NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
21 reportsClear category filterMileage unknown · May 9, 2026
EnginePower TrainService Brakes
2015 Hyundai Santa Fe Limited, 3.3L Lambda II GDI V6, ~102,000 miles. In December 2022, an authorized Hyundai dealer replaced three specific parts under a Hyundai recall/campaign (records requested). On Sunday [DATE] at approximately [TIME] PM, I was driving on [FREEWAY], [STATE], at 55–70 mph at night. With NO prior warning — n…
Read full complaint
2015 Hyundai Santa Fe Limited, 3.3L Lambda II GDI V6, ~102,000 miles. In December 2022, an authorized Hyundai dealer replaced three specific parts under a Hyundai recall/campaign (records requested). On Sunday [DATE] at approximately [TIME] PM, I was driving on [FREEWAY], [STATE], at 55–70 mph at night. With NO prior warning — no warning lights, no chimes, no loss of power buildup, no knocking, no engine protection mode — the engine suddenly and completely died. The failure was instantaneous. There was no limp-home mode and no opportunity to reach the shoulder under engine power. The vehicle lost forward momentum and rolled backward in a live highway travel lane, where it remained stranded until a tow truck recovered it. No injuries. The 12V battery and electrical system remained fully active throughout. The instrument cluster was operational and capable of displaying warnings before the failure. None were displayed. Dashboard warning lights illuminated only seconds AFTER the engine had already died — a post-failure consequence of engine shutdown, not a pre-failure warning. An independent mechanic diagnosed a seized engine due to loss of oil flow. No oil pressure or low-oil light had ever illuminated. The vehicle was then transported to the Hyundai dealer that performed the 2022 service; they promised a diagnostic call and have not provided one or any written diagnostic. This failure mode matches Hyundai TSB 24-EM-003H (15yr/150k extended warranty for 3.3L Lambda II engines in 2013–2019 Santa Fe), NHTSA Recall 21V-727 (acknowledging stall risk at highway speed), and the active class action Burns v. Hyundai Motor Company (C.D. Cal. 2025). Hyundai's KSDS is documented to trigger a blinking MIL, audible chime, and reduced-power Engine Protection Mode upon bearing wear. None of these protective behaviors occurred.
NHTSA ODI #11736814
Mileage unknown · Mar 21, 2024
Service Brakes
The contact owns a 2015 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was notified and confirmed that the part was not yet available. The contact stated that the manufacturer ha…
Read full complaint
The contact owns a 2015 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was notified and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA ODI #11578785
Mileage unknown · Jan 24, 2024
EngineService Brakes
My 2015 Santa Fe Limited with 44,000 miles developed a knocking sound coming from the engine. No lights appeared on the dashboard, no low oil pressure warning, etc. I was able to drive it to my local dealership, but the brakes were very jerky and the car shut off when I pulled into the parking lot. I was told I needed a new eng…
Read full complaint
My 2015 Santa Fe Limited with 44,000 miles developed a knocking sound coming from the engine. No lights appeared on the dashboard, no low oil pressure warning, etc. I was able to drive it to my local dealership, but the brakes were very jerky and the car shut off when I pulled into the parking lot. I was told I needed a new engine, but was denied Hyundai paying for it because the 5 years/100,000 mile warranty had expired. I called corporate and pointed out many instances of excess oil consumption, recalls, and extended warranties due to engines. I was told that my engine didn’t qualify and I would have to pay to have it fixed. I was also given a phone number for a class action lawsuit because Hyundai knows of these kinds of engine problems on my make and model.
NHTSA ODI #11567671
Mileage unknown · Sep 3, 2023
Fuel/propulsion SystemService BrakesSteering
While driving at 65 mph on an urban expressway, the engine quit without warning and would not restart. This resulted in diminished steering and braking control as well as exposure near the edge of traffic on a narrow berm of an overpass bridge. Full tank of fuel, good battery, the engine would not crank or restart. All electr…
Read full complaint
While driving at 65 mph on an urban expressway, the engine quit without warning and would not restart. This resulted in diminished steering and braking control as well as exposure near the edge of traffic on a narrow berm of an overpass bridge. Full tank of fuel, good battery, the engine would not crank or restart. All electrical accessories work fine.
NHTSA ODI #11542427
Mileage unknown · Apr 6, 2022
Electrical SystemService BrakesFire
The car was parked for about 4 hours and suddenly catches fire and reports says it was ABS anti brake system and i got my car burnt. Is there any help Hyundai can assist me.
NHTSA ODI #11459838
Mileage unknown · Sep 4, 2021
Electrical SystemService BrakesFire
Hyundai Santa Fe Sport 2015 was making sounds when vehicle was off. The ABS warning lights were lit on the dashboard (3 warnings in total) once car was turned on. Drove home hoping the sound would go away but it did not. Once home the sound continued without the vehicle being on. Opened the hood and listened for the location of …
Read full complaint
Hyundai Santa Fe Sport 2015 was making sounds when vehicle was off. The ABS warning lights were lit on the dashboard (3 warnings in total) once car was turned on. Drove home hoping the sound would go away but it did not. Once home the sound continued without the vehicle being on. Opened the hood and listened for the location of the sound. It was the ABS module on the left. This part then caught on fire while parked and off (keys were out).
NHTSA ODI #11431709
117,000 miles · Aug 23, 2021
Service BrakesFire
The contact owned a 2015 Hyundai Santa Fe. The contact stated while driving 25 mph, when he lost control of the vehicle and multiple warning lights were illuminated. The contact stated while attempting to park on the side of the road, he saw smoke entering the AC vents. The contact and his son (front passenger) were able to exit…
Read full complaint
The contact owned a 2015 Hyundai Santa Fe. The contact stated while driving 25 mph, when he lost control of the vehicle and multiple warning lights were illuminated. The contact stated while attempting to park on the side of the road, he saw smoke entering the AC vents. The contact and his son (front passenger) were able to exit the vehicle before it exploded. The contact stated the fire was located in the front of the vehicle. The contact stated no one was injured nor sought medical attention. The fire department was able to extinguish the fire, but was unaware if a fire report was filed. The police report was filed. The vehicle was not drivable. The insurance company deemed the vehicle total loss. The vehicle was towed to a towing yard. The contact called the local dealer and made them aware of the failure. The manufacturer had been informed of the failure. The contact stated two days after the incident, he received notification of NHTSA Campaign Number: 21V303000 (SERVICE BRAKES, HYDRAULIC) and associated the failure with this recall. The failure mileage was approximately 117,000.
NHTSA ODI #11430124
Mileage unknown · Jun 29, 2021
Forward Collision AvoidanceService BrakesCrashFire
ABS failed while merging causing a collision that ended up totaling my car.
NHTSA ODI #11422818
Mileage unknown · Jun 15, 2021
Service Brakes
Leak which may cause a fire. This is second recall for same problem. I feel unsafe while driving. They say if ABS light comes on to stop immediately. Unable to park in my garage or close to the house. No incidents as of now. I do not understand why this is taking so long and we are expected to drive an unsafe vehicle. Val…
Read full complaint
Leak which may cause a fire. This is second recall for same problem. I feel unsafe while driving. They say if ABS light comes on to stop immediately. Unable to park in my garage or close to the house. No incidents as of now. I do not understand why this is taking so long and we are expected to drive an unsafe vehicle. Value of car has also dropped.
NHTSA ODI #11421003
Mileage unknown · Feb 12, 2021
Service Brakes
RECALL 194 IS RELATED TO POTENTIAL ELECTRICAL FIRE. THIS RECALL HAS BEEN OUT SINCE 9/2020 AND YET NO DEALERSHIP HAS PARTS TO FIX THE PROBLEM. I HAVE CALL AT LEAST 3 TIMES AND GET TOLD "PARTS ARE NOT AVAILABLE". LAT CALL IS THE DATE BELOW.
NHTSA ODI #11395890
Official recalls
2Sep 22, 2023
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
Jun 5, 2017
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Consequence & remedy
Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
Illustration