While accelerating at a light, the accelerator became unresponsive, only propelling the vehicle a couple miles per hour. I was not able to pull over, as I was in the left lane of a very busy road. After about 15 seconds of lack of acceleration, the accelerator responded enough for me to pull over. I’m glad this incident did not …
Read full complaint
While accelerating at a light, the accelerator became unresponsive, only propelling the vehicle a couple miles per hour. I was not able to pull over, as I was in the left lane of a very busy road. After about 15 seconds of lack of acceleration, the accelerator responded enough for me to pull over. I’m glad this incident did not occur on a highway, during a turn, or other hazardous situations. Dash displayed, “Check hybrid system. Pull over safely”. There was no indication or issue with the vehicle prior to this. I haven’t had any issues since I bought it several months ago. I’ve read reports of this same issue happening with this same model. I have a scheduled date for inspection.
NHTSA ODI #11708867
Mileage unknown · Mar 23, 2025
Electrical SystemPower TrainUnknown Or Other
vehicle will not change out of EV electric mode and return to gas power causing hybrid battery drains to zero, vehicle loses acceleration, you can push the gas pedal to the floor and you have no acceleration, very UNSAFE when you are in traffic, no power to maneuver or avoid other vehicles quickly if needed, potential for accid…
Read full complaint
vehicle will not change out of EV electric mode and return to gas power causing hybrid battery drains to zero, vehicle loses acceleration, you can push the gas pedal to the floor and you have no acceleration, very UNSAFE when you are in traffic, no power to maneuver or avoid other vehicles quickly if needed, potential for accidents, hybrid system warning lights and alarms go on, have to try and pull over safely, battery will not recharge or takes a very long time to do so, only recourse is to shut vehicle off and restart which seems to reset vehicle, which in turn does not leave any warning lights other than codes on to show dealer, very dangerous to lose all acceleration capacity while in traffic, this has happened multiple times with the latest being today 3/23/25, vehicle is available for you to inspect, have had other powertrain codes issues as well, dealer has replaced fuel pump and erg valve but it does not resolve this hybrid issue, this battery drain issue has occurred multiple times but no resolution, help!
NHTSA ODI #11650017
Mileage unknown · Jan 15, 2025
Power TrainService BrakesUnknown Or Other
When pressing the accelerator from a full stop, the car would either not move at all, idle/roll forward, or unsteadily jerk forward. In addition, the car would brake while driving despite not applying any pressure to the brake pedal. This issue persisted regardless of "drive mode" and no cruise control was in use.
NHTSA ODI #11636018
Mileage unknown · Dec 26, 2024
Power TrainUnknown Or Other
On October 28, 2024 and again on November 26, 2024, a warning light appeared on the dash which said “ check hybrid system stop safely” Within 20 seconds both times , the car became inoperable . When I stepped on the gas nothing happened . The first time I was blocking major traffic , the second time I was on an interstate in th…
Read full complaint
On October 28, 2024 and again on November 26, 2024, a warning light appeared on the dash which said “ check hybrid system stop safely” Within 20 seconds both times , the car became inoperable . When I stepped on the gas nothing happened . The first time I was blocking major traffic , the second time I was on an interstate in the right lane and had time to pull over. In about 15 minutes the light went off and the car drove as normal. The dealer has had the car after both instances , currently for 28 days, and has not been able to replicate the problem .
NHTSA ODI #11632498
Mileage unknown · Jun 21, 2023
Forward Collision AvoidanceService BrakesUnknown Or Other
I was driving on the highway when my car all of a sudden started to beep and told me it was activating the emergency brake. I was driving safely and was not at risk of a collision. The car slowed slightly. Just as soon as the emergency brake warning popped up, it was gone. It was terrifying for the car to slow down while dri…
Read full complaint
I was driving on the highway when my car all of a sudden started to beep and told me it was activating the emergency brake. I was driving safely and was not at risk of a collision. The car slowed slightly. Just as soon as the emergency brake warning popped up, it was gone. It was terrifying for the car to slow down while driving 60 MPH on the highway.
NHTSA ODI #11528204
Mileage unknown · Mar 27, 2022
Unknown Or Other
Not even 500 miles on it and the transfer case/ power control unit went down. (It’s the thing that switches it from electric back to engine power.
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview image that does not display reduces the driver's visibility and increases the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed January 14, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 271.
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Hyundai Motor America (Hyundai) is recalling certain 2023 Genesis G80 Electric, 2021-2022 Santa Fe Hybrid, and 2022-2023 Santa Fe Plug-In Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioners may explode upon deployment.
Consequence & remedy
Consequence: An exploding seat belt pretensioner can project metal fragments into the vehicle, strike vehicle occupants, and result in injury.
Remedy: Dealers will secure the seat belt pretensioners with a cap, free of charge. Owner notification letters were mailed December 14, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 238/011G. This recall is an expansion of recall numbers 22V-354 and 22V-458.
Additional source detail variants (2)
Seat Belts:front
Hyundai Motor America (Hyundai) is recalling certain 2023 Genesis G80 Electric, 2021-2022 Santa Fe Hybrid, and 2022-2023 Santa Fe Plug-In Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioners may explode upon deployment.
Consequence: An exploding seat belt pretensioner can project metal fragments into the vehicle, strike vehicle occupants, and result in injury.
Remedy: Dealers will secure the seat belt pretensioners with a cap, free of charge. Owner notification letters were mailed December 14, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 238/011G. This recall is an expansion of recall numbers 22V-354 and 22V-458.
Seat Belts:pretensioner
Hyundai Motor America (Hyundai) is recalling certain 2023 Genesis G80 Electric, 2021-2022 Santa Fe Hybrid, and 2022-2023 Santa Fe Plug-In Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioners may explode upon deployment.
Consequence: An exploding seat belt pretensioner can project metal fragments into the vehicle, strike vehicle occupants, and result in injury.
Remedy: Dealers will secure the seat belt pretensioners with a cap, free of charge. Owner notification letters were mailed December 14, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 238/011G. This recall is an expansion of recall numbers 22V-354 and 22V-458.
Hyundai Motor America (Hyundai) is recalling certain 2022 Santa Fe HEV and Santa Fe PHEV vehicles. The instrument cluster liquid-crystal display (LCD) may invert the image on the screen upon vehicle startup, making the display illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Controls and Displays."
Consequence & remedy
Consequence: An illegible instrument cluster will not show information such as vehicle speed or safety system warnings, which can increase the risk of a crash.
Remedy: Dealers will replace the instrument cluster, free of charge. Owner notification letters were mailed February 23, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 217.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2022 Hyundai Santa Fe Hybrid Problems, Complaints & Recalls | Skip That Year
Illustration