I was driving on the highway when, out of nowhere, my car started shaking whenever I went over 40 miles per hour. It was quite alarming and honestly a bit scary. So, I would like to request a recall on it. A week after I took it to Hyundai, they informed me that they sent it to you to see if it would be approved to cover the mot…
Read full complaint
I was driving on the highway when, out of nowhere, my car started shaking whenever I went over 40 miles per hour. It was quite alarming and honestly a bit scary. So, I would like to request a recall on it. A week after I took it to Hyundai, they informed me that they sent it to you to see if it would be approved to cover the motor. I’ve had this car for just 2 years, and it's frustrating to deal with issues like this. I truly appreciate your attention to this matter, as I hope we can resolve it soon. Thank you for your understanding!
NHTSA ODI #11626687
Mileage unknown · Feb 12, 2024
EnginePower TrainVehicle Speed Control
Recent cold weather starts in the morning (40-50 degrees fahrenheit) have caused my car to have poor or stalled acceleration. It will occasionally not go past 20 or 40 mph while the RPMs rev high. The DTC error code would read P2565 as a pending code. An independent mechanic changed out my transmission fluid and switched out my …
Read full complaint
Recent cold weather starts in the morning (40-50 degrees fahrenheit) have caused my car to have poor or stalled acceleration. It will occasionally not go past 20 or 40 mph while the RPMs rev high. The DTC error code would read P2565 as a pending code. An independent mechanic changed out my transmission fluid and switched out my boost pressure sensor but the problem is still there. Hyundai says that they need to replicate the problem but it does not occur when I take it to them so it's very hard to have this intermittent issue diagnosed by them. This is a very dangerous issue in my opinion if your cars engine revs high without accelerating and can potentially cause serious accidents and injury. I know I'm not the only person experiencing this issue as I've read on online forums of other car owners describing the same issue. Please issue a safety recall before someone is seriously injured or dies as a result of this intermittent issue.
NHTSA ODI #11571466
Mileage unknown · Sep 1, 2023
Electrical SystemEngineVehicle Speed Control
Vehicle has been consuming oil between oil changes. Recently the ABS, Down hill assist, and traction control lights came on. We took it to the dealer and were advised it was a wheel speed sensor in the passenger rear, but they wanted over $600 so we did not repair. Two days later all the lights went off and we had no issues. A…
Read full complaint
Vehicle has been consuming oil between oil changes. Recently the ABS, Down hill assist, and traction control lights came on. We took it to the dealer and were advised it was a wheel speed sensor in the passenger rear, but they wanted over $600 so we did not repair. Two days later all the lights went off and we had no issues. A month later I drove to Florida, checked and filled the oil with a little over one quart. On my way back the RPM shot up to close to 6K, the engine light started flashing, oil and battery light came on, and the car lost all power qnd started shuttering. There was a strong burning smell when we pulled over, that may it hard to breathe. As of writing this we were told it sounds like the engine has seized, but they are 5 months out on looking into it.
NHTSA ODI #11542203
Mileage unknown · Jul 9, 2023
Electrical SystemEngineVehicle Speed Control
Engine suddenly went into limp mode and jerked steering while on the highway (engine light happened AFTER). We started about 60mph, then vehicle slowed to about 30mph in a few seconds. Almost crashed into a semi-truck trying to get my car under control, then almost caused a pileup collision behind a slow-moving traffic control v…
Read full complaint
Engine suddenly went into limp mode and jerked steering while on the highway (engine light happened AFTER). We started about 60mph, then vehicle slowed to about 30mph in a few seconds. Almost crashed into a semi-truck trying to get my car under control, then almost caused a pileup collision behind a slow-moving traffic control vehicle. Limped into town. Engine was rattling. Found the engine to be very hot under the hood. Found oil dripping underneath (research says certain Hyundai Santa Fe were recalled for this issue). Oil was low, even though I had it topped off less than a week before. It seems this may be related to large oil use resulting in engine overheat. Mechanic later disclosed to me there was oil buildup underneath and in the engine. Towed into another city to get available mechanic. Found error code P1326. Mechanic took a couple days to determine it was NOT caused by faulty sensor. (attached invoice) Towed to another city where I could have it taken into the lot (there is a long backload of cases at Hyundai). I saw about a dozen of the exact same model as my car in the service lot waiting repair (and many similar models). Told by dealership it would take 2 months to repair and there would be a diagnosis fee. This shouldn't have happened to my car. It was relatively new and low miles for an engine failure. The result was an expensive series of expenses and extremely dangerous series of near-collisions. It has been difficult to contact and navigate Hyundai corporate for help with this. They seem to have a lot of backlogs of these problems related to my model. I get put on hold for long periods. I was assigned case number and case manager who hasn't contacted me yet. I am still without a car as of today.
NHTSA ODI #11531213
Mileage unknown · Apr 8, 2022
Power TrainVehicle Speed ControlWheels
It appears to be a problem with all the Hyundai Santa Fe Sport. It has abs, downhill, stability control lights on at the same time. It appears to be wheel speed sensor but they do not know which one. The service manager had said it happens to be a lot of the time the rear sensor that goes out. The service manager made it seem l…
Read full complaint
It appears to be a problem with all the Hyundai Santa Fe Sport. It has abs, downhill, stability control lights on at the same time. It appears to be wheel speed sensor but they do not know which one. The service manager had said it happens to be a lot of the time the rear sensor that goes out. The service manager made it seem like it happens frequently. When I check online a lot of owners appear to be having the same issue. THREE LIGHTS, ESC, DBC, and ABS warning lights turn on. I am in fear for my life, due the safety on the road if the tires would lose control!
NHTSA ODI #11460210
100,000 miles · Apr 11, 2019
Power TrainVehicle Speed Control
CAR STARTED SURGING FORWARD WITHOUT TOUCHING GAS PEDAL, IT LUNGES AT HIGHWAY SPEEDS AS WELL. I
NHTSA ODI #11195615
21,000 miles · Sep 2, 2018
EngineFuel/propulsion SystemVehicle Speed Control
TWICE ENGINE QUIT WHILE OPERATING WITH NO WARNING. ONCE AT 60MPH AND THE OTHER AT SLOW SPEED WHILE TURNING AROUND. RESTARTED BY PLACING IN NEUTRAL AND PUSH START BUTTON WHILE STILL MOVING. 21000+ MILES. DEALER OFFERS NO EXPLANATION. THERE ARE NUMEROUS REPORTS OF SIMILAR INCIDENTS WITH HYUNDAI VEHICLES. NO FIXES I HAVE BEEN ABLE…
Read full complaint
TWICE ENGINE QUIT WHILE OPERATING WITH NO WARNING. ONCE AT 60MPH AND THE OTHER AT SLOW SPEED WHILE TURNING AROUND. RESTARTED BY PLACING IN NEUTRAL AND PUSH START BUTTON WHILE STILL MOVING. 21000+ MILES. DEALER OFFERS NO EXPLANATION. THERE ARE NUMEROUS REPORTS OF SIMILAR INCIDENTS WITH HYUNDAI VEHICLES. NO FIXES I HAVE BEEN ABLE TO FIND AND LITTLE SATISFACTION FROM THE MFR.
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Consequence & remedy
Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
2015 Hyundai Santa Fe Problems, Complaints & Recalls | Skip That Year
Illustration