Engine. Review the 196 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports8 fire reports3 injury reports

Service Brakes complaints

13 reports

Clear category filter

Mileage unknown · Feb 12, 2022

Electrical SystemService Brakes

RECALL ON ENGINE COMPARTMENT , SERVICE BRAKES HYDRAULIC,

NHTSA ODI #11451654

135 miles · Jun 22, 2019

Service BrakesCrash

I SUBMITTED A COMPLAINT ON JUNE 11, #11219391 BUT HAVE RECEIVED NO RESPONSE, AND IT DOES NOT SHOW AS A FILED COMPLAINT. PLEASE ADVISE THE STATUS OF THIS COMPLAINT. THANKS

NHTSA ODI #11221829

125 miles · Jun 11, 2019

Service BrakesCrash

Read full complaint

I RENTED THE VEHICLE FROM ENTERPRISE RENT A CAR ON MAY 28. IT SEEMED TO RUN FINE THEN AND ON THE MORNING OF MAY 29. BUT ABOUT 3.45P.M. I WAS DRIVING ON CITY STREETS IN ARCADIA TO MY DOCTOR'S APPOINTMENT WHEN I SAW A CAR AHEAD OF ME SUDDENLY PUT ON ITS BRAKE LIGHTS. I PRESSED MY BRAKES, BUT MY CAR DID NOT SLOW. I HAD TO SWERVE AROUND THE CAR AHEAD OF ME. SHORTLY THEREAFTER, THE BRAKES STARTED WORKING AGAIN. AT THE NEXT TRAFFIC LIGHT, I MADE A LEFT BEHIND ANOTHER CAR. AT THE NEXT TRAFFIC LIGHT, I WAS GOING TO MAKE A RIGHT BEHIND THE CAR AHEAD OF ME. IT WAS STOPPED AT A RED LIGHT. I WAS ABOUT 50 YARDS AWAY, WHEN I PRESSED ON MY BRAKES, BUT THE CAR DID NOT SLOW. I PRESSED AS HARD AS I COULD, BUT THE CAR KEPT GOING AND GOING AND REAR-ENDED THE CAR IN FRONT OF ME. IT THEN JUMPED BACK AND HIT THE OTHER CAR AGAIN. IT WAS A FRIGHTENING EXPERIENCE. TO THE BEST OF MY RECOLLECTION, I HAVE NOT CAUSED A TRAFFIC ACCIDENT IN MORE THAN 30 YEARS. THE OTHER DRIVER AND I PULLED OVER AND EXCHANGED INFORMATION. BADLY SHAKEN, I DROVE TO MY DOCTOR'S OFFICE AND TOLD HIM ABOUT IT. UPON LEAVING HIS OFFICE, I WAS DRIVING SLOWLY IN HIS PARKING LOT BECAUSE OF THE BRAKES,, BUT THE BRAKES WOULD NOT WORK AGAIN. THIS TERRIFIED ME AS THE TRAFFIC ON THE ROAD AHEAD WAS FULL OF CARS. AS I WENT OVER A SPEED BUMP, THE BRAKES CAME BACK ON. I DROVE HOME AT ABOUT 15 MPH, AND ABOUT 100 YARDS BEHIND ANY OTHER CAR. I WAS VERY AFRAID. I PARKED MY CAR AT HOME. THE NEXT DAY, I CALLED ENTERPRISE TO HAVE THEM TOW THE CAR AWAY. AAA CAME AND DID THAT ON MAY 30.

NHTSA ODI #11219391

Official recalls

22V810000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Oct 27, 2022

Hyundai Motor America (Hyundai) is recalling certain 2018 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire while parked or driving.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, free of charge. Owner notification letters were mailed November 16, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 237. This recall is an expansion of recall 22V-056.

22V056000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Feb 3, 2022

Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.

17V801000 · Air Bags:side/window

Dec 13, 2017

Hyundai Motor America (Hyundai) is recalling certain 2018 Santa Fe Sport vehicles. The side curtain air bags on these vehicles have a component that may detach during deployment of the inflatable curtain air bag.

Consequence & remedy

Consequence: If the component detaches during deployment, the curtain air bag may not inflate properly during a crash, increasing the risk of injury. Additionally, if the detached component were to enter the vehicle occupant compartment, there could be an increased risk of occupant injury.

Remedy: Hyundai will notify owners, and dealers will replace the driver and passenger side curtain air bags, free of charge. The recall is expected to begin February 9, 2018. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 171.

17V577000 · Suspension:front:springs:coil Springs

Sep 20, 2017

Hyundai Motor America (Hyundai) is recalling certain 2018 Santa Fe Sport vehicles. The front coil springs may have been improperly manufactured and, as a result, may fracture under certain loads while driving.

Consequence & remedy

Consequence: If the coil spring fractures, it can puncture the tire, causing a loss of vehicle control and increasing the risk of a crash.

Remedy: All of the affected vehicles are currently unsold on dealer lots. Dealers will replace both front coil springs, free of charge prior to the vehicle's sale. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 167.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.