2018 Hyundai Kona

My car started making a noise back in Dec/2024. I scheduled an appointment with Quirk Hyundai in Braintree, Ma on Dec 11, 2024, and paid for a diagnostic the service center came back that it was the oil pan leaking so on this date I had that repaired that same day total cost was $254.76. Please note that my car was under warranty at this time. On [XXX], I brought my car back to Quirk Hyundai in Braintree because the noise had returned and was intermittent, and passenger side makes loud noise when riding over bumps and the car was shaking when driving pass 65 MPH. When I had the diagnostic done on 03/29/2025 the service center came back and said it was the mismatch tires that were put on my car by an outside provider (townfair tire) and that I needed 4 new tires, oil changes, mount and balance tires and four wheel alignment which cost me $959.08. Three days later while driving home from work the noise returned and my car ept shutting off one me. I went to AXP North in Randolph MA on 04/08/2025 (had to make an appt) for a second opinion diagnostic and they told me that my car will need a new engine as the one now is failing. I called Quirk Hyundai back on 04/08/2025 and told them this and they asked to bring the car back so they can recheck my car for misdiagnosis. So, on 4/09/2025 I called Quirk Hyundai for an update the failed engine was confirmed, and now because my car is 40 miles over the warranty it cannot be fixed by Hyundai. This car is a 2018 and should last me longer than 2025. My car is only 8 years old and I have cared for the car whenever it needed maintenance. I need someone to please call me to discuss further at [XXX] . I need a new engine and Quirk Hyundai will not cover the cost despite my several attempts to have this noise resolved when care was under warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2018 Hyundai Kona has been dealership serviced since buying it and it had about 115,000 miles on it when these issues began. Vehicle started to burn oil twice as fast as every time i would bring it into the dealership for the routine oil change, they would ALWAYS tell me that I had no oil in it. Therefore, I started to carry a quart of oil in the trunk and fill it up every 3 weeks or so. This went on for a few months until I started to notice a power problem while driving it on the highway on a trip. Tried to pull over at the next stop and then the car began shaking uncontrollably and engine shut off and would not start again. Took it to the dealership and they said your engine is shot and you're going to have to either buy a new car or put a new engine in it. I have seen many complaints and reviews about people having these same issues with the 2018 models. I know that there were a lot of recalls for the 2019 with these same issues with the incorrect heat tampered pistons causing these exact issues that the many of us 2018 owners have had. Please do the right thing and look into this. There are too many people having these same issues and this was my only means of transportation at the time.

Motor started burning oil at the rate of .5 quarts per week and a few months later vehicle failed to accelerate, had major vibrations and hesitation. Piston rings had failed. Verified by dealer. No other symptoms. Numerous problems with same motor reported by others and repair services. Has been recalled in Australia for same issues.

Felt a large shudder/vibration go through the whole car while on the highway and lost some power. The check engine light came on immediately after so we took it to a mechanic. Diagnostics came back as Hall sensor and cam shaft timing errors. It was found that the timing chain had slipped a tooth. Additionally, one of the pistons was found to have significantly lower PSI than the rest (105 vs 140) which they said is indicative of a pending total engine failure. A recall was issued for the 2019 model for this exact issue and symptom but Hyundai has said it doesn’t apply to our situation. Hyundai quoted 12-17 thousand dollars for a new engine. The car has 87 thousand miles and is less than 6 years old.

Vehicle was traveling down the highway with cruise control on and suddenly proceeded to not maintain speed and lost the ability to accelerate and shake in the middle of the interstate. Check engine light came on after this and we were able to limp it off the highway onto the ramp. No warning lights, no over heating, or any signs were given prior to this incident to give the impression this vehicle would stop operating. My family's safety was put at risk as it lost speed suddenly on the interstate in the middle of traffic and could have caused other cars to hit us as we slowed and tried to get over to access the ramp. Vehicle was towed and inspected at a local mechanic and was informed there was oil burned on the spark plugs and cylinder 1 and 3 had little to no compression.

While trying to accelerate on a on ramp onto the interstate, I felt my engine begin to knock. I pulled over and was able to get the car to drive home. The next morning my car would not turn over. I had it towed to my mechanic. They said it was bone dry of oil, I have always had it regularly serviced. They diagnosed it with engine failure. I’m just above the 60000 mile warranty at 63000 and Hyundai refuses to honor the warranty or help with the engine failure.

The contact owns a 2018 Hyundai Kona. The contact stated that while accelerating from a stop, the contact heard a loud knocking sound coming from the engine with the check engine warning light illuminated. The vehicle was taken to a dealer however, a diagnostic result was not disclosed; however, the dealer stated that the oil needed to be changed. The vehicle was not repaired, and the failure persisted. The vehicle was taken to another dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle would not be repaired under warranty. The failure mileage was approximately 50,000.

I was sold a car with 1 unprepared safety recall and 22 technical service bulletins. In addition to was previously salvaged sue to collision, hail, flood and fire. The vehicle also was a 2019 made into a 2018. When the ecm was reprogrammed the new vin was wiped clean and altered. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Pulled into driveway and saw smoke coming from engine. Popped hood and saw engine block was on fire. Quickly closed the hood and called 911. Within a few minutes the car was completely engulfed. I just had the car serviced a few days earlier and prior to that i had the 60k mile maintenance service done. There was around 63k miles on the car.

UNKNOWN. AC stopped working. According to repair shop, alternator belt sliced through the aluminum housing tube and Freon cannot be recharged . It needs total rebuild/reroute of AC tubing as The position and location of alternator belt is too close to the aluminum housing/tubing for cooling system. This is a bad build/design. When it’s really hot outside this is very dangerous for all passengers in this vehicle. Repairman/mechanic said he has seen this issue more and more on several Hyundai’s that came thru his shop, that he believes a common defect and has educated him as first thing to look for on a Hyundai needing AC repair.. and one can speculate there are MANY more, since he’s not a dealership.