2023 Hyundai Ioniq 6

The vehicle popped up a screen that said check power source. Then within 30 seconds went into limp mode said power was limited and couldn't drive faster the. 25mph in the middle of a highway. By the time I pulled over to the side of the road my car was dead. Ive been trying to get Hyundai and the dealership to dignose the issue. Based on the error codes I was given it appears to be a dead iccu and 12v battery. I am in a ioniq group on Facebook and over the last week of being in it I've counted over 50 dead iccu on this group alone. All in one week.

The contact owns a 2023 Hyundai Ioniq 6. The contact had received a notice of NHTSA Campaign Number: 24V868000 (Electrical System), and the vehicle was taken to the dealer, where the Integrated Charging Control Unit (ICCU) software update was completed. The contact stated that while driving 50 MPH on the highway, the vehicle stalled. The contact was able to pull over to the shoulder of the road. It was unknown whether a warning light had illuminated. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the Integrated Charging Control Unit (ICCU), and the 12-Volt battery had failed and needed to be replaced. The dealer ordered the parts. The contact stated that the recall remedy had failed to correct the safety issue. The vehicle was not yet repaired. The manufacturer was notified of the failure and informed the contact that parts would be shipped to the dealer for repair. The failure mileage was approximately 14,000.

The contact owns a 2023 Hyundai Ioniq 6. The contact received notification of NHTSA Campaign Number: 24V868000 (Electrical System), and the vehicle was taken to the dealer, where a software update was performed. The contact stated that the vehicle was charged at the residence, and the contact received notification through the Mobile App that the big battery charge was 80 percent. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to the dealer, where it was determined that the 12-Volt battery was completely drained and needed to be replaced. The contact stated that the recall remedy was intended to ensure that the big battery charged the 12-Volt battery during a charging session, but the recall remedy had failed to correct the issue as intended. The dealer informed the contact that the battery needed to be replaced prior to another attempt to perform the recall repair. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 55,000.

The contact owns a 2023 Hyundai Ioniq6. The contact stated that while driving approximately 20-30 MPH and attempting to use the horn, the contact discovered that the horn was inoperable. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was determined that the horn needed to be replaced. The vehicle was repaired, but the failure recurred. The dealer failed to pre-order the part for the repair. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 12,500.

Integrated charging control unit ICCU failed and was replaced by dealer. Warning light directed me to immediately pull over and have the car towed to the nearest dealer. Dealer confirmed ICCU failure with Diagnostic trouble code DTC P1A9096. Unknown whether the failed ICCU has been inspected by the manufacturer, police, insurance representatives or others. Warning lamps and messages appeared immediately upon the ICCU failure.

ICCU failure. EV car flashed battery issues and could not drive. ICCU and 12 volt battery replaced after 10 days in dealership shop. Manufacturer inspected. Prior to issue electric hatchback closed half way then stalled. I drove to the dealership and asked them to check if there was something wrong. They closed the hatch manually and said the 12 volt battery was fine and the computer said something blocked the closure, I left the dealership and made it less than a mile before battery light went off (within 5 minutes of leaving dealership). Made it back to dealership in turtle mode and this time computer said the ICCU failed.