2017 Hyundai Santa Fe Sport

Following the completion of an official emissions recall software upgrade at Fitzgerald Auto Mall Countryside, Clearwater Florida, my 2017 Hyundai Santa Fe Sport (52,000 miles) now suffers from a severe loss of motive power and erratic transmission shifting/jerking during cold starts throughout day. The vehicle continues to hesitate during cold starts, making it impossible to safely accelerate from a stop into incoming traffic. I returned to dealership on 5/29/26 to address continued driving issues. The servicing dealership states they don't have a software fix and offer no mechanical fix. The dealership states they received an internal memo from Hyundai Corporate which instructed the dealership to tell affected owners to idle the vehicle for 1-3 minutes before driving to allow system adjustments. Forcing a consumer to wait out a dangerous powertrain defect in a running vehicle to avoid a roadway acceleration/loss accident is an unacceptable safety hazard. The manufacturers recall update has actively compromised the safe operation and motive control of this vehicle.

After the ECM recall for a software update the car would not run correctly. It jerks and and runs rough. It almost stalls when you put your foot on the gas. I took it back to the dealer and they can not get the problem to duplicate. Noone else has looked at the problem. There were never any problems with the care until the recall. The problem occurred the day I brought the car home from the ECM update.

Hello, I was driving home from work with my six-month old in the car and the engine stalled while on the Belleville Turnpike. It seized and I was almost rear-ended by a tractor trailer hauling lumber to the lumber yard just a few streets away. I couldn't move the car and was afraid of how to even attempt to secure my car as my daughter was strapped in her car seat. An extremely nice man pulled over and began to flag vehicle to go around me. By this time, I had only my hazard lights on. I was frightened beyond belief having gone through that experience. The car was towed to the dealership who confirmed it was catastrophic engine failure(misfire of a cylinder). They stated initially with my 3rd party warrant that it would be covered and in their words " it was a good thing I had a warranty". Fast forward to two weeks after I check to see what is going on. Things have changed. Now, because I am missing one oil change receipt, they need to be paid $1400, to further corroborate the cause of the engine failure. I haven't paid and honestly don't plan on paying them anything. To date, I have spent over $2,000 on car rental fees since my car is now sitting at the Global Hyundai Dealership.

I was driving on a main road at 55-60 mph with my daughter and grandchildren in the car and had a sudden loss of power. I was almost hit from behind. The check engine light started blinking. And the car went into limp mode. I had to limp it to the nearest place to safely get off the road so as not to put my family in any other danger.There is not enough shoulder on the road to pull over safely. It was very stressful. Was able to get it in someone's driveway and then eventually towed to Auburn,NY Hyundai/Chevrolet where it is currently. It would not turn over to start again. It does have battery power. I am waiting to hear from the service techs as to what they think is wrong. They advised me that there is a $199 per hour diagnostic fee. I also told them that we noticed metal flakes in the oil when we checked it. I feel I should mention that the vehicle went into limp mode a few weeks ago also and the dealership told me the knock sensor was bad. I had that replaced at that time.

THIS IS AN UPDATE TO EXISTING NHTSA ODI COMPLAINT #11735718 2017 Hyundai Santa Fe Sport, TXXI Theta II engine defect. UPDATE: On May 7, 2026, Hyundai Case Manager acknowledged in writing "Your case is important to us" and "2.4L THETA concerns" for Case #42623761. This is written admission the vehicle has the TXXI defect covered by warranty extension to 120,000 miles. I gave Hyundai 48 hours to provide written authorization for oil consumption test per their TSB 22-EM-003H. After 3 days they are silent. They refuse email communication despite documented language barrier. Current Vehicle Status: - Active DTC P0010 causing loss of power and stalling risk - Oil Consumption: 1 liter per 600km, which is 3x Hyundai failure threshold in TSB 22-EM-003H - 95,772 miles, under TXXI 120,000 mile warranty limit - U.S. Spec vehicle covered by TXXI Warranty Extension Hyundai is violating Magnuson-Moss Warranty Act by refusing to honor written warranty for known safety defect. The P0010 defect causes sudden loss of power while driving. Requesting immediate NHTSA intervention to compel Hyundai to perform warranty repair.

COMPONENT FAILED: Theta II 2.4L GDI engine connecting rod bearings. Vehicle has 95,000 miles. Engine available for inspection in [XXX] . SAFETY RISK: Engine knock + limp mode at 1500 RPM caused sudden loss of power on highway. Oil consumption 1L/700km risks catastrophic engine seizure while driving. CONFIRMED BY DEALER: Independent service center confirmed DTC P0010 from metal debris. Hyundai Motor America Case #42623761 confirmed recall coverage but refuses remedy. INSPECTION: Manufacturer aware via Case #42623761. Local Hyundai dealers non-responsive. No police/insurance inspection. WARNING SYMPTOMS: Engine knock started at ~94,000 miles. Check Engine Light with DTC P0010. Progressive oil consumption. Limp mode activated at 95,000 miles. HYUNDAI VIOLATION: Hyundai confirmed via email they refuse to honor Safety Recall 162 / Service Campaign 966 Lifetime Warranty for VIN [XXX] despite all symptoms matching recall description. Request NHTSA compel Hyundai to authorize Bearing Clearance Test and engine replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My ABS Lights the triangle with the ! In the middle goes in and off the down hill control light and the sweet control light all go on when the ABS light goes on my oil was completely dry had to add two quarts while the engine was ticking when started and when accelerating it was making a clicking noise I still had 3000 miles before needed an oil change but like I said it was bone dry and then the drivers seat was going back and not wanting to come back up I’ve only had the car 42 days and it’s having all kinds of problems