IllustrationDaughter was driving vehicle when began hesitating on road and losing power. She also heard knocking sound coming from engine. Concerned she would get rear ended she pulled off to side of road. No engine warning lights. Had vehicle towed to dealership where upon inspection determined total engine failure.
2015 Hyundai Santa Fe
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2015 Hyundai Santa Fe do not stand out strongly from the model-year median of 212.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Santa Fe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
230–25K
1025–50K
1550–75K
1375–100K
21100–150K
6150K+
88 reports with mileage · 166 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 160 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports13 fire reports7 injury reports
Engine complaints
160 reportsThe contact owns a 2015 Hyundai Santa Fe Sport. The contact stated while driving approximately 35 MPH, the vehicle lost motive power and stalled. The contact depressed the accelerator pedal however, the vehicle failed to respond. The contact steered the vehicle off of the roadway safely. The contact was unable to restart the veh…
Read full complaint
The contact owns a 2015 Hyundai Santa Fe Sport. The contact stated while driving approximately 35 MPH, the vehicle lost motive power and stalled. The contact depressed the accelerator pedal however, the vehicle failed to respond. The contact steered the vehicle off of the roadway safely. The contact was unable to restart the vehicle. The contact stated no warning light was illuminated. The vehicle was towed to the residence and then to a dealer. The dealer diagnosed the vehicle and determined that the engine had seized and needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was 194,353.
I am the 2nd owner of my 2015 Santa Fe Sport 2.0T, having purchased it in June 2018. I had regular oil changes, the last one being done on 1/24/22 at 134K miles. Engine started knocking after that oil change, so I was driving back to the repair shop on 1/25/22 when I was unable to accelerate and I pulled off to the side of the…
Read full complaint
I am the 2nd owner of my 2015 Santa Fe Sport 2.0T, having purchased it in June 2018. I had regular oil changes, the last one being done on 1/24/22 at 134K miles. Engine started knocking after that oil change, so I was driving back to the repair shop on 1/25/22 when I was unable to accelerate and I pulled off to the side of the interstate. Some warning lights flashed briefly when the acceleration started, but I wasn't able to see which ones since I was more concerned with pulling safely off the road. Towed to the closest repair shop and they advised that my engine was seized and that Hyundai had an open recall so I needed to take my car to a Hyundai dealership. I had it towed to the dealership right away, where it said for the next 6+ weeks waiting to be inspected. They finally inspected it on 3/10/22 and submitted it to Hyundai for approval to replace the engine. Hyundai came back and asked for maintenance records, which I provided on 3/15/22. Today, 3/17/22, I was told Hyundai denied my claim because I didn't bring my car in for repair as soon as the the recall was issued. I didn't know there was a recall until this happened. The only thing I received in the mail was something about a hood latch problem, but that was a different issue. Once I found out about the recall (after my engine had already seized) I did go online to look up the details and Hyundai's recall specifically said that owners can continue driving their car. So even though I didn't know about the recall, and when I did find out about the recall it said the car could continue to be driven, Hyundai won't replace the engine. I tried to call Hyundai to appeal the decision and their message said the office is closed to do scheduled maintenance. There is no option to leave a message.
The contact owns a 2015 Hyundai Santa Fe Sport. The contact stated while driving at approximately 25 MPH, the vehicle stalled without warning. After the failure, the check engine warning light was illuminated. The vehicle was towed to the local dealer. The vehicle was not diagnosed or repaired. The manufacturer was not made awar…
Read full complaint
The contact owns a 2015 Hyundai Santa Fe Sport. The contact stated while driving at approximately 25 MPH, the vehicle stalled without warning. After the failure, the check engine warning light was illuminated. The vehicle was towed to the local dealer. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 120,000.
Motor seized no warning no lights no previous issues while driving
No warning lights. Had started making a small noise that morning but nothing of concern, sounded like a rock in my tire. Was driving up hill, started struggling, then lost all power, had no brakes, Parts went flying out from under car. Smoke came out from hood. Had no brakes or power. Cars behind me could have been hit by flying…
Read full complaint
No warning lights. Had started making a small noise that morning but nothing of concern, sounded like a rock in my tire. Was driving up hill, started struggling, then lost all power, had no brakes, Parts went flying out from under car. Smoke came out from hood. Had no brakes or power. Cars behind me could have been hit by flying parts, left a trail of parts on road. I had my kids in car and if we would have been going down hill I wouldn’t have been able to stop. Had entire engine replaced. Hole in engine block. Piston and and valve pieces on road
My car shut down while traveling at a normal speed on a freeway and I had to pull over as it slowed down. This was unsafe on a busy highway while I waited 3 hours to be towed. The car dealer service center stated a faulty connecting rod bearing failure caused the problem and requires a new engine to be installed. There were no w…
Read full complaint
My car shut down while traveling at a normal speed on a freeway and I had to pull over as it slowed down. This was unsafe on a busy highway while I waited 3 hours to be towed. The car dealer service center stated a faulty connecting rod bearing failure caused the problem and requires a new engine to be installed. There were no warning lights or sounds prior to the problem. Regular maintenance was done including an oil change and filter within the 6month recommendation. The dealership said there was no oil and the engine seized.
The engine completely failed while driving on the highway. The check engine light appeared approximately 20 minutes prior to event. Vehicle was serviced regularly, Including at a hyundai dealership in July. Per our independent mechanic the engine seized up. The engine is available upon request.
Per the Theta Engine Recall Settlement, I had the recall work performed on my 2015 Hyundai Sante Fe on August 23, 2021. Roughly in October, the oil light faded on and off on the dashboard. I pulled into the Autozone and purchased 1 Quart of engine oil. I checked the dipstick in the parking lot and added the quart to the prop…
Read full complaint
Per the Theta Engine Recall Settlement, I had the recall work performed on my 2015 Hyundai Sante Fe on August 23, 2021. Roughly in October, the oil light faded on and off on the dashboard. I pulled into the Autozone and purchased 1 Quart of engine oil. I checked the dipstick in the parking lot and added the quart to the proper fill line of the engine dipstick. On 11/11/2021, while driving my vehicle, without any warning, the engine stopped and shut the car off in traffic. The oil light, check engine light, and service light came on then went off. I attempted 5 times to restart the engine before it would run. I took it to a Midas Auto shop where the diagnostic advised the engine failed and was damaged. I had the vehicle towed to Larry H. Miller Hyundai in Peoria, AZ 85382. The diagnostics indicated that the engine failed as was due to the fact of the Theta Class Engine Recall. The mechanic, service manager, and service advisor took notes and photographs of the valve train on the engine block. They advised the vehicle engine was damaged and needed replacement. They advised they did not find any indications of lack of maintenance. The engine was low on oil as it is apparent that the engine was more likely running hot. Hyundai Motors has denied the extended warranty claim (even though the recall updates have been completed prior to the engine failure). I have appealed within the company for the replacement of the engine but Hyundai is continuing to deny the claims. The dealership has advised other customers are being denied for the same reason just due to gaps in service records even though there are no indications of wear of the engine. Hyundai has since tried to settle the claim with me for $500.00 to release the company from any liability that the HMA failed to conform the vehicle to warranty in connection fo my concerns and history repair.
On or about October 16th 2021. After leaving a resturant I was unable to restart my car. It just would not turn over. I called a tow truck thinking It was possibly the starter. The vehicle was towed to Kia, where it was purchased. Upon inspection they(mechanics) also thought it was the starter. Being that the car is under an ext…
Read full complaint
On or about October 16th 2021. After leaving a resturant I was unable to restart my car. It just would not turn over. I called a tow truck thinking It was possibly the starter. The vehicle was towed to Kia, where it was purchased. Upon inspection they(mechanics) also thought it was the starter. Being that the car is under an extended warranty, they contacted the appropriate company for the coverage. However the starter was or isn't the problem, they now believe it's the engine. Mind you I have less than 100,000 miles. I was told I would possiblly incounter a cost of 900.00 for them to determine what's wrong with the vehicle? At the time of me submitting this complaint, my car has been in the repair shop for 3 months. Can you imagine my rental expenses? I"ve read through several complaints of people expressing their concerns and complaints for this same or similar problem, It appears to me that Hyundai has a problem. I"m still without a vehicle.
Official recalls
223V651000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Sep 22, 2023
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
17V358000 · Latches/locks/linkages:hood:latch
Jun 5, 2017
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Consequence & remedy
Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.