2017 Hyundai Santa Fe Sport

The contact owns a 2017 Hyundai Santa Fe Sport. The contact stated that while driving approximately 35 MPH a loud noise and smoke was suddenly present coming from under the hood of the vehicle and the engine stalled. The vehicle was towed back to the home. The contact indicated that during the failure no warning messages or lights had displayed. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet contacted. The VIN was not available. The failure mileage was 83,000.

am filing a formal complaint regarding an official software update provided by Hyundai that completely corrupted the infotainment/head unit system in my 2017 Hyundai Santa Fe Sport. I purchased this vehicle from CarMax less than three weeks ago. The vehicle came equipped with Hyundai Blue Link, so I contacted Hyundai support to activate the service by pressing the Blue Link button inside the vehicle. Hyundai informed me that my vehicle required a software update because the current system did not contain the necessary software for Blue Link to function properly. A Hyundai representative directed me to Hyundai’s official update website and provided instructions for completing the update. Following Hyundai’s instructions exactly, I purchased and formatted a USB drive, downloaded the update using my VIN from Hyundai’s official website, properly extracted the files, and installed the update into the vehicle. During the installation process, the update failed and corrupted the head unit system. The display now continuously shows “Update Unsuccessful” with Error Code 106. Since the failed Hyundai update, multiple vehicle systems no longer function properly, including the backup camera, Bluetooth, hands-free calling, Blind Spot functionality, radio, map/display system, automatic headlights, and automatic radio shutoff when opening the driver door. I now have to manually operate systems that previously worked automatically. I contacted Hyundai customer support multiple times and was repeatedly transferred between departments. I was incorrectly referred to navigation support even though my vehicle has a non-navigation system. Navigation support confirmed this was a Hyundai issue and stated they could not assist. When I contacted Hyundai again, I explained every step I followed, and the representative acknowledged that I appeared to have completed the update process correctly. Despite Hyundai’s official software causing this failure

I was driving on a main road at 55-60 mph with my daughter and grandchildren in the car and had a sudden loss of power. I was almost hit from behind. The check engine light started blinking. And the car went into limp mode. I had to limp it to the nearest place to safely get off the road so as not to put my family in any other danger.There is not enough shoulder on the road to pull over safely. It was very stressful. Was able to get it in someone's driveway and then eventually towed to Auburn,NY Hyundai/Chevrolet where it is currently. It would not turn over to start again. It does have battery power. I am waiting to hear from the service techs as to what they think is wrong. They advised me that there is a $199 per hour diagnostic fee. I also told them that we noticed metal flakes in the oil when we checked it. I feel I should mention that the vehicle went into limp mode a few weeks ago also and the dealership told me the knock sensor was bad. I had that replaced at that time.

THIS IS AN UPDATE TO EXISTING NHTSA ODI COMPLAINT #11735718 2017 Hyundai Santa Fe Sport, TXXI Theta II engine defect. UPDATE: On May 7, 2026, Hyundai Case Manager acknowledged in writing "Your case is important to us" and "2.4L THETA concerns" for Case #42623761. This is written admission the vehicle has the TXXI defect covered by warranty extension to 120,000 miles. I gave Hyundai 48 hours to provide written authorization for oil consumption test per their TSB 22-EM-003H. After 3 days they are silent. They refuse email communication despite documented language barrier. Current Vehicle Status: - Active DTC P0010 causing loss of power and stalling risk - Oil Consumption: 1 liter per 600km, which is 3x Hyundai failure threshold in TSB 22-EM-003H - 95,772 miles, under TXXI 120,000 mile warranty limit - U.S. Spec vehicle covered by TXXI Warranty Extension Hyundai is violating Magnuson-Moss Warranty Act by refusing to honor written warranty for known safety defect. The P0010 defect causes sudden loss of power while driving. Requesting immediate NHTSA intervention to compel Hyundai to perform warranty repair.

COMPONENT FAILED: Theta II 2.4L GDI engine connecting rod bearings. Vehicle has 95,000 miles. Engine available for inspection in [XXX] . SAFETY RISK: Engine knock + limp mode at 1500 RPM caused sudden loss of power on highway. Oil consumption 1L/700km risks catastrophic engine seizure while driving. CONFIRMED BY DEALER: Independent service center confirmed DTC P0010 from metal debris. Hyundai Motor America Case #42623761 confirmed recall coverage but refuses remedy. INSPECTION: Manufacturer aware via Case #42623761. Local Hyundai dealers non-responsive. No police/insurance inspection. WARNING SYMPTOMS: Engine knock started at ~94,000 miles. Check Engine Light with DTC P0010. Progressive oil consumption. Limp mode activated at 95,000 miles. HYUNDAI VIOLATION: Hyundai confirmed via email they refuse to honor Safety Recall 162 / Service Campaign 966 Lifetime Warranty for VIN [XXX] despite all symptoms matching recall description. Request NHTSA compel Hyundai to authorize Bearing Clearance Test and engine replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My ABS Lights the triangle with the ! In the middle goes in and off the down hill control light and the sweet control light all go on when the ABS light goes on my oil was completely dry had to add two quarts while the engine was ticking when started and when accelerating it was making a clicking noise I still had 3000 miles before needed an oil change but like I said it was bone dry and then the drivers seat was going back and not wanting to come back up I’ve only had the car 42 days and it’s having all kinds of problems

The vehicle is experiencing a massive paint adhesion failure (white pearl paint), which is peeling off in large sheets from the hood and roof. This is a severe manufacturing defect. At highway speeds, paint flakes fly off, posing a significant safety hazard to other drivers and obstructing visibility. Furthermore, the exposed metal is prone to rapid corrosion, which compromises the structural integrity of the body panels. Despite contacting Hyundai Motor America (Case #XXX), the manufacturer has refused to provide a timely resolution or cover the repair cost of $4,650, as estimated by an authorized dealer." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Abs, traction control lights, emergency braking lights on .. tire sensors are bad. Causing intermittent issue with the lights. For 3 years I've been trying to get my ABS/traction control fixed at Hyundai, that dealership refused to acknowledge there was an issue. I had a code from a car place since I live over an hour away and they said they couldn't use it since it wasn't from them. I have an extended warranty there. Went to another dealership and was immediately told it was the tire sensors. That he used to work at the other dealership and they saw it all the time. I now see Palisades have a tire sensor issue. Heck I've been dealing with this for years, and apparently so are many other Hyundai owners, according to this Hyundai employee. Now they're trying to overcharge me and saying my warranty will only cover a quarter of what they want. My deductible is only 100 if I don't get the work done at the original place, the one that said there isn't a problem. I've had it with Hyundai. They are unsafe and don't care about customer service.