Engine. Review the 160 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports13 fire reports7 injury reports

Unknown Or Other complaints

22 reports

Clear category filter

Mileage unknown · Dec 31, 2024

Unknown Or Other

The driver's door is stuck, it cannot be opened.

NHTSA ODI #11633342

Mileage unknown · Dec 21, 2024

Exterior LightingForward Collision AvoidanceUnknown Or Other

Read full complaint

THE BRAKE LIGHT SWITCH IS MALFUNCTIONING AND CAUSING THE BRAKE LIGHT TO STAY ON CONTINIOUSLY. THIS IS DANGEROUS BECAUSE THE BRAKE LIGHT STAYS ON SO THERES NO INDICATION THAT I'M GETTING READY TO STOP BECAUSE THE LIGHT IS ALREADY ON, INCREASEING THE RISK OF A CRASH. THE CRUISE CONTROL IS ALSO AFECTECED WITH THIS ISSUE BECAUSE IT STOP WORKING AT THE SAME TIME. I LOOKED UP THE RECALL AND IT SAID THAT 2013 -2015 HYDUNDIA SANTA FEE SPORT VIHECLES WERE AFFECTED, BUT WHEN I CALL THE DEARLERSHIP THEY SAID MY VIN# WAS NOT INCLUDED IN THE RECALL!

NHTSA ODI #11631945

Mileage unknown · May 15, 2024

Unknown Or Other

Read full complaint

While driving, there was a very loud pop, following by the sound of glass shattering. I was unable to tell which window was broken since it was dark outside (early morning before sunrise), but I could hear wind coming into the car. I pulled over and inspected my car, and that is when I noticed that the middle portion of the panoramic sunroof was completely shattered. Fortunately, the inside cover was closed, otherwise the glass would have fallen on top of my head & covered me in broken glass from the sunroof, as well as the front and rear seat passengers. I am grateful that my children were not in the car with me when this occurred. My safety was at risk 1), due to the loud pop/explosion sound which startled me & caused me to swerve while driving. 2) the shattered glass falling from the sunroof onto my head and the rest of my person, as well as any passengers, could have caused serious injury especially if glass had fallen into the eye of anyone inside of the vehicle, especially the driver. This could have endangered others by causing me to collide with another motorist on the roadway. Prior to the shattered sunroof, there were no warning signs to indicate anything like this would happen. No warning lamps, no visible defects, issues, or other symptoms of failure were present before this occurred. The issue of exploding sunroofs has been a well-known issue with Hyundai vehicles with panoramic sunroofs and resulted in a recall for some models of Hyundai. I contacted a local dealership after my incident, and he was aware of the unexpected shattering of the sunroofs, but advised that my vehicle was out of warranty, and that my model year was not included in the recall group, and therefore it was not covered for the incident. There are many online forums that discuss this issue for various Hyundai vehicles in the USA & Canada, including class action lawsuits regarding the issue. Photos taken of the damage for insurance claim. Stress marks seen in photos.

NHTSA ODI #11588817

Mileage unknown · Nov 2, 2023

EngineUnknown Or Other

Read full complaint

Hello, I'm not sure if this is something that you would handle or not. My husband and I have a Hyundai Santa Fe (husband-2015, Mine - 2013). We both bought the vehicles used and haven't had any major problems until about a year ago when both of our vehicles started drinking motor oil like people drink water. We don't have any signs of a leak anywhere. We had taken it to the Hyundai Dealerships and other mechanics and both say that Hyundai has been known to have this problem. Many years ago, I had a Hyundai Sonata which I bought brand new around 2003 and had it for many years. I never had this problem. After doing my research, I have seen where other people have had this problem with their Hyundai vehicles. I emailed several people about our situation, one being [XXX] , and received a response from Hailey, Customer Service Specialist with Hyundai Motor America and her response was for us to have Oil Consumption Testing done. She said that it would be our responsibility to pay for the testing and any repairs that need to be done since we're past the warranty and the years of our vehicles. From what the dealership and other mechanics keep saying, I feel it should be a recall for this problem due to Hyundai being aware that this has been a problem with their vehicles for years. I've known people to have cars much older than ours that never had an oil consumption problem such as this. Also, from what I read, this Oil Consumption Testing is a process that is done in stages which can be costly. Plus this Oil Consumption problem can lead to our engine dying without us knowing when it will die. With this problem, we don't have any warning that our motor oil is low or empty for our oil light will either blink or don't come on at all. I have seen mine blink, but by then the oil was already gone. My husband's oil stick had burnt and he purchased another one from Hyundai. The new one is now burnt and mine is burnt as well. This is a safety hazard. I feel that Hyundai shoul INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INF

NHTSA ODI #11553172

Mileage unknown · Jul 12, 2023

EngineUnknown Or Other

Read full complaint

I came through car was and proceeded to vacuum area, as I approached the area I applied my brakes and car sped up jumping the curb. I tried pumping the brakes and finally brought vehicle to a stop after applying pressure. I tried to back up, but felt I was going to damage the vacuum hoses, so I pulled forward believing I had clear area to get to the other side. As I pulled forward I didn’t realize how close I was to a brick column as it didn’t appear in my side view mirror. As a result right rear door, rear quarter panel and trim were damaged.

NHTSA ODI #11531912

Mileage unknown · Apr 24, 2023

Unknown Or Other

Hello. My sunroof glass was shattered while I was driving with a large boom sound. My vehicle has a total mileage of less than 70000 miles an it was under extended warranty. Hyundai refused to bear the repair cost.

NHTSA ODI #11518667

Mileage unknown · Aug 29, 2022

Unknown Or Other

Was driving and it just quit with smell from under hood

NHTSA ODI #11481680

Mileage unknown · Apr 29, 2022

Unknown Or OtherFire

Read full complaint

Summer of 2020,my engine needed to be replaced for an unknown reason, that work was done at the Herb Chambers Hyundai service department. On 4/22/2022 my car hesitated to start, it did start, I traveled about 12 miles and my engine light came on. I traveled about 3 more miles and then my car stalled in the middle of the highway, I headed to the breakdown lane very quickly. As soon as I put the car in park, the car started to smoke, I ran down the highway on foot, called 911, I turned around and my car was engulfed in flames. This whole incident went awry very quickly, about 5 minutes. I am writing in as I was offered $16000.00 as a settlement for my vehicle and all losses from Hyundai. My insurance company is offering about $1500.00 more than Hyundai. Hyundai is not even performing an inspection which was not what they communicated initially. I was told an inspection needed to be done prior to any settlement decision. Their is a known recall, I understand, recall #205, which I had not yet been notified of. I want to reiterate that no inspection on Hyundai's part was done to confirm damage/recall issue. At this point I do not have a vehicle and not in a position to buy a new car.

NHTSA ODI #11462810

Mileage unknown · Mar 18, 2022

Unknown Or Other

Read full complaint

The driver side door latch stopped working. The door cannot be opened from the inside OR the outside. This is a huge safety risk. In an emergency, not being able to exit the vehicle could put the driver and entire car at risk of injury and death. Consider having two child seats in the back, and the child locks active. This leaves one functioning door. And if this mechanism failure is systemic, consider multiple latch failures in conjunction. Multiple passengers would have extreme difficulty exiting the vehicle safely, especially in exigent circumstances.

NHTSA ODI #11457232

Mileage unknown · Feb 5, 2022

Back Over PreventionUnknown Or Other

Read full complaint

The navigation/backup camera screen gets stuck on the loading page. This problem began right after the warranty period ended, which appears to be a common complaint on the message boards. When it first became a problem, it eventually would load, but would take approximately 15 minutes. Now, it fails to load at all (just continuously displays "loading"), which renders the backup camera, navigation system, maps, radio, satellite, clock and all associated controls useless. A backup camera is essential for me--I will not drive a car without one, since it a safety concern due to kyphosis. Having the navigation on a large screen (versus my phone or a printed map) is another reason I chose this car. So, not repairing it is not an option. It is a safety issue. When trying to find a solution, I found hundreds upon hundreds of complaints for the same issue with the same model as my car. The dealership also was aware of it. So, I figured I would report it since it is so common, hoping to save others from the $1000+ bill I received to repair it.

NHTSA ODI #11450560

Official recalls

23V651000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Sep 22, 2023

Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.

17V358000 · Latches/locks/linkages:hood:latch

Jun 5, 2017

Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.

Consequence & remedy

Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.

Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP21003 · Throttle Control System Vulnerabilities

Opened Nov 12, 2021 · Closed Jun 20, 2023

Status: closed (inferred from source dates) · Vehicle Speed Control:throttle

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.