IllustrationWHILE DRIVING AT LOW SPEED, AND APPLYING BRAKES, MY BREAK PEDAL WENT ALL THE WAY TO FLOOR. NO LIGHTS OR WARNINGS WERE DISPLAYED. THIS CONDITION CONTINUED UNTIL HOME. THE NEXT MORNING BRAKES WORKED NORMALLY AND HAVE FOR TWO WEEKS NOW.
2009 Hyundai Genesis
Owner reports · Recalls · Investigations
More warning signs than most Genesis years
Owner complaints for the 2009 Hyundai Genesis are substantially higher than the model-year median of 109.
About this comparison →How this year compares
Owner complaints by model year
Compare all Genesis years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
290–25K
4725–50K
6050–75K
3675–100K
27100–150K
8150K+
207 reports with mileage · 27 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 110 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports2 fire reports3 injury reports
What owners actually said
234 reportsTL* THE CONTACT OWNS A 2009 HYUNDAI GENESIS. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT APPLIED THE BRAKES AND THE BRAKE PEDAL TRAVELED TO THE FLOOR. THERE WAS NO RESISTANCE. THE VEHICLE WAS ABLE TO STOP SLOWLY. THE CONTACT PLACED THE VEHICLE IN PARK AND CONTINUED TO PUMP THE BRAKE PEDAL TO INCREASE THE TENSION AND THE BRAK…
Read full complaint
TL* THE CONTACT OWNS A 2009 HYUNDAI GENESIS. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT APPLIED THE BRAKES AND THE BRAKE PEDAL TRAVELED TO THE FLOOR. THERE WAS NO RESISTANCE. THE VEHICLE WAS ABLE TO STOP SLOWLY. THE CONTACT PLACED THE VEHICLE IN PARK AND CONTINUED TO PUMP THE BRAKE PEDAL TO INCREASE THE TENSION AND THE BRAKE PRESSURE RETURNED TO NORMAL. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 89,000.
TL* THE CONTACT OWNS A 2009 HYUNDAI GENESIS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE POWER STEERING FAILED CAUSING THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN. THE VEHICLE WAS RESTARTED AND OPERATED AS NORMAL. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2009 HYUNDAI GENESIS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE POWER STEERING FAILED CAUSING THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN. THE VEHICLE WAS RESTARTED AND OPERATED AS NORMAL. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE STEERING COLUMN SENSOR WAS REPLACED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 87,000.
2009 HYUNDAI GENESIS, IN MOTION STREET AND HIGHWAY. TOTAL BRAKE FAILURE. NO WARNING, NO DASHBOARD LIGHT WARNING. COLUMBIA HYUNDAI ADVISED THAT THE BRAKE FAILURE IS DUE TO FAILURE OF THE ABS CONTROL BOX. IN OTHER WORDS TOTAL, UN-ANNOUNCED FAILURE OF ANTI SKID CONTROL BOX CAUSED A COMPLETE BRAKE SYSTEM FAILURE IN THIS CAR.
WHEN ATTEMPTING TO STOP THE VEHICLE THE BRAKES WENT LOW TO THE FLOOR. TOOK TO DEALERSHIP SAID THAT THE ABS SYSTEM NEEDED TO BE REPLACED. THIS IS A KNOWN ISSUE WITH THE 2009 GENESIS BUT SINCE THEY HAD CHECKED IT IN 2014 IT WOULD NOT BE AN ISSUE FOR US. THIS WAS NOT TRUE AND OTHERS MAY HAVE THE PROBLEM IF THE ABS SYSTEM IS NOT REP…
Read full complaint
WHEN ATTEMPTING TO STOP THE VEHICLE THE BRAKES WENT LOW TO THE FLOOR. TOOK TO DEALERSHIP SAID THAT THE ABS SYSTEM NEEDED TO BE REPLACED. THIS IS A KNOWN ISSUE WITH THE 2009 GENESIS BUT SINCE THEY HAD CHECKED IT IN 2014 IT WOULD NOT BE AN ISSUE FOR US. THIS WAS NOT TRUE AND OTHERS MAY HAVE THE PROBLEM IF THE ABS SYSTEM IS NOT REPLACED.
WINDSHIELD WIPERS QUIT WORKING, DID SOME RESEARCH ONLINE, COME TO FIND OUT THAT THE WIPERS NOT WORKING IS A COMMON PROBLEM ON ALL 2009-2012 GENESIS. HYUNDAI HAS NOT COME OUT WITH A RECALL NOR A SERVICE BULLETIN KNOWING THIS IS A SAFETY ISSUE AND THE VEHIVLE IS INOPERABLE IN BAD WEATHER CONDITIONS.
TL* THE CONTACT OWNS A 2009 HYUNDAI GENESIS. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH AND ATTEMPTING TO STOP THE VEHICLE, THE BRAKES FAILED CAUSING THE BRAKE PEDAL TO EXTEND TO THE FLOORBOARD CAUSING A LONGER STOPPING DISTANCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS PREVIOUSLY SERVICED UN…
Read full complaint
TL* THE CONTACT OWNS A 2009 HYUNDAI GENESIS. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH AND ATTEMPTING TO STOP THE VEHICLE, THE BRAKES FAILED CAUSING THE BRAKE PEDAL TO EXTEND TO THE FLOORBOARD CAUSING A LONGER STOPPING DISTANCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS PREVIOUSLY SERVICED UNDER NHTSA CAMPAIGN NUMBER: 13V489000 (SERVICE BRAKES, HYDRAULIC) BUT THE FAILURE PERSISTED. THE FAILURE MILEAGE WAS 101,000.....UPDATED 12/30/15 *BF UPDATED 01/27/16.*JB
TL* THE CONTACT OWNS A 2009 HYUNDAI GENESIS. WHILE DRIVING APPROXIMATELY 75 MPH, THE BRAKE PEDAL FELT STIFF AND MADE AN ABNORMAL NOISE. THE VEHICLE SLOWED DOWN TO 30 MPH AND WOULD NOT INCREASE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE CONTACT PROCEEDED TO PULL OVER TO THE SHOULDER AN…
Read full complaint
TL* THE CONTACT OWNS A 2009 HYUNDAI GENESIS. WHILE DRIVING APPROXIMATELY 75 MPH, THE BRAKE PEDAL FELT STIFF AND MADE AN ABNORMAL NOISE. THE VEHICLE SLOWED DOWN TO 30 MPH AND WOULD NOT INCREASE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE CONTACT PROCEEDED TO PULL OVER TO THE SHOULDER AND CALLED ROADSIDE SERVICE. THE VEHICLE WAS TURNED OFF AND RESTARTED. THE ELECTRONIC STABILTY CONTROL LIGHT ILUMINATED AND THE VEHICLE RESUMED NORMAL OPERATION. THE DEALER STATED THAT THE BRAKE ROTORS OVERHEATED. THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 70,060.
I WAS DRIVING FROM RHODE ISLAND TO NORTH CAROLINA AND WHEN I WAS DRIVING WEST ACROSS THE TAPPAN ZEE BRIDGE NEAR NEW YORK CITY AND HAD GOTTEN TO THE OTHER SIDE OF THE BRIDGE, I LOST THROTTLE RESPONSE. THE CAR BEGAN TO SLOW DOWN IN HEAVY TRAFFIC AND I HAD TO CROSS THREE LANES TO GET TO THE RIGHT HAND LANE. THE CHECK ENGINE LIGHT…
Read full complaint
I WAS DRIVING FROM RHODE ISLAND TO NORTH CAROLINA AND WHEN I WAS DRIVING WEST ACROSS THE TAPPAN ZEE BRIDGE NEAR NEW YORK CITY AND HAD GOTTEN TO THE OTHER SIDE OF THE BRIDGE, I LOST THROTTLE RESPONSE. THE CAR BEGAN TO SLOW DOWN IN HEAVY TRAFFIC AND I HAD TO CROSS THREE LANES TO GET TO THE RIGHT HAND LANE. THE CHECK ENGINE LIGHT WAS ON STEADY AT THIS POINT. BY THE TIME I REACHED THE RIGHT HAND LANE, THE CAR WAS GOING ONLY ABOUT 35 MPH AND I WAS VERY LUCKY THAT I WAS NOT HIT BY OTHER VEHICLES ON THE BRIDGE, WHO WERE DODGING ME AT HIGH SPEED ON BOTH SIDES. . THIS WAS A VERY SCARY SITUATION AND COULD EASILY HAVE RESULTED IN FATALITIES. FORTUNATELY, THERE WAS AN EXIT ON THE OTHER SIDE OF THE BRIDGE AND I MANAGED TO GET OFF I287 AND FIND A PLACE TO STOP. I CHECKED THE INTERNET AND FOUND REPORTS THAT OTHER PEOPLE HAD EXPERIENCED SIMILAR EVENTS AND THAT THE CAR RETURNED TO NORMAL AFTER TURNING OFF THE ENGINE AND RESTARTING IT. MY WIFE, WHO WAS WITH ME, RECALLED THAT SOMETHING SIMILAR HAPPENED TO HER 2004 HYUNDAI SANTA FE SEVERAL YEARS AGO WHEN IT WAS DRIVEN LOCALLY BY ONE OF MY SONS. SO AFTER ABOUT 20 MINUTES, I RESTARTED THE CAR AND FOUND THAT THROTTLE CONTROL HAD RETURNED AND WE CONTINUED ON OUR WAY. AFTER STOPPING TO EAT LATER IN THE DAY, AND RETURNING TO THE CAR, THE CHECK ENGINE LIGHT HAD GONE OFF AND HAS BEEN OFF EVER SINCE. I MANAGED TO RETURN TO RHODE ISLAND YESTERDAY WITHOUT ANY FURTHER PROBLEMS, BUT AM NOW AFRAID THAT THIS MIGHT HAPPEN AGAIN AND THAT I WILL NOT BE SO LUCKY THE NEXT TIME. I HAVE NOT HAD TIME YET TO HAVE THE DEALER CHECK OUT THE CAR, BUT PLAN TO DO SO AS SOON AS POSSIBLE. THIS IS CLEARLY A SERIOUS SAFETY ISSUE AND I AM SURPRISED THAT THERE HAS NOT BEEN A RECALL TO FIX THIS PROBLEM, ESPECIALLY CONSIDERING THAT IT APPEARS TO BE SOMETHING THAT HAS BEEN HAPPENING TO HYUNDAI CARS, (AND POSSIBLY OTHERS), FOR SOME TIME NOW.
ON SEPTEMBER 19, 2015, WHEN APPROACHING A RED LIGHT, THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOORBOARD AND THE CAR WOULD NOT STOP. REPEATED PUMPING OF THE PEDAL FINALLY BROUGHT THE CAR TO A STOP. WITHIN AN HOUR A SECOND EVENT OCCURRED ON THE FREEWAY WHEN APPROACHING ANOTHER CAR FROM THE REAR. THE BRAKE PEDAL HAD NO RESISTANCE A…
Read full complaint
ON SEPTEMBER 19, 2015, WHEN APPROACHING A RED LIGHT, THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOORBOARD AND THE CAR WOULD NOT STOP. REPEATED PUMPING OF THE PEDAL FINALLY BROUGHT THE CAR TO A STOP. WITHIN AN HOUR A SECOND EVENT OCCURRED ON THE FREEWAY WHEN APPROACHING ANOTHER CAR FROM THE REAR. THE BRAKE PEDAL HAD NO RESISTANCE AND WENT ALL THE WAY TO THE FLOORBOARD. IT HAS NOT OCCURRED AGAIN. TWO DAYS LATER I TOOK THE CAR (CAREFULLY) INTO THE DEALER. THEY HAVE, AS YET, BEEN UNABLE TO REPLICATE THE PROBLEM (AS HYUNDAI REQUIRES FOR WARRANTY CONSIDERATION). HOWEVER, I WILL NOT DRIVE THIS CAR OR LET MY WIFE USE IT UNTIL THIS IS DIAGNOSED AND REPAIRED. IT IS EXTREMELY UNSAFE. THIS TYPE OF BRAKE FAILURE HAS BEEN NOTED REPEATEDLY IN THE 2009 HYUNDAI GENESIS. I AM STUCK WITH AN UNUSABLE CAR AND A MANUFACTURER WHO WILL NOT RECOGNIZE THE SEVERITY OF THIS ISSUE. THE DEALER DOES NOT WANT TO REPEATEDLY SUBJECT THEIR STAFF TO THE RISK OF AN ACCIDENT BUT HYUNDAI REQUIRES THE PROBLEM BE VALIDATED BY ANOTHER OCCURRENCE WHEN DRIVEN BY DEALER STAFF.
Official recalls
314V713000 · Exterior Lighting:brake Lights:switch
Nov 7, 2014
Hyundai Motor America (Hyundai) is recalling certain 2009-2011 Hyundai Genesis vehicles manufactured April 30, 2008, to November 21, 2010, and 2011 Hyundai Equus vehicles manufactured July 31, 2010, to November 21, 2010. Due to a circuit failure, the stop lamps in the affected vehicles may not illuminate.
Consequence & remedy
Consequence: A following vehicle may not recognize that the vehicle is slowing or coming to a stop if the stop lamps on the vehicle do not illuminate as expected. There is an increased risk of a rear-end crash as a result.
Remedy: Hyundai will notify owners, and dealers will repair the stop lamp switch circuit, free of charge. Hyundai issued an interim notification to owners on January 6, 2015. The recall began on March 23, 2015. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 125.
13V489000 · Service Brakes, Hydraulic:fluid
Oct 29, 2013
Hyundai is recalling certain model year 2009-2012 Genesis vehicles manufactured April 30, 2008, through March 28, 2012. The vehicles may contain brake fluid which does not protect against corrosion of the Hydraulic Electronic Control Unit (HECU).
Consequence & remedy
Consequence: If the module corrodes, reduced brake effectiveness may result, increasing the risk of a crash.
Remedy: Hyundai will notify owners and instruct them to bring their vehicle to a dealer for service. Hyundai will inspect the HECU module for proper operation, and will replace the modules as necessary. Hyundai will replace the factory brake fluid in those vehicles that have not previously had the factory brake fluid replaced. These repairs will be done free of charge. The recall began on December 24, 2013. Owners may contact Hyundai at 1-800-633-5151 or by email at consumeraffairs@hmausa.com. Hyundai's recall number is 114.
13V113000 · Exterior Lighting:brake Lights:switch
Apr 1, 2013
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE13033 · Brake Hydraulic Control Module Failure
Opened Oct 17, 2013 · Closed Apr 4, 2014
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
On October 28, 2013, Hyundai Motor Company (Hyundai) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the braking system of approximately 43,500 model year (MY) 2009 through 2012 Hyundai Genesis sedans (NHTSA Recall No. 13V-489).The Hyundai report indicates that the recalled vehicles may contain brake fluid that does not sufficiently inhibit corrosion on the zinc plating of control valve armatures in the Hydraulic Electronic Control Unit (HECU) module. The DIR indicated that, over time, the build-up of corrosion products may affect operation of HECU control valves, resulting in a low/soft brake pedal with reduced brake effectiveness, which may increase the risk of a crash.In October 2011, the HECU supplier notified Hyundai that the brake fluid used in production plants was causing corrosion of valve armatures in the control module.The supplier changed the coating of the valve armatures in late March 2012 to correct the problem in production vehicles.Hyundai's recall includes Genesis vehicles produced prior to the implementation of the HECU change.In March 2013, Hyundai initiated a Service Campaign (TL6) to replace brake fluid in the subject vehicles with brake fluid with better corrosion resistance properties.According to Hyundai's DIR letter, after PE13-033 was opened, the company noted that some of the vehicles serviced in the TL6 campaign subsequently required HECU replacement.This was an indication that internal corrosion had progressed enough to affect valve operation and brake performance, prompting Hyundai to conduct a safety recall.Hyundai's repair procedures for 13V-489 require brake system flushing and replacement in all recalled vehicles with a new fluid containing the necessary corrosion inhibitor.In addition, for vehicles produced prior to June 1, 2010, dealers will perform an inspection procedure to verify that the HECU is functioning properly and replace units that do not meet the test requirements.Hyundai indicated that, based on analysis of claim data, only vehicles produced prior to June 1, 2010 have been in service long enough to require the additional inspection/replacement of the HECU. Analysis of failure data reported to NHTSA and provided by Hyundai in response to ODI's information request letter for PE13-033 identified 756 complaints and 1,683 warranty claims for 30,114 subject vehicles produced prior to June 1, 2010, resulting in a complaint rate of 25.1 incidents per thousand vehicles (IPTV) and a claim rate of 5.6 percent.The MY 2009 vehicles, with the longest exposure times, experienced the highest complaint (33.5 IPTV) and warranty (7.0 percent) rates.For the 45,639 subject vehicles produced after June 1, 2010, ODI identified 13 complaints and 34 warranty claims, resulting in a complaint rate of 0.3 IPTV and a warranty claim rate of 0.1 percent, indicating that the brake fluid corrosion concern had not progressed far enough to result in significant rates of brake system performance symptoms in those vehicles.This investigation is closed.ODI will continue to monitor complaints to evaluate the effectiveness of Hyundai's recall.The VOQs noted in the Failure Report are: 10569231, 10560898, 10560495, 10559360, 10558279, 10558264, 10556964, 10556631, 10556577, 10556322, 10554988, 10554802, 10554122, 10552958, 10551817, 10551157, 10551110, 10551092, 10550791, 10550773, 10550431, 10549750, 10549634, 10549629, 10549567, 10549402, 10549376, 10549270, 10549228, 10549186, 10549021, 10548903, 10548823, 10548791, 10548737, 10548722, 10548716, 10548705, 10546565, 10544803, 10543663, 10542962, 10541959, 10541741, 10538208, 10537934, 10536652, 105354
Additional source detail variants (3)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
On October 28, 2013, Hyundai Motor Company (Hyundai) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the braking system of approximately 43,500 model year (MY) 2009 through 2012 Hyundai Genesis sedans (NHTSA Recall No. 13V-489).The Hyundai report indicates that the recalled vehicles may contain brake fluid that does not sufficiently inhibit corrosion on the zinc plating of control valve armatures in the Hydraulic Electronic Control Unit (HECU) module. The DIR indicated that, over time, the build-up of corrosion products may affect operation of HECU control valves, resulting in a low/soft brake pedal with reduced brake effectiveness, which may increase the risk of a crash.In October 2011, the HECU supplier notified Hyundai that the brake fluid used in production plants was causing corrosion of valve armatures in the control module.The supplier changed the coating of the valve armatures in late March 2012 to correct the problem in production vehicles.Hyundai's recall includes Genesis vehicles produced prior to the implementation of the HECU change.In March 2013, Hyundai initiated a Service Campaign (TL6) to replace brake fluid in the subject vehicles with brake fluid with better corrosion resistance properties.According to Hyundai's DIR letter, after PE13-033 was opened, the company noted that some of the vehicles serviced in the TL6 campaign subsequently required HECU replacement.This was an indication that internal corrosion had progressed enough to affect valve operation and brake performance, prompting Hyundai to conduct a safety recall.Hyundai's repair procedures for 13V-489 require brake system flushing and replacement in all recalled vehicles with a new fluid containing the necessary corrosion inhibitor.In addition, for vehicles produced prior to June 1, 2010, dealers will perform an inspection procedure to verify that the HECU is functioning properly and replace units that do not meet the test requirements.Hyundai indicated that, based on analysis of claim data, only vehicles produced prior to June 1, 2010 have been in service long enough to require the additional inspection/replacement of the HECU. Analysis of failure data reported to NHTSA and provided by Hyundai in response to ODI's information request letter for PE13-033 identified 756 complaints and 1,683 warranty claims for 30,114 subject vehicles produced prior to June 1, 2010, resulting in a complaint rate of 25.1 incidents per thousand vehicles (IPTV) and a claim rate of 5.6 percent.The MY 2009 vehicles, with the longest exposure times, experienced the highest complaint (33.5 IPTV) and warranty (7.0 percent) rates.For the 45,639 subject vehicles produced after June 1, 2010, ODI identified 13 complaints and 34 warranty claims, resulting in a complaint rate of 0.3 IPTV and a warranty claim rate of 0.1 percent, indicating that the brake fluid corrosion concern had not progressed far enough to result in significant rates of brake system performance symptoms in those vehicles.This investigation is closed.ODI will continue to monitor complaints to evaluate the effectiveness of Hyundai's recall.The VOQs noted in the Failure Report are: 10569231, 10560898, 10560495, 10559360, 10558279, 10558264, 10556964, 10556631, 10556577, 10556322, 10554988, 10554802, 10554122, 10552958, 10551817, 10551157, 10551110, 10551092, 10550791, 10550773, 10550431, 10549750, 10549634, 10549629, 10549567, 10549402, 10549376, 10549270, 10549228, 10549186, 10549021, 10548903, 10548823, 10548791, 10548737, 10548722, 10548716, 10548705, 10546565, 10544803, 10543663, 10542962, 10541959, 10541741, 10538208, 10537934, 10536652, 105354
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
On October 28, 2013, Hyundai Motor Company (Hyundai) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the braking system of approximately 43,500 model year (MY) 2009 through 2012 Hyundai Genesis sedans (NHTSA Recall No. 13V-489).The Hyundai report indicates that the recalled vehicles may contain brake fluid that does not sufficiently inhibit corrosion on the zinc plating of control valve armatures in the Hydraulic Electronic Control Unit (HECU) module. The DIR indicated that, over time, the build-up of corrosion products may affect operation of HECU control valves, resulting in a low/soft brake pedal with reduced brake effectiveness, which may increase the risk of a crash.In October 2011, the HECU supplier notified Hyundai that the brake fluid used in production plants was causing corrosion of valve armatures in the control module.The supplier changed the coating of the valve armatures in late March 2012 to correct the problem in production vehicles.Hyundai's recall includes Genesis vehicles produced prior to the implementation of the HECU change.In March 2013, Hyundai initiated a Service Campaign (TL6) to replace brake fluid in the subject vehicles with brake fluid with better corrosion resistance properties.According to Hyundai's DIR letter, after PE13-033 was opened, the company noted that some of the vehicles serviced in the TL6 campaign subsequently required HECU replacement.This was an indication that internal corrosion had progressed enough to affect valve operation and brake performance, prompting Hyundai to conduct a safety recall.Hyundai's repair procedures for 13V-489 require brake system flushing and replacement in all recalled vehicles with a new fluid containing the necessary corrosion inhibitor.In addition, for vehicles produced prior to June 1, 2010, dealers will perform an inspection procedure to verify that the HECU is functioning properly and replace units that do not meet the test requirements.Hyundai indicated that, based on analysis of claim data, only vehicles produced prior to June 1, 2010 have been in service long enough to require the additional inspection/replacement of the HECU. Analysis of failure data reported to NHTSA and provided by Hyundai in response to ODI's information request letter for PE13-033 identified 756 complaints and 1,683 warranty claims for 30,114 subject vehicles produced prior to June 1, 2010, resulting in a complaint rate of 25.1 incidents per thousand vehicles (IPTV) and a claim rate of 5.6 percent.The MY 2009 vehicles, with the longest exposure times, experienced the highest complaint (33.5 IPTV) and warranty (7.0 percent) rates.For the 45,639 subject vehicles produced after June 1, 2010, ODI identified 13 complaints and 34 warranty claims, resulting in a complaint rate of 0.3 IPTV and a warranty claim rate of 0.1 percent, indicating that the brake fluid corrosion concern had not progressed far enough to result in significant rates of brake system performance symptoms in those vehicles.This investigation is closed.ODI will continue to monitor complaints to evaluate the effectiveness of Hyundai's recall.The VOQs noted in the Failure Report are: 10569231, 10560898, 10560495, 10559360, 10558279, 10558264, 10556964, 10556631, 10556577, 10556322, 10554988, 10554802, 10554122, 10552958, 10551817, 10551157, 10551110, 10551092, 10550791, 10550773, 10550431, 10549750, 10549634, 10549629, 10549567, 10549402, 10549376, 10549270, 10549228, 10549186, 10549021, 10548903, 10548823, 10548791, 10548737, 10548722, 10548716, 10548705, 10546565, 10544803, 10543663, 10542962, 10541959, 10541741, 10538208, 10537934, 10536652, 105354
Service Brakes, Hydraulic
On October 28, 2013, Hyundai Motor Company (Hyundai) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the braking system of approximately 43,500 model year (MY) 2009 through 2012 Hyundai Genesis sedans (NHTSA Recall No. 13V-489).The Hyundai report indicates that the recalled vehicles may contain brake fluid that does not sufficiently inhibit corrosion on the zinc plating of control valve armatures in the Hydraulic Electronic Control Unit (HECU) module. The DIR indicated that, over time, the build-up of corrosion products may affect operation of HECU control valves, resulting in a low/soft brake pedal with reduced brake effectiveness, which may increase the risk of a crash.In October 2011, the HECU supplier notified Hyundai that the brake fluid used in production plants was causing corrosion of valve armatures in the control module.The supplier changed the coating of the valve armatures in late March 2012 to correct the problem in production vehicles.Hyundai's recall includes Genesis vehicles produced prior to the implementation of the HECU change.In March 2013, Hyundai initiated a Service Campaign (TL6) to replace brake fluid in the subject vehicles with brake fluid with better corrosion resistance properties.According to Hyundai's DIR letter, after PE13-033 was opened, the company noted that some of the vehicles serviced in the TL6 campaign subsequently required HECU replacement.This was an indication that internal corrosion had progressed enough to affect valve operation and brake performance, prompting Hyundai to conduct a safety recall.Hyundai's repair procedures for 13V-489 require brake system flushing and replacement in all recalled vehicles with a new fluid containing the necessary corrosion inhibitor.In addition, for vehicles produced prior to June 1, 2010, dealers will perform an inspection procedure to verify that the HECU is functioning properly and replace units that do not meet the test requirements.Hyundai indicated that, based on analysis of claim data, only vehicles produced prior to June 1, 2010 have been in service long enough to require the additional inspection/replacement of the HECU. Analysis of failure data reported to NHTSA and provided by Hyundai in response to ODI's information request letter for PE13-033 identified 756 complaints and 1,683 warranty claims for 30,114 subject vehicles produced prior to June 1, 2010, resulting in a complaint rate of 25.1 incidents per thousand vehicles (IPTV) and a claim rate of 5.6 percent.The MY 2009 vehicles, with the longest exposure times, experienced the highest complaint (33.5 IPTV) and warranty (7.0 percent) rates.For the 45,639 subject vehicles produced after June 1, 2010, ODI identified 13 complaints and 34 warranty claims, resulting in a complaint rate of 0.3 IPTV and a warranty claim rate of 0.1 percent, indicating that the brake fluid corrosion concern had not progressed far enough to result in significant rates of brake system performance symptoms in those vehicles.This investigation is closed.ODI will continue to monitor complaints to evaluate the effectiveness of Hyundai's recall.The VOQs noted in the Failure Report are: 10569231, 10560898, 10560495, 10559360, 10558279, 10558264, 10556964, 10556631, 10556577, 10556322, 10554988, 10554802, 10554122, 10552958, 10551817, 10551157, 10551110, 10551092, 10550791, 10550773, 10550431, 10549750, 10549634, 10549629, 10549567, 10549402, 10549376, 10549270, 10549228, 10549186, 10549021, 10548903, 10548823, 10548791, 10548737, 10548722, 10548716, 10548705, 10546565, 10544803, 10543663, 10542962, 10541959, 10541741, 10538208, 10537934, 10536652, 105354