in the oil control valve and still denied it. We got the car back because we were not provided a loaner or a rental. I called back in with concern that the car had a weird burning smell and the car would die. Then it started sounding weird as well. Then called again Saturday because I checked oil and it had fuel smell in the oil. Now today it left my family stranded on the highway. I have th 100,000 mile ten year warranty and the car is only at 83480 miles now when this all started it was at 82000. I have expressed my concern of safety before it finally left my family vernable to be injured in the lane that it died in This afternoon. Many denied claims and now very dangerous situation that was preventable and could have cause fire or death. I brought to manufactures attention early to prevent a accident happening. I was denied all the way through the process .