Power Train. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

8 crash reports6 fire reports6 injury reports

Unknown Or Other complaints

22 reports

Clear category filter

Mileage unknown · Oct 26, 2023

Electrical SystemUnknown Or OtherFire

Read full complaint

My 2010 Hyundai Sante Fe caught fire on 9/27/23 while I was operating the vehicle and this fire ultimately caused my electrical systems to overheat and the wiring to melt. There was no indication that my alternator was about to fail (no battery light on my dash, no issues with starting my car) and I regularly maintenance my car with oil changes, tire rotations, and I redid my whole brake system in August 2023. My safety, the safety of my passenger, as well as the safety of ALL the patrons in the building that sat above the parking garage I was located in when the fire was burning were put at risk by this incident. My passenger acted quickly enough to put out the fire before anything more serious occurred, however according to my insurance we didn't let the fire burn long enough for there to be damage... even though my electrical harness is melted from it overheating due to the fire... The dealership/insurance have inspected my vehicle and say that the fire occurred because the alternator shorted out/failed however I believe this is false and Hyundai is covering their butts. When alternators fail the car doesn't just burst into flames, typically the car just fails to turn on since the alternator is no longer charging the battery... at least that's what I've read and heard from friends that are mechanics. Hyundai and Kia have been plagued by fire problems since 2015. The Center for Auto Safety successfully petitioned U.S. regulators to seek recalls in 2018 and says that the automakers have recalled more than 9.2 million vehicles for fires and engine problems. More than two dozen of the recalls involved over 20 models from the 2006 through 2021 model years and ALL are for fire risk. This is a KNOWN issue with Hyundai cars in general. My thought is that the same issues that are listed in the most recent Hyundai recall for the Sante Fe's from 2011-2015 is what occurred in my vehicle but Hyundai is refusing to take ownership of the issue.

NHTSA ODI #11551974

Mileage unknown · Jul 13, 2023

Air BagsSeat BeltsUnknown Or Other

Read full complaint

I am the original owner of a 2010 Hyundai Santa Fe. It currently has less than 100,000 miles on it as I drive it infrequently. On June 12, 2023, my airbag light lit on the display and has since remained. I immediately contacted the local Hyundai dealership and made the next available appointment. I was concerned because I had recently completed the Knock Sensor Detection System (KSDS) service campaign on 4/3/2023. Initially, I took my vehicle to an auto repair facility where a diagnostic test determined my SUV had a B1620 error code and was advised to take it to a Hyundai dealership. My Hyundai appointment was on 6/23/2023. I shared the information about the error code with the technicians. The dealership confirmed I had a B1620 error code where the Supplemental Restraint System Control Module (SRSCM) shorted out. I also showed the dealership employees an Extended Warranty Notification letter I received from Hyundai about faulty clock springs, but the dealer stated the module was completely separate and not part of the recall. The repair estimate was quite costly at around $2,600. From my understanding, the SRSCM controls all safety features. The dealership informed me the air bag light/error code means my entire safety system is completely disabled. This is not a mechanical issue but rather a safety red flag.

NHTSA ODI #11532175

Mileage unknown · Jan 25, 2022

Unknown Or Other

My paint is peeling on my SUV . The hood and side by my windshield along with the top by the sun roof

NHTSA ODI #11448867

Mileage unknown · Jun 14, 2021

Unknown Or Other

Read full complaint

The problem is that the vehicle sometimes hesitates to move forward, and then suddenly accelerates quickly and roughly. It happens when the vehicle is stopped as in traffic. It sometimes makes a clunking noice, it feels like someone hit me from behind. I have taken it to the dealership before a couple years ago, when this happened and they re-programmed it. It was fine for awhile then it happened again, so I took it to the dealership again, they did an inspection….they are saying now it needs a $1300 part, it will cost over $1600.

NHTSA ODI #11420925

120,000 miles · May 9, 2021

Electrical SystemUnknown Or Other

Read full complaint

THIS CAR HAS STALLED AT LEAST SIX TIMES IN THE PAST SIX MONTHS, USUALLY AS WE ARE DEACCELERATING AND IN A DOWNHILL POSITION (IE: DRIVING SLOWLY DOWN A MOUNTAIN, COMING TO A STOPLIGHT GOING DOWN A HILL, ETC.). IT HAS A NEW ENGINE AS OF SUMMER 2020. WE TOOK IT TO A LOCAL HYUNDAI DEALERSHIP AND THEY RAN A GENERAL DIAGNOSTICS CHECK-UP WITH NO RESULTS. WE HAVE SEARCHED THIS PROBLEM ONLINE FOR A SOLUTION AND SEE MANY OTHERS REPORTING SIMILAR STALLING CONCERNS, BUT WHEN WE PUT OUR VIN INTO THE RECALL SYSTEM, THERE ARE NO RECALLS AFFILIATED WITH THIS CAR. THE CAR DRIVES GREAT OTHERWISE, BUT THE STALLING IS VERY CONCERNING.

NHTSA ODI #11415740

Mileage unknown · Feb 3, 2021

Unknown Or Other

Read full complaint

THIS VEHICLE DOES NOT MEET WITH THE FOLLOWING US FEDERAL MOTOR VEHICLE SAFETY STANDARDS (FMVSS) AND REGULATIONS [DOT] I NEED TO REGISTER AND TAG MY VEHICLE HERE IN ORLANDO FLORIDA I GOT HYUNDAI AUTO CANADA CERTIFIES THAT THE ABOVE NOTED VEHICLE, 2010 SANTA FE GT 2.4 LITRE DOHC, WAS MANUFACTURED FOR RETAIL SALE IN CANADA AND COMPLIED WITH ALL CANADIAN MOTOR VEHICLE SAFETY STANDARDS (CMVSS) AND CANADIAN EMISSIONS STANDARDS APPLICABLE AS OF THE DATE OF MANUFACTURE. THIS VEHICLE DOES NOT MEET WITH THE FOLLOWING US FEDERAL MOTOR VEHICLE SAFETY STANDARDS (FMVSS) AND REGULATIONS: I HOPE YOU CAN HELP ON THIS OR RECOMMEND ME TO SOMEONE WHO CAN PLEASE, THANK YOU [XXX] MY EMAIL IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #11394489

180 miles · Nov 21, 2020

Unknown Or Other

Read full complaint

WHENEVER I LOOK UP THE RECALLS MY ENGINE TYPE HAS RECALLS BUT EVERY SYSTEM SAYS NONE FOR MY VIN. I THINK IT'S BECAUSE I HAVE AWD/4WD. HOWEVER, EVERYTHING ELSE IS THE SAME. I HAD TO REPLACE THE CATALYTIC CONVERTER, THE DEALER SAID AT THE TIME THEY WERE REPLACING THEM FOR 2WD. NOT MINE $2000. NOW THERE ARE TRANSMISSION ISSUES THAT WILL BE COVERED FOR 2WD WITH THE SAME ENGINE TYPE I HAVE BUT NOT MINE. BECAUSE I HAVE 4WD THIS IS NOT RIGHT I'M HAVING ALL THE SAME ISSUES. CAN YOUR AGENCY GET THEN TO ADD MY VIN# OR 4WD TO THE LIST? WITH THE CATALYTIC CONVERTER MY CAR WOULD JERK WHEN I TRIED TO ACCELERATE. MOST OF THE TIME IT WOULDN'T SPEED UP IT WOULD JUST JERK. WITH THE TRANSMISSION I STOPPED GOING UP THE FREEWAY ENTRANCE RAMP ON I10 HEADED EAST. THE CAR WAS SLUGGISH BARELY MOVING. I WAS BARELY ABLE TO GET TO THE SIDE, HALF MY CAR OUT IN THE WAY. IT HAS NOT MOVED SINCE. IT WON'T DRIVE FORWARD OR BACKWARD. THE TOW MAN ONLY NEUTRAL WORKS. HE PUSHED IT INTO A PARKING SPOT AFTER IT WAS TOWED. I HAD A MECHANIC COME TO LOOK AT IT. HE SAID TRANSMISSION ISSUES. ALSO, THE ELECTRIC IS CRAZY THE KEY CLICKER AND THE DOOR LOCKS, WORK WHEN IT WANTS TO.

NHTSA ODI #11375698

10 miles · Feb 29, 2020

Unknown Or Other

Read full complaint

IN APRIL 2019 THE SUNROOF OF MY 2010 HYUNDAI SANTA FE FLEW OFF. REPLACED AFTER $500 INSURANCE DEDUCTIBLE. ON FEBRUARY 21, 2020 WHILE TRAVELING AT AROUND 65 MILES AN HOUR ON I75 NORTH, THE SAME INCIDENT OCCURRED ON OUR 2010 HYUNDAI SONATA. TODAY I SUBMITTED A SEPARATE COMPLAINT FOR THE SONATA. COMPLAINT 11312271. I DECIDED TO FILE BOTH COMPLAINTS TODAY ON BOTH VEHICLES DUE TO THE FACT THAT COULD HAVE CAUSED SERIOUS ACCIDENTS ON THE HIGHWAY AND SOMEONE COULD GET SERIOUSLY HURT.

NHTSA ODI #11312274

Mileage unknown · Aug 24, 2019

Unknown Or Other

I HAVE BOUGHT ALL MY PARTS NEW AND MY CAR KEEP SHUTTING OFF WHILE IM DRIVING.ON THE ROAD I CAN BE IN TRAFFIC AND IT SHUTS OFF OR AT THE LIGHT AND IT DO THE SAME THING OR I CAN DRIVE LIKE 10 SECONDS IT SHUTS OFF.

NHTSA ODI #11246194

Mileage unknown · Mar 27, 2019

SuspensionUnknown Or OtherWheels

Read full complaint

I'VE HAD THE BRAKES REPLACED, ALIGNMENT DONE, ROTORS CHECKED, AND IT STILL SHAKES LIKE SOMETHING ISN'T RIGHT, AND IT'S SCARING ME, I'M HANDICAP, AND I FEEL LIKE MY FRONT END IS GONNA COME APART OR MY CAR IS GONNA FLIP, WHEN I'M DRIVING DOWN THE ROAD IT'S DOING JUST FINE BUT WHEN I GO TO PRESS ON MY BRAKES TO SLOW DOWN MY CAR IS SHAKING LIKE I'M GOING THROUGH AN EARTHQUAKE OR TORNADO, AND IT ALSO SEEMS TO HAVE THIS PROBLEM LIKE WHEN YOU PUSH PUSH THE GAS TO GET SPEED SO YOU COULD JUMP ON THE HIGHWAY IT LIKE JERKS A LITTLE BETTER SHE IS A LITTLE HARD TO BE ABLE TO CATCH UP AND IT'S NEVER DONE THAT BEFORE

NHTSA ODI #11192079

Official recalls

13V113000 · Exterior Lighting:brake Lights:switch

Apr 1, 2013

Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.

Consequence & remedy

Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.

11V261000 · Power Train:driveline:driveshaft

Apr 28, 2011

HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2010 SANTA FE 2WD VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND 2.4L ENGINES MANUFACTURED FROM OCTOBER 15, 2009 THROUGH MARCH 5, 2010. THE INTERMEDIATE SHAFT MAY SUFFER FROM NOISE AND EXCESSIVE WEAR DUE TO A MISALIGNMENT OF THE INTERMEDIATE SHAFT WITH THE RIGHT SIDE OUTPUT GEAR. CONTINUING TO DRIVE THE VEHICLE IN THIS CONDITION LEADS TO THE DEVELOPMENT OF A WHIRRING/WHINING NOISE AND CAN EVENTUALLY CAUSE DAMAGE TO THE AUTOMATIC TRANSMISSION.

Consequence & remedy

Consequence: DAMAGE TO THE TRANSMISSION MAY CAUSE LOSS OF MOTIVE POWER, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE RIGHT SIDE OUTPUT GEAR AND INTERMEDIATE SHAFT FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP21003 · Throttle Control System Vulnerabilities

Opened Nov 12, 2021 · Closed Jun 20, 2023

Status: closed (inferred from source dates) · Vehicle Speed Control:throttle

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.

PE11010 · Transmission Intermediate Driveshaft

Opened Apr 7, 2011 · Closed May 10, 2011

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:driveline:driveshaft

On April 25, 2011, Kia Motors Corporation submitted a defect notification letter to NHTSA regarding a transmission intermediate driveshaft condition in approximately 12,690 model year (MY) 2011 Kia Sorento 2-wheel drive vehicles equipped with automatic transmissions and 2.4L engines (NHTSA Recall No. 11V-258).The recall addresses a defect with the external shape of the engine block which can prevent the intermediate shaft bearing bracket from mating evenly with the engine block.This can cause a misalignment of the intermediate shaft with the right side output gear.Resulting damage could cause a loss of motive power.Additionally, on April 27, 2011, Hyundai Motor Company submitted a defect notification (NHTSA Recall No. 11V-261) for the same issue in approximately 6,169 MY 2010 Sante Fe 2-wheel drive vehicles equipped with automatic transmissions and 2.4L engines that use the same components as the recalled Kia Sorento vehicles.This investigation is closed.

Additional source detail variants (4)

Power Train:automatic Transmission

Power Train:driveline:driveshaft