2015 Hyundai Santa Fe Sport

The vehicle suffered a severe engine overheating failure that created an immediate fire risk and electrical safety signaling failure. A brand-new replacement engine was installed by an authorized dealership in April 2026 under a goodwill warranty and had only been driven ~ 3,100 miles since installation. While operating the vehicle, the air conditioning suddenly stopped functioning. Upon restarting, the check engine light illuminated; however, there was never any dashboard temperature warning indicator, notification, or chime to alert the driver to an active overheating situation. Shortly after, the engine completely disabled itself and died while in transit in a parking lot. AAA was contacted to tow the vehicle. Smoke was visible coming out of the engine's oil dipstick and oil intake spout before being towed. After being towed home, an overwhelming chemical burning odor was noted and continued to get worse. A physical check revealed that the oil level on the dipstick was critically overfilled a full inch above the maximum fill line. The local fire department responded to the scene to mitigate the thermal risk, ordered the battery disconnected due to safety hazards, and deemed the vehicle entirely unsafe to operate or connect to power. This represents a catastrophic failure of critical safety equipment and onboard driver warning networks on a newly installed engine assembly, presenting an active safety and fire hazard to passengers. An official corporate safety case has been opened with Hyundai Motor America under Case Number: 43112676.

For a few months- the ABS light, Downhill assist light, and Slippery road light have all been on. Read it could be due to a bad sensor. Then on Saturday July 4th, I turned the car on and the Ebrake light was on but my ebrake was NOT initiated. Car was making a low humming noise on front passenger side of vehicle as well. I read the ebrake light could come on due to low brake fluid, so I wanted to drive it around the block to further try and diagnose the issue. My car then made a pop noise and started smoking from where the ABS pump is located and my tail lights all started flickering like Christmas lights. I instantly turned the car off and disconnected the battery to prevent an electrical fire. UPON researching- there is a recall for 2015 Santa Fe’s for this exact issue except mine isn’t on the list. I need to talk to someone who has seniority upon this situation because I have called Hyundai Customer service and my local dealership and nothing is being done or nobody cares to resolve this situation. My car is currently at a trusted local garage awaiting repair- I can not tow it back and forth between the garage and a dealership. I rely on my car for my children and work.. I can’t play around waiting for them to inspect it weeks from now. This is a serious issue as my children were also in the car. Everything is VERY similar to the recall on other 2015 Santa Fe’s..

FHW Garage used car dealer [XXX], sold this Hyundai Santa fe 2015 knowing the vehicle is defective. It Stalls and stops in the middle of the road in High Traffic. This Hyundai Santa Fe 2015 Lock up the Steering Wheel, Lock up the breaks, Lock up the gas. it Stalls and stops without Warning then after it freeze and stop it flashes all of the Warning Lights on the dash board. FHW Garage is Falsely Advertising this vehicle in Excellent Condition. Its Advertised on Craigs List, and [XXX]. I was almost in a Serious Accident. [XXX] keeps getting his people in the workshop to Machanically Rig the Vehicle to run and drive until someone gets killed when this vehicle is in a terrible Accident. The Gas Cap dont screw on properly. Fhw Garage [XXX] sold me this Vehicle with full knowlege of the Mechanical Defects, and refuses to give my money back. I paid $5,400 Cash plus traded my car. The Hyundai Santa fe was $6,900. Deceptive Practices Fraud, and Title Jumping. FHW still have the two cars after I purchased them. I would like to see FHW Dealer License Suspended or Revoked. Give my money back and return my car. I will be filing a complaint Affidavit with the FLHSMV. [XXX] lied on the Bill of Sales how much I paid and he put $900 in his pocket. I will also file a complaint to FHW [XXX]. For defrauding me, Misrepresentation saying the Vehicle is in Excellent Condition when its Mechanically Defective, and Dangerous should not be on the road to kill someone. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Put in reverse to move backwards 5 feet or so the vehicle kept going and moving faster I applied the brake and hitting the brakes as well I didn't wonna hit the parked cars behind me so I put in park thinking that will also help stop the vehicle nothing worked it only stopped after hitting my other car that was parked on the street I tried everything to stop it it just took off I came out a beautiful morning to change the radiator it was dripping from the bottom I purchased a new one I put the car front wheels on ramps to look underneath to see what sockets I needed I got in vehicle just to lower off ramps backing down slow foot covering brake once the car touch ground it accelerated not fast but wouldn't stop it happened so fast but I applied the emergency brake its moving faster applying the brake as well im looking in the mirror at wants behind me as well I put in park thinking that would stop the vehicle but it was accelerating didnt stop until it hit the car parked on the street that's also mine it was dangerous and scary and im thankful it wasnt a tragedy normally my grandkids would be playing out there i could killed them I cant stop thinking about the what could been driving 42 years I consider myself a good driver defensive driving course never had a chargeable accident drove professional also for 32 years I did all I could think of in that little bit of time it just accelerated again backing tapping brakes 2 or 3 times coming down off ramps front maybe 4 or 5 inches off ground lowering to ground it take off something worth looking into thank you last thing my wife was coming to bring me a flashlight the fence hit her 30 more seconds she probably would been hit or killed so this is really affecting me

I am writing to express my concern regarding an ongoing and persistent issue with excessive engine oil consumption in my 2015 Hyundai Santa Fe, Subject: Severe Oil Consumption Issue - 2015 Hyundai Santa Fe - VIN: [XXX] The vehicle consumes an alarming amount of oil, approximately 1 quart every 300 miles. This rate of consumption is far beyond what is considered normal and strongly suggests a serious mechanical or manufacturing defect. I have already taken the vehicle to a mechanic to diagnose and attempt to resolve this problem. Based on their professional advice, the following parts were recently replaced: 1.Engine Valve Cover Gasket 2.Turbo Charger Oil Line 3.Spark Plugs Unfortunately, despite these repairs, the issue of excessive oil consumption remains unresolved. The rate of oil loss remains consistent and dangerously high. This was first informed by a service center when I took the car for a random check. Then, after traveling 1,000 miles, the engine oil level dropped again. After that, I am keeping an eye on that. This level of oil consumption poses a significant risk to the engine's long-term health and reliability, and it is a major inconvenience and expense for me as the owner. I am deeply concerned that a major engine component may be failing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I bought the 2015 Hyundai Santa Fe yesterday evening. Upon leaving the dealership I promptly broke for a car in front of me. Immediately the vehicle turned off completely. I put the vehicle in the park and attempted to start the vehicle back up. The vehicle would not start up and begin leaking a prominent scent. Following this, white smoke with the same pungent smell was coming from the engine. I propped the hood and saw the smoke continue to release. I then motioned away from the vehicle and called for a tow truck. The car is now being inspected by the dealership I purchased it from the same day. I believe this is related to the NHTSA recall on 2010-2015 Hyundai Santa Fe, recall date 09/22/2023, recall number 21V303000, and Hyundai Safety Recall 251s Anti-Lock Braking System Fuse Replace. This issue is not listed under my vehicle VIN number but it’s apparent to be the case and issue and is being inspected further by the dealership.

WE WERE ON A TRIP FROM NEBRASKA TO MICHIGAN AND RETURN. WHEN TRAVELING ALONG THE TOLL ROAD EXPRESS SOUTH OF CHICAGO AT ABOUT 65MPH 02/1WE BOTH SMELLED "SOMETHING BURNING". DETERMINING THAT IT WAS NOT ANYTHING ON THE INTERIOR, WE CLOSED THE OUTSIDE AIR VENT CONTROL AND FELT THAT IT WAS KIND OF A HOT ELECTRICAL WIRE BURNING SMELL COMING FROM THE ENGINE COMPARTMENT. WHEN WE COULD FINALLY EXIT THE EXPRESSWAY WE TRIED TO SMELL AROUND THE FRONT WHEEL WELLS AND THE ODOR SEEMED TO HAVE GONE AWAY. WE ATE LUNCH, LET THE CAR SIT FOR 45 MINUTES AND DROVE ON, NOT SMELLING THAT AGAIN. THE "BURNING ODOR" WAS PRESENT FOR 5-8 MINUTES.