Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
230–25K
1025–50K
1550–75K
1375–100K
21100–150K
6150K+
88 reports with mileage · 166 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 160 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports13 fire reports7 injury reports
What owners actually said
254 reports
Mileage unknown · Jan 31, 2024
Engine
Premature failure of engine that was regularly maintained. Vehicle started sounding louder than normal and stalled spontaneously while driving, stopping in the middle of an intersection. No warning lights illuminated prior to incident. Vehicle had started again when prompted to finish traveling to destination. Oil was checked at…
Read full complaint
Premature failure of engine that was regularly maintained. Vehicle started sounding louder than normal and stalled spontaneously while driving, stopping in the middle of an intersection. No warning lights illuminated prior to incident. Vehicle had started again when prompted to finish traveling to destination. Oil was checked at destination and was low by 1.5 quarts. Vehicle was towed to nearest Hyundai dealership. Vehicle has now been at dealership for almost 5 months. Tech stated that internals were extremely clean upon inspection but that oil port to 1 or more cylinders may have been blocked, causing burning or premature ware and failure. No metal shavings were found in oil according to tech, and engine still turned freely. Hyundai corporate has agreed to cover 90% of cost to replace motor and offer a 12 month /12,000 mile warranty.
NHTSA ODI #11569023
Mileage unknown · Jan 24, 2024
EngineService Brakes
My 2015 Santa Fe Limited with 44,000 miles developed a knocking sound coming from the engine. No lights appeared on the dashboard, no low oil pressure warning, etc. I was able to drive it to my local dealership, but the brakes were very jerky and the car shut off when I pulled into the parking lot. I was told I needed a new eng…
Read full complaint
My 2015 Santa Fe Limited with 44,000 miles developed a knocking sound coming from the engine. No lights appeared on the dashboard, no low oil pressure warning, etc. I was able to drive it to my local dealership, but the brakes were very jerky and the car shut off when I pulled into the parking lot. I was told I needed a new engine, but was denied Hyundai paying for it because the 5 years/100,000 mile warranty had expired. I called corporate and pointed out many instances of excess oil consumption, recalls, and extended warranties due to engines. I was told that my engine didn’t qualify and I would have to pay to have it fixed. I was also given a phone number for a class action lawsuit because Hyundai knows of these kinds of engine problems on my make and model.
NHTSA ODI #11567671
Mileage unknown · Jan 15, 2024
Steering
My power steering failed without notice while driving. This has happened several times. The first time I just happened to need to pull off the highway because my 4 year old had to go to the bathroom and couldn't hold it. It went out as soon as I exited the highway and entered the parking lot. The steering became very hard and he…
Read full complaint
My power steering failed without notice while driving. This has happened several times. The first time I just happened to need to pull off the highway because my 4 year old had to go to the bathroom and couldn't hold it. It went out as soon as I exited the highway and entered the parking lot. The steering became very hard and heavy to move and then just locked up. If I hadn't gotten of the highway when I did it would have happened while driving on the highway with my two young sons which could have resulted in a bad accident. I had no prior warning. It just happened unexpectedly. We thought maybe it was the battery so we replaced the battery with a brand new one but about a month later it happened again when I was backing out of my garage. I was afraid of driving it so I just parked it back in the garage. It is available for inspection. It has not been inspected by anyone yet. The problem just started about a month ago.
NHTSA ODI #11565541
Mileage unknown · Jan 11, 2024
Engine
My 2015 Hyundai Santa Fe sport with 15,643 miles is consuming a lot of oil. I am having to add engine oil on a weekly basis.
NHTSA ODI #11564826
Mileage unknown · Jan 6, 2024
Engine
My 2015 Santa Fe has metal in oil so my engine not working it went out
NHTSA ODI #11563965
Mileage unknown · Jan 4, 2024
EngineFire
The engine caught fire and the vehicle is a total loss. Acceleration became inconsistent at time of the incident while driving on the freeway. Once that was noticed, and at a speed of 50mph, I immediately heard a loud clicking noise coming from the engine. ALL warning lights also immediately went off. I noticed white smoke and p…
Read full complaint
The engine caught fire and the vehicle is a total loss. Acceleration became inconsistent at time of the incident while driving on the freeway. Once that was noticed, and at a speed of 50mph, I immediately heard a loud clicking noise coming from the engine. ALL warning lights also immediately went off. I noticed white smoke and pulled over on the freeway. Once parked, black smoke was emerging from the engine. I exited the vehicle to safety and within 30 seconds, flames emerged from the vehicle. The vehicle maintenance was kept current during the 7 months of ownership. There were no prior warnings of any issues before the incident occurred.
The blue link on all older models is not being supported which cause the screen to become stuck on loading screen. This is a visibility and safety issue because it cause blue link to reload and bright lights to flash as you are driving at night every time it reloads. It is a distraction from the road if you shut it off completel…
Read full complaint
The blue link on all older models is not being supported which cause the screen to become stuck on loading screen. This is a visibility and safety issue because it cause blue link to reload and bright lights to flash as you are driving at night every time it reloads. It is a distraction from the road if you shut it off completely you have no access to radio or sound. The issue it cannot be fixed unless you pay for manual update but you have to it working to actually get the update to run. There are many forums discussing the issue
NHTSA ODI #11554870
Mileage unknown · Nov 2, 2023
EngineUnknown Or Other
Hello, I'm not sure if this is something that you would handle or not. My husband and I have a Hyundai Santa Fe (husband-2015, Mine - 2013). We both bought the vehicles used and haven't had any major problems until about a year ago when both of our vehicles started drinking motor oil like people drink water. We don't have any si…
Read full complaint
Hello, I'm not sure if this is something that you would handle or not. My husband and I have a Hyundai Santa Fe (husband-2015, Mine - 2013). We both bought the vehicles used and haven't had any major problems until about a year ago when both of our vehicles started drinking motor oil like people drink water. We don't have any signs of a leak anywhere. We had taken it to the Hyundai Dealerships and other mechanics and both say that Hyundai has been known to have this problem. Many years ago, I had a Hyundai Sonata which I bought brand new around 2003 and had it for many years. I never had this problem. After doing my research, I have seen where other people have had this problem with their Hyundai vehicles. I emailed several people about our situation, one being [XXX] , and received a response from Hailey, Customer Service Specialist with Hyundai Motor America and her response was for us to have Oil Consumption Testing done. She said that it would be our responsibility to pay for the testing and any repairs that need to be done since we're past the warranty and the years of our vehicles. From what the dealership and other mechanics keep saying, I feel it should be a recall for this problem due to Hyundai being aware that this has been a problem with their vehicles for years. I've known people to have cars much older than ours that never had an oil consumption problem such as this. Also, from what I read, this Oil Consumption Testing is a process that is done in stages which can be costly. Plus this Oil Consumption problem can lead to our engine dying without us knowing when it will die. With this problem, we don't have any warning that our motor oil is low or empty for our oil light will either blink or don't come on at all. I have seen mine blink, but by then the oil was already gone. My husband's oil stick had burnt and he purchased another one from Hyundai. The new one is now burnt and mine is burnt as well. This is a safety hazard. I feel that Hyundai shoul INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INF
NHTSA ODI #11553172
Mileage unknown · Oct 25, 2023
Engine
On October 7, while driving on the interstate, the engine started rattling, then stopped completely, causing me to drift across lanes to get to the shoulder. Upon restarting the car, the check engine light was flashing and the car was in limp mode. After bringing it to a shop, they diagnosed the P1326 engine code, where I was in…
Read full complaint
On October 7, while driving on the interstate, the engine started rattling, then stopped completely, causing me to drift across lanes to get to the shoulder. Upon restarting the car, the check engine light was flashing and the car was in limp mode. After bringing it to a shop, they diagnosed the P1326 engine code, where I was instructed to drive the car on the back roads to the nearest dealership, 50 miles away. The dealership confirmed that the engine needs to be replaced. One month prior to this incident, a P0420 code appeared (catalytic converter needs to be replaced). I had not yet replaced it, since the part is on backorder. My go-to auto shop is still waiting for the catalytic converter to come in. The car currently has about 137,000 miles on it, and has been serviced and inspected regularly. If the engine needs to be inspected, the car is currently awaiting a new engine at the dealer. It will take several months for the dealer to replace the engine, so the car should be available. My safety and the general public's safety was put at risk when my car became difficult to control when the engine stopped unexpectedly while driving at highway speeds on the interstate.
NHTSA ODI #11551817
Mileage unknown · Oct 23, 2023
Engine
2015 3.3 engine santa fe motor seized 115,000miles, no lights, no low oil indicator, no check engine light, no noise except 6minutes prior!
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Consequence & remedy
Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
2015 Hyundai Santa Fe Problems, Complaints & Recalls | Skip That Year
Illustration