Engine. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports2 fire reports5 injury reports

What owners actually said

236 reports

30,000 miles · May 12, 2017

Electrical System

WHEN DRIVING THE PARKING LIGHT COMES ON, DOWNHILL ASSIST COMES ON AND THE TRACTION CONTROL GOES OFF, THEN THE SPEEDOMETER GOES FROM THE CURRANT SPEED TO ZERO THEN FLUTTERS BACK TO THE CORRECT SPEED, THEN REPEATS. THIS HAS HAPPENED AT SPEEDS FROM 25 MPH TO 70 MPH. DEALER SAYS THEY CAN'T FIND OUT WHAT IS WRONG.

NHTSA ODI #10985104

64,000 miles · Apr 3, 2017

Fuel/propulsion System

I BOUGHT THIS CAR 16 MONTHS AGO, THE GAS GAUGE STOPPED WORKING, I TOOK THE CAR TO LESTER GLENN HYUNDAI IN TOMS RIVER, NJ WHERE I BOUGHT IT. I USE THIS CAR AND COVER 5 STATES AS A TERRITORY MANAGER, THE WARRANTY EXPIRED 10,000 MILES AGO, THEY SAID THEY WILL TALK TO HYUNDAI TO SEE IF THEY WILL COVER PART. I FEEL AFTER 1 YEAR THIS …

Read full complaint

NHTSA ODI #10970358

16,000 miles · Jan 9, 2017

Vehicle Speed Control

WIFE STOPPED AT STOP SIGN , CAR WOULD NOT RESPOND TO ACCELERATOR PEDAL , 1 BLOCK FROM HOME WAS ABLE TO IDLE CAR INTO DRIVE WAY. I GOT INTO CAR TO SEE WHAT WAS GOING ON FOUND SAME PROBLEM. I SHUT CAR OFF AND RESTARTED AND ACCELERATOR STARTED WORKING , PULLED INTO GARAGE AND CALLED HYUNDAI TO GET TOWED TO DEALER CAR NOT SAFE TO DR…

Read full complaint

NHTSA ODI #10943804

13,640 miles · Dec 5, 2016

Structure

THE ENTIRE PANARAMA SUNROOF EXPLODED ON MY 2016 SANTA FE WHILE TRAVELING ON INTERSTATE 81 @ 70 MPH IN PENNSYLVANIA YESTERDAY COVERING MY WIFE AND I WITH SHARDES OF GLASS. I UNDERSTAND THERE HAS BEEN OTHER INCIDENTS OF THIS NATURE POSTED ON GOOGLE. I CALLED THE DEALER AND GOT THE TYPICAL RUN AROUND. I DID NOT PASS UNDER ANY OVER…

Read full complaint

NHTSA ODI #10929964

14,000 miles · Nov 29, 2016

Visibility/wiper

Read full complaint

A. WIPER HEATERS, AS LISTED ON THE WINDOW INVOICE ARE NON-EXISTANT. I HAD SEVERAL FREEZE-UPS LAST WINTER CAUSING ME TO STOP THE CAR AND CLEAR THE BLADES MANUALLY, EVEN THOUGH THE FRONT DEFROST BUTTON WAS DEPRESSED. DEALER SAID IT WAS OPERATING AS IT SHOULD. (?? - I DISAGREE) B. DURING THE SUMMER I WAS GETTING MOISTURE ON THE INSIDE OF THE WINDSHIELD AND FRONT SIDE WINDOWS. I DISCOVERED A SOPPING WET FRONT PASSENGER FLOOR WHICH THE DEALER ATTRIBUTED TO SPIDERWEBS IN THE A/C CONDENSER DISCHARGE TUBE WHICH THEY "CLEANED" FOR NON WARRANTY $69 PRICE-POINT . WATER APPEARED ON CABIN FIREWALL / CONSOLE YESTERDAY, AS 'DEFROST /BLADE DEICER' ACTIVATES A/C; AND A CIRCLE OF EVENTS BEGINS AGAIN. THE PROBLEM REQUIRES DEFROST TO FUNCTION WHICH CAUSES MORE MOISTURE AND THE WIPERS STILL DO NOT HEAT UP (THE WINDSHIELD UNDER THE BLADES SEEMS TO GET WARM BUT NOT ENOUGH TO KEEP SNOW/ICE FROM THE EXCESSIVE BUILD-UP AND IT'S RESTRICTING AIR INTAKE AT THE PORTS UNDER THE REAR EDGE OF THE HOOD). VISIBILITY IS PROBLEM-MATIC IN THIS CAR'S MALFUNCTION AND DESIGN. THIS 2016 SANTAFE SPORT IS ONE YEAR OLD LAST WEEK.

NHTSA ODI #10928522

Mileage unknown · Sep 8, 2016

EquipmentSeat BeltsCrashInjury

Read full complaint

2016 HYUNDAI SANTE FE INVOLVED IN A NEAR HEAD ON COLLISION. COMBINED TOTAL SPEED OF IMPACT APPROXIMATELY 80 MPH. TWO OCCUPANTS BOTH WEARING SEATBELTS AT TIME OF CRASH. DRIVER SIDE AND PASSENGER SIDE AIRBAGS DEPLOYED DURING CRASH. PASSENGER SHOULDER HARNESS FAILED (LOCKING MECHANISM DID NOT LOCK) RESULTING IN PASSENGER HEAD IMPACT WITH WIND SHIELD CAUSING SIGNIFICANT DEFORMATION OF WIND SHIELD AND HEAD INJURY TO THE PASSENGER. LAP BELT RESTRAINT PREVENTED PASSENGER FROM SIGNIFICANTLY WORSE INJURY. PHOTOS ARE AVAILABLE. *TR

NHTSA ODI #10904763

8,000 miles · Jun 28, 2016

Fuel/propulsion System

I BOUGHT A 2016 SANTA FE SPORT AT CARMAX 8000 MILES AND WHEN I FILLED THE TANK THE FIRST TIME I COULD ONLY FILL ABOUT 13 GAL, I DROVE IN TOWN ABOUT 280 MILES. FILLED NOW A FEW TIMES AND ONLY CAN FILL ABOUT 13 GAL EACH TIME. IT SHOWS AS FULL, HOWEVER THE TANK IS A 17 GAL TANK. ALSO WHEN FILL THE GAUGE SHOWS I SHOULD GET ABOUT 380…

Read full complaint

NHTSA ODI #10877133

1,000 miles · May 2, 2016

Visibility/wiper

Read full complaint

TL* THE CONTACT OWNS A 2016 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 50 MPH IN THE SNOW, THE CONTACT ACTIVATED THE FRONT WINDSHIELD WIPERS. SNOW BEGAN TO ACCUMULATE AT THE BASE OF THE WINDSHIELD WIPERS, WHICH PREVENTED THE WINDSHIELD WIPERS FROM GOING DOWN. AS A RESULT, THE WIPERS BECAME INOPERABLE. THE FAILURE RECURRED THREE TIMES. THE DEALER DIAGNOSED THAT THE WINDSHIELD WIPERS WERE FUNCTIONING AS DESIGNED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 1,000.

NHTSA ODI #10862584

8,100 miles · Apr 5, 2016

Unknown Or Other

Read full complaint

THE FRONT SUNROOF ON MY 2016 SANTA FE I BOUGHT IN JAN 2016 THAT HAS APPROX. 8000 MILES, EXPLODED ON THE WAY TO WORK WHILE DRIVING ON THE INTERSTATE. IT SOUNDED LIKE A GUN SHOT IN MY RIGHT EAR, THEN GLASS BEGAN TO FALL ON MY HEAD AND THROUGHOUT THE CAR - I'M SURE THE MAJORITY OF IT WAS SUCKED OUT AND ONTO THE INTERSTATE. (I HAD THE SUN SHADE INSIDE OPENED SO MY CHILD COULD WATCH THE RAIN ON THE RIDE TO THE BABYSITTERS.)I FOUND OTHERS WITH THE SAME PROBLEM WHEN I GOOGLED IT. CAR WAS TOWED TO DEALERSHIP AND ISSUE WOULD BE COVERED UNDER WARRANTY I WAS TOLD, I WAS GIVEN A LOANER WHILE IT WAS FIXED. NO OTHER VEHICLES IN FRONT OF OR BEHIND ME WITHIN 4 CAR LENGTHS AT LEAST. I DID NOT PASS UNDER AN OVERPASS. IT WAS RAINING THAT DAY (OF COURSE - THAT'S MY LUCK) WHEN I GOT TO WORK I CLOSED THE SUN SHADE ON THE INSIDE AS BEST AS I COULD WITH ALL THE GLASS THAT WAS IN THE TRACK, AND TAPED GARBAGE BAGS OVER IT TO PRESERVE THE INSIDE. I WENT TO DEALERSHIP LATER TO TAKE ADDITIONAL PICTURES AND YOU CAN TELL THE GLASS WAS BLOW OUTWARDS. THERE WAS EVEN CHIPS IN THE PAINT THROUGH THE CLEAR COAT FROM WHEN GLASS FLEW. I'M THANKFUL I WAS THE ONLY ONE IN THE CAR AT THE TIME, BUT MY CHILD'S CAR SEAT IS FULL OF GLASS REMAINS. I WASN'T HURT - ONLY A FEW CUTS FROM GLASS THAT WAS IN MY JACKET POCKET AND IN MY CLOTHES. I AM STILL AT A LOSS AS TO WHAT HAPPENED, HOW AND WHY - UNKNOWN. AND SO FAR THE DEALERSHIP HAS NOT COMMUNICATED ANYTHING TO ME, BUT I HOPE THEY MAKE IT RIGHT.

NHTSA ODI #10853568

3,400 miles · Mar 29, 2016

Wheels

THE SUV 2016 COME EQUIPPED WITH CONTINENTAL 235/55 R19 TIERS, THE SUV HAS ONLY 3400 MILES ON IT SINCE PURCHASE, I LOST TWO TIERS ON A BLOW OUT AT LOW SPEED 35 TO 40 MPH, SIDE WALLS FAILED, (IT WAS ON A STREET) I VISUALLY INSPECTED THE TIRES MYSELF AND AGREED WITH THE TIRE DISTRIBUTOR.

NHTSA ODI #10852291

Official recalls

22V056000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Feb 3, 2022

Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.

17V358000 · Latches/locks/linkages:hood:latch

Jun 5, 2017

Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.

Consequence & remedy

Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.

Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.

16V145000 · Seat Belts:front:warning Light/devices

Mar 10, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.

Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP21003 · Throttle Control System Vulnerabilities

Opened Nov 12, 2021 · Closed Jun 20, 2023

Status: closed (inferred from source dates) · Vehicle Speed Control:throttle

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.