← New search

2020 Hyundai Kona

Owner reports · Recalls · Investigations

More warning signs than most Kona years

Owner complaints for the 2020 Hyundai Kona are substantially higher than the model-year median of 74.

About this comparison →

When problems were reported

Mileage at the reported incident

47 reports with mileage · 111 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Engine. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

8 crash reports3 fire reports7 injury reports

Engine complaints

105 reports
Clear category filter
Mileage unknown · May 11, 2026
Engine

Engine light comes on starts flashing as well as the oil light occasionally. If you slow down or have to stop it completely shuts down you have to put in park and restart the car to get anywhere and start stopping in front in the middle of traffic. So if you slow down to go up a hill or anything, it just stops completely. Also m…

Read full complaint

Engine light comes on starts flashing as well as the oil light occasionally. If you slow down or have to stop it completely shuts down you have to put in park and restart the car to get anywhere and start stopping in front in the middle of traffic. So if you slow down to go up a hill or anything, it just stops completely. Also making a clicking or grinding sound not sure.

NHTSA ODI #11737100

Mileage unknown · Apr 17, 2026
Engine

On February 27, 2026, my 2020 Hyundai Kona (Recall 203) suffered a catastrophic engine stall while driving, requiring an emergency tow. The dealership (Rosen Hyundai) and Hyundai Motor America are refusing to perform the Safety Recall 203 remedy unless I first pay $4,715.26 for a timing repair. I was also required to pay $453.05…

Read full complaint

On February 27, 2026, my 2020 Hyundai Kona (Recall 203) suffered a catastrophic engine stall while driving, requiring an emergency tow. The dealership (Rosen Hyundai) and Hyundai Motor America are refusing to perform the Safety Recall 203 remedy unless I first pay $4,715.26 for a timing repair. I was also required to pay $453.05 for wiring repairs just to "enable" the recall test, yet the recall remains unaddressed because of a financial paywall. I am reporting an obstruction of a federal safety recall by the manufacturer.

NHTSA ODI #11731892

Mileage unknown · Apr 6, 2026
EngineUnknown Or Other

Basically normal driving the car stalled. It slowed to a stall. I had to restart the car. This has happened a couple to times.

NHTSA ODI #11729398

Mileage unknown · Mar 25, 2026
Engine

My car was taken in as a part of recall bulletin 203 for improperly heated piston rings treated pistons rings that result in premature engine failure and possible fire on 12/5/25. The knock sensor test was performed and the KSDS software was installed. On 3/12/26 my daughter who was on the way home from a trip called because h…

Read full complaint

My car was taken in as a part of recall bulletin 203 for improperly heated piston rings treated pistons rings that result in premature engine failure and possible fire on 12/5/25. The knock sensor test was performed and the KSDS software was installed. On 3/12/26 my daughter who was on the way home from a trip called because her checking engine light started flashing and the engine was knocking. We had it towed to Hyundai and they are denying service under the recall stating improper codes yet one of the codes is P1327 KSDS detection which is related to the rod bearing failure the car currently has. They are trying to make me pay $4600 out of pocket plus the tow bill when this is directly related to the recall.

NHTSA ODI #11727112

Mileage unknown · Mar 19, 2026
EnginePower TrainSteering

My 2020 Hyundai Kona (VIN: [XXX] ) has a persistent engine stalling safety defect that matches Recall 203 (22-01-042H, NHTSA Campaign 21V301000 – Nu 2.0L Atkinson Engine Inspection and Replacement). The recall addresses improperly heat-treated piston oil rings causing cylinder bore scuffing, accelerated oil consumption, abnormal…

Read full complaint

My 2020 Hyundai Kona (VIN: [XXX] ) has a persistent engine stalling safety defect that matches Recall 203 (22-01-042H, NHTSA Campaign 21V301000 – Nu 2.0L Atkinson Engine Inspection and Replacement). The recall addresses improperly heat-treated piston oil rings causing cylinder bore scuffing, accelerated oil consumption, abnormal knocking, and potential engine stall while driving (increasing crash/fire risk).I first brought the vehicle to Corona Hyundai for repeated stalling while driving. They performed the recall vibration inspection and software update (Campaign 974), stated the test passed, and declared the vehicle "fixed", safe and "good-to-go" Immediately after pickup, the stalling returned worse: approximately 60-80 miles later on XX near the XXX exit (four-lane high-speed highway), the engine completely stalled at 65 mph while merging for an exit. This caused vehicles and semi-trucks behind me to swerve dangerously and very nearly collide with me. The vehicle stalled four more times on the way to my destination in [XXX] .I then took it to the nearest dealer, Carlsbad Hyundai for safety reasons. They performed the vibration inspection again, which also "passed," yet the real-world symptoms would continue unchanged: accelerated oil consumption (I monitor the dipstick and refill regularly), sputtering, knocking noises, and complete engine stalls (dozens of incidents, especially on local roads and turns). The vehicle remains undrivable due to imminent stall risk while moving and putting myself, my passengers and other commuters at high risk of severe injury or death.Both dealers and Hyundai Customer Care (Case #XXX) have refused further action, stating the vibration test passed, they cannot duplicate the concern, and no additional claim can be submitted for engine replacement. Hyundai's TSB [XXX] requires only the vibration inspection; engine replacement is authorized if "NO PASS" – no separate oil consumption test or monitored drive INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.

NHTSA ODI #11725552

108,000 miles · Mar 11, 2026
Engine

The contact owns a 2020 Hyundai Kona. While the contact’s son was driving the vehicle on the highway at an undisclosed speed, there was a knocking sound coming from the engine and the vehicle failed to stop as intended. The gear shifter was shifted into neutral(N) and restarted; however, the engine failed shortly afterwards, and…

Read full complaint

The contact owns a 2020 Hyundai Kona. While the contact’s son was driving the vehicle on the highway at an undisclosed speed, there was a knocking sound coming from the engine and the vehicle failed to stop as intended. The gear shifter was shifted into neutral(N) and restarted; however, the engine failed shortly afterwards, and the vehicle was unable to restart. No warning lights were illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed with piston rings failure and low engine oil. The vehicle was not repaired. The manufacturer was notified of the failure, where it was confirmed that the VIN was included in NHTSA Campaign Number: 21V301000 (Engine); however, the recall repair was already performed. The approximate failure mileage was 108,000.

NHTSA ODI #11723633

Mileage unknown · Feb 3, 2026
Electrical SystemEngineForward Collision Avoidance

many times a year, without warning, vehicle dash lights turn off and light up like a christmas tree, followed by fca warning sound and lights going off, and a loud mechanical thud. Lose engine throttle going highway speeds. This can occur at nearly any speed without warning. Car must be powered off and back on to get normalcy. …

Read full complaint

many times a year, without warning, vehicle dash lights turn off and light up like a christmas tree, followed by fca warning sound and lights going off, and a loud mechanical thud. Lose engine throttle going highway speeds. This can occur at nearly any speed without warning. Car must be powered off and back on to get normalcy. This puts me, everyone in the car and everyone on the highway at risk. Dealership was not able to reproduce or pull error codes.

NHTSA ODI #11715307

Mileage unknown · Oct 27, 2025
EnginePower Train

The vehicle has ~51K miles. It has been maintained according to the manufacturer's recommended repair schedule. At low speeds (<10 mph) or when coming from a full stop the vehicle hard shifts. When driving up inclines at low speeds (<10 mph), the vehicle shakes and stutters on the verge of shutting off. This happened twice on [X…

Read full complaint

The vehicle has ~51K miles. It has been maintained according to the manufacturer's recommended repair schedule. At low speeds (<10 mph) or when coming from a full stop the vehicle hard shifts. When driving up inclines at low speeds (<10 mph), the vehicle shakes and stutters on the verge of shutting off. This happened twice on [XXX]. I experienced a full vehicle shut off on [XXX} while the vehicle was stationary, but shifted into drive . In August, the vehicle stuttered and shook before shutting off. I have reported three instances of this issue to my local Hyundai dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11695939

Mileage unknown · Oct 27, 2025
Engine

Vehicle suddenly began shutting off upon braking and/or acceleration at any speed, idling very hard, and/or barely starting or dying immediately after starting and making a very loud whining noise while driving on an interstate. A mechanic ran a diagnostic test on it and determined that it was a P1327 code and recommended it be …

Read full complaint

Vehicle suddenly began shutting off upon braking and/or acceleration at any speed, idling very hard, and/or barely starting or dying immediately after starting and making a very loud whining noise while driving on an interstate. A mechanic ran a diagnostic test on it and determined that it was a P1327 code and recommended it be taken to dealership for full engine failure. This particular code was known by Hyundai to occur on certain models and years, including Kona 2019-2021, as early as 2022 and while a recall campaign was initiated, no recall to date has been issued. No warning indicators on dash occurred in advance or even after the vehicle began malfunctioning (i.e., no check engine indicator, etc.). Vehicle is available at dealership upon request.

NHTSA ODI #11695903

Mileage unknown · Oct 15, 2025
Engine

The engine shut down when the car stops at a red light or stop sign. There are metal shavings in the oil due to issues with the pistons.

NHTSA ODI #11693682

Official recalls

2

21V301000 · Engine

Apr 28, 2021

Hyundai Motor America (Hyundai) is recalling certain 2019-2020 Elantra, 2019-2021 Kona and Veloster vehicles equipped with 2.0L Nu MPI engines. The piston oil rings may not have been properly heat-treated, which could result in engine damage.

Consequence & remedy

Consequence: A damaged engine may stall, increasing the risk of a crash. In addition, oil may leak onto hot exhaust components, increasing the risk of a fire.

Remedy: Dealers will inspect and, if necessary, replace the engine, free of charge. In addition, Hyundai will deploy Piston Ring Noise Sensing System (PNSS) software. Owner notification letters were mailed August 24, 2021. Owners may contact Hyundai customer service at 1-855-371-9460.

20V022000 · Equipment:other:labels

Jan 17, 2020

Hyundai Motor America (Hyundai) is recalling certain 2020 Kona vehicles. The certification label may indicate incorrect Gross Axle Weight Rating (GAWR). As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 567, "Certification" and 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: An incorrect GAWR could result in the vehicle being overloaded, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will install new label stickers displaying the correct GAWR over the affected areas of the certification label, free of charge. The recall began March 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 187.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing.  There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.