2024 Hyundai Kona Electric

Dead battery parasitic drawer. brand new 2024 Hyundai Kona purchase February 2024. The car has been in the repair shop four times for this issue. Service department cannot find the parasitic draw so they just give you a new battery. The battery has been replaced twice. the problem has been reproduce, and the battery has died at the dealership. The manufacturer has been contacted, but the parasitic draw they cannot find.

My 2024 Hyundai Kona Electric lost power several times while driving on roads and highways at various speeds. The first instance was on [XXX] near Burlington, MA on [XXX], and then it happened several other times before we were able to get the vehicle to a Hyundai dealership for diagnosis and repair. The power loss typically manifested in the vehicle stuck at about 20-25 mph despite generous use of the accelerator pedal (often to the floor). There were no error messages or similar diagnostic information provided before, during, or after moments when power loss occurred. Often the vehicle would return to normal operation after a few minutes or by turning the vehicle off and back on again. The safety of the driver and passengers was at significant risk, especially on higher speed roadways due to the slow speed of the Kona in these moments. The dealer service department completed extensive diagnostics as detailed in the service report PDF attached. They ultimately found a nut (designated "ge09") connecting several ground wires to the chassis was loose. After replacing the nut and tightening to specification the problem has not recurred. We are satisfied with the communication and fix from the dealership and Hyundai corporate representatives, but concerned other Hyundai owners might encounter this issue with their vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2024 Hyundai Kona Electric. The contact stated while driving at an undisclosed speed at night, the instrument cluster, radio, and headlights inadvertently turned off for 20-30 seconds; however, the vehicle remained operational. The vehicle was taken to the dealer, where it was diagnosed with a loosened coaxial cable behind the radio, but no DTC codes were stored in any modules. The dealer related the failure to Technical Service Bulletin: 24-BE-013H (Software Reset for Connected Car Service (CCS) Disconnection). The dealer disconnected and reconnected the PDC connector, but the failure persisted. The vehicle was then taken to McCarthy Olathe Hyundai (681 N Rawhide, Olathe, KS 66061); however, the dealer was unable to duplicate the failure. The failure recurred. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 1,808.

The contact owns a 2024 Hyundai Kona Electric. The contact stated while driving at an undisclosed speed, the AEB feature was inadvertently activated. The contact also stated that while driving at an undisclosed speed, the vehicle lost motive power. The contact stated that the message “Engine off - Switch to Park or Neutral” was displayed. The vehicle was towed to an independent mechanic however, the vehicle was not diagnosed or repaired. The dealer was contacted but the vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 3,000.