IllustrationThe engine has basically come apart. There is a timing chain issue, the engine is not recalled and it is getting where the car cannot drive. There is a constant smell of burning electrical wires. There’s also issues with the heating and air that is related to electrical.
2015 Hyundai Santa Fe
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2015 Hyundai Santa Fe do not stand out strongly from the model-year median of 212.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Santa Fe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
230–25K
1025–50K
1550–75K
1375–100K
21100–150K
6150K+
88 reports with mileage · 166 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 160 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports13 fire reports7 injury reports
Electrical System complaints
20 reportsThe engine is continually knocking. It has caused the powertrain system to start to fail. The interior portion of the car with electrical is malfunctioning and causing the car to lag. Many attempts have been taken to get the vehicle fixed to no avail. $1,000 just to take out the engine to diagnose the problem.
The blue link on all older models is not being supported which cause the screen to become stuck on loading screen. This is a visibility and safety issue because it cause blue link to reload and bright lights to flash as you are driving at night every time it reloads. It is a distraction from the road if you shut it off completel…
Read full complaint
The blue link on all older models is not being supported which cause the screen to become stuck on loading screen. This is a visibility and safety issue because it cause blue link to reload and bright lights to flash as you are driving at night every time it reloads. It is a distraction from the road if you shut it off completely you have no access to radio or sound. The issue it cannot be fixed unless you pay for manual update but you have to it working to actually get the update to run. There are many forums discussing the issue
I have a 2015 Hyundai Santa Fe sport and been having electrical issues at the fuse box
Vehicle has been consuming oil between oil changes. Recently the ABS, Down hill assist, and traction control lights came on. We took it to the dealer and were advised it was a wheel speed sensor in the passenger rear, but they wanted over $600 so we did not repair. Two days later all the lights went off and we had no issues. A…
Read full complaint
Vehicle has been consuming oil between oil changes. Recently the ABS, Down hill assist, and traction control lights came on. We took it to the dealer and were advised it was a wheel speed sensor in the passenger rear, but they wanted over $600 so we did not repair. Two days later all the lights went off and we had no issues. A month later I drove to Florida, checked and filled the oil with a little over one quart. On my way back the RPM shot up to close to 6K, the engine light started flashing, oil and battery light came on, and the car lost all power qnd started shuttering. There was a strong burning smell when we pulled over, that may it hard to breathe. As of writing this we were told it sounds like the engine has seized, but they are 5 months out on looking into it.
On August 2, 2023 I was driving my truck and it completely shut off on me on the highway. I push the start button to turn the engine and it just keep turning like it wanted to start, but it didn't. Called the tow truck to take it to the shop, to then get a call after two days saying that they couldn't find out what was going on,…
Read full complaint
On August 2, 2023 I was driving my truck and it completely shut off on me on the highway. I push the start button to turn the engine and it just keep turning like it wanted to start, but it didn't. Called the tow truck to take it to the shop, to then get a call after two days saying that they couldn't find out what was going on, because when they ran the test it didn't come back with any code. The clerk informed me that when he started my truck that next day, it cranked as if nothing was wrong. He drove it around about 15-20 minutes ,and it didn't do anything like what it had done the previous day before. I am very concerned because this could have been a bad outcome because I was in the highway on Wednesday. I need someone to further look into this matter.
During normal driving operations the car lost all power as our daughter and her 2 children were driving down the street. She called us and notified us that the car would barely run and that she had her hazard lights on and had no safe place to pull over. When she arrived back home from a few miles away the motor was making a ver…
Read full complaint
During normal driving operations the car lost all power as our daughter and her 2 children were driving down the street. She called us and notified us that the car would barely run and that she had her hazard lights on and had no safe place to pull over. When she arrived back home from a few miles away the motor was making a very loud knocking and tapping noise. I immediately checked the oil in the car which we have changed on a regular basis and very recently and to our disbelief there wasn't a drop of oil on the dipstick. No indicators or warning lights had come on to tell us the oil was low. We immediately called a local Hyundai dealership, and they explained that thousands of people have experienced consumption of oil with no obvious leaks causing catastrophic engine failure in Hyundais. Upon inspection from the dealership, it was determined that the motor had spun rod bearings due to excessive oil consumption. However, we have since discovered that the 2015 Hyundai Santa Fe is pending a class action lawsuit in California and no recall is current for this year and model. This could have caused serious and devastating fatalities to not only our family but others as well. Hyundai has not yet been willing to work with us for a car we purchased a little over a year ago and are still financing. The warranty did not transfer to a 2nd owner and we were not informed of this. Now the car sits at a dealership and I continue to make payments on a useless vehicle. The manufacturer of Hyundai's engine is the same for many models. However, not all models and years have had recalls yet. This puts thousands of people, like us, at risk for serious injuries, fatalities, and devastating financial loss. The public relies on their vehicles for their family's transportation and their jobs. I did my research and searched for this year, make, and model and found nothing that deterred me from finding this vehicle unsafe or unreliable. Hyundai is not in good faith protecting customers.
Engine suddenly went into limp mode and jerked steering while on the highway (engine light happened AFTER). We started about 60mph, then vehicle slowed to about 30mph in a few seconds. Almost crashed into a semi-truck trying to get my car under control, then almost caused a pileup collision behind a slow-moving traffic control v…
Read full complaint
Engine suddenly went into limp mode and jerked steering while on the highway (engine light happened AFTER). We started about 60mph, then vehicle slowed to about 30mph in a few seconds. Almost crashed into a semi-truck trying to get my car under control, then almost caused a pileup collision behind a slow-moving traffic control vehicle. Limped into town. Engine was rattling. Found the engine to be very hot under the hood. Found oil dripping underneath (research says certain Hyundai Santa Fe were recalled for this issue). Oil was low, even though I had it topped off less than a week before. It seems this may be related to large oil use resulting in engine overheat. Mechanic later disclosed to me there was oil buildup underneath and in the engine. Towed into another city to get available mechanic. Found error code P1326. Mechanic took a couple days to determine it was NOT caused by faulty sensor. (attached invoice) Towed to another city where I could have it taken into the lot (there is a long backload of cases at Hyundai). I saw about a dozen of the exact same model as my car in the service lot waiting repair (and many similar models). Told by dealership it would take 2 months to repair and there would be a diagnosis fee. This shouldn't have happened to my car. It was relatively new and low miles for an engine failure. The result was an expensive series of expenses and extremely dangerous series of near-collisions. It has been difficult to contact and navigate Hyundai corporate for help with this. They seem to have a lot of backlogs of these problems related to my model. I get put on hold for long periods. I was assigned case number and case manager who hasn't contacted me yet. I am still without a car as of today.
My vehicle was taken from my residence due to the individual being able to take apart my steering wheel column and starting my vehicle. This is very alarming to know that my vehicle can be stolen anytime with this trick that is being shown all over social media and the news channels.
The car was parked for about 4 hours and suddenly catches fire and reports says it was ABS anti brake system and i got my car burnt. Is there any help Hyundai can assist me.
Official recalls
223V651000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Sep 22, 2023
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
17V358000 · Latches/locks/linkages:hood:latch
Jun 5, 2017
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Consequence & remedy
Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.