NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
314 reports20 miles · Jun 11, 2009
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2008 HYUNDAI ELANTRA. WHILE DRIVING 45 MPH, THE THROTTLE SENSOR STICKS AND CAUSES THE VEHICLE TO CONTINUE ACCELERATING WITHOUT PRESSURE BEING APPLIED TO THE PEDAL. THE CONTACT HAS TO APPLY EXTREME PRESSURE TO THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY DETER…
Read full complaint
TL*THE CONTACT OWNS A 2008 HYUNDAI ELANTRA. WHILE DRIVING 45 MPH, THE THROTTLE SENSOR STICKS AND CAUSES THE VEHICLE TO CONTINUE ACCELERATING WITHOUT PRESSURE BEING APPLIED TO THE PEDAL. THE CONTACT HAS TO APPLY EXTREME PRESSURE TO THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY DETERMINED THAT THE THROTTLE SENSOR WAS FAILING. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT THEY WILL CALL THE DEALER FOR A REPORT ON THE FAILURE, AND GIVE THE CONTACT A CALL BACK. THE FAILURE MILEAGE WAS 20 AND CURRENT MILEAGE WAS 17,400.
NHTSA ODI #10273524
4,443 miles · Jun 9, 2009
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2008 HYUNDAI ELANTRA. ON TWO OCCASIONS, THE VEHICLE BEGAN TO STUTTER AND STALL WHEN SLOWING DOWN. DURING THE SECOND OCCURRENCE, THE VEHICLE WAS TOWED TO THE DEALER BUT THEY COULD NOT FIND ANY FAILURES. THE FAILURE MILEAGE WAS 4,443.
NHTSA ODI #10273214
5,150 miles · May 19, 2009
Electrical SystemFuel System, Gasoline
ENGINE CUT OFF WITH FUEL GAUGE DROPPING TO 'EMPTY' [ WITH A 1/2 FULL TANK]. ON THE NYS THRUWAY ALMOST CAUSING A COLLISION WITH AN 18 WHEELER AS I COASTED ACROSS ITS PATH TO THE SHOULDER IN ROCKLAND COUNTY. CALLED AAA AND EVENTUALLY, [ABOUT 10 MIN. AFTER, WHILE STILL ON THE LINE WITH AAA, I HEARD A LIGHT CLICK AND THE FUEL GAUGE…
Read full complaint
ENGINE CUT OFF WITH FUEL GAUGE DROPPING TO 'EMPTY' [ WITH A 1/2 FULL TANK]. ON THE NYS THRUWAY ALMOST CAUSING A COLLISION WITH AN 18 WHEELER AS I COASTED ACROSS ITS PATH TO THE SHOULDER IN ROCKLAND COUNTY. CALLED AAA AND EVENTUALLY, [ABOUT 10 MIN. AFTER, WHILE STILL ON THE LINE WITH AAA, I HEARD A LIGHT CLICK AND THE FUEL GAUGE WENT BACK UP TO 1/2 TANK AND THE CAR ENGINE STARTED UP TO COMPLETE MY DRIVE HOME. *TR
NHTSA ODI #10269446
14,000 miles · Feb 28, 2009
Air Bags
THERE WAS NO PARTICULAR INCIDENT RELATED TO A CRASH. TWICE SINCE 10/08 THE DASHBOARD AIRBAG LIGHT HAS GONE ON FOR NO REASON AND WOULD NOT GO OFF. THE HYUNDAI DEALER SAID THE FIRST TIME THAT THE WIRING WAS LOOSE FROM THE TIME OF INSTALLATION MOST LIKELY, AND THEY TIGHTENED THE WIRES. SECOND INCIDENT WAS 2 WEEKS AGO. THIS TIME THE…
Read full complaint
THERE WAS NO PARTICULAR INCIDENT RELATED TO A CRASH. TWICE SINCE 10/08 THE DASHBOARD AIRBAG LIGHT HAS GONE ON FOR NO REASON AND WOULD NOT GO OFF. THE HYUNDAI DEALER SAID THE FIRST TIME THAT THE WIRING WAS LOOSE FROM THE TIME OF INSTALLATION MOST LIKELY, AND THEY TIGHTENED THE WIRES. SECOND INCIDENT WAS 2 WEEKS AGO. THIS TIME THEY TELL US WE HAVE A FAULTY HARNESS AND IT NEEDS TO BE REPLACED. WE ARE STILL WAITING FOR THE PART WHICH IS SUPPOSEDLY ON MANUFACTURER BACKORDER. THEY TELL US THE ISSUE IS SO UNCOMMON THAT THEY HAVE NOT SEEN IT BEFORE. JUST DOING A SEARCH ONLINE I SEE THE RECENT RECALL FOR SIMILAR AIRBAG ISSUES ON THE 01-02 ELANTRAS, SO THIS MAKES ME NERVOUS. PLEASE PLEASE INVESTIGATE THIS ISSUE WITH THE 08S AS WELL! THIS IS OUR ONLY CAR AND I DO NOT FEEL SAFE DRIVING IT, ESPECIALLY WHILE WAITING FOR THE NEW HARNESS..BUT IN THE LONG RUN I WORRY ABOUT FUTURE FAILURES IF AN ACCIDENT DID OCCUR. *TR
NHTSA ODI #10260307
Mileage unknown · Feb 20, 2009
Engine And Engine Cooling
DURING A SHARP, SUDDEN TURN AT ABOUT 40 MPH, THE CAR SHUT OFF COMPLETELY. THE CAR IS A 2008 HYUNDAI ELANTRA GLS. *TR
NHTSA ODI #10259415
200 miles · Feb 17, 2009
Power Train
1) POOR GAS MILEAGE - NOT MEETING EPA ESTIMATES. TOOK TO DEALER 3 TIMES. HAD FUEL PUMP REPLACED AFTER CAR STALLED ON ROADWAY AND WOULD NOT RESULT. STALLING STOPPED BUT MPG IS BELOW EPA ESTIMATES - DEALER SAYS EVERYTHING OK... 2) AUTO TRANSMISSION SPUTTERS AND DOESN''T DOWNSHIFT PROPERLY - HAVE TO MANUALLY DOWNSHIFT TO MAINTAIN …
Read full complaint
1) POOR GAS MILEAGE - NOT MEETING EPA ESTIMATES. TOOK TO DEALER 3 TIMES. HAD FUEL PUMP REPLACED AFTER CAR STALLED ON ROADWAY AND WOULD NOT RESULT. STALLING STOPPED BUT MPG IS BELOW EPA ESTIMATES - DEALER SAYS EVERYTHING OK... 2) AUTO TRANSMISSION SPUTTERS AND DOESN''T DOWNSHIFT PROPERLY - HAVE TO MANUALLY DOWNSHIFT TO MAINTAIN PROPER TORQUE ON MOTOR. I FEEL LIKE I AM DRIVING A STICK SHIFT I HAVE TO DOWNSHIFT SO OFTEN TO KEEP CAR FROM SPUTTERING AND MAINTAIN ACCELERATION. DEALER SAY EVERYTHING OK. I READ THAT THERE IS AN ACKNOWLEDGE TORQ PROBLEM BUT MANUFACTURE HAS NOT ISSUED A FIX... *TR
NHTSA ODI #10259150
3,450 miles · Jan 29, 2009
Parking Brake
FOR THE PAST 2 WEEKS I HAVE NOTICED A PROBLEM WITH THE EMERGENCY BRAKES. NOW 2 DAYS AGO WHILE ON A HILL AND IN PARK I HAD THE EMERGENCY BRAKES ON AND THE CAR STARTED ROLLING WITH ME IN IT BEFORE I EVEN GOT OUT OF THE CAR. BACK IN AUGUST I TOLD MY DEALER THE CAR WAS ROLLING BACKWARDS WHEN I WOULD PARK ON A HILL AND THEY CHECKED I…
Read full complaint
FOR THE PAST 2 WEEKS I HAVE NOTICED A PROBLEM WITH THE EMERGENCY BRAKES. NOW 2 DAYS AGO WHILE ON A HILL AND IN PARK I HAD THE EMERGENCY BRAKES ON AND THE CAR STARTED ROLLING WITH ME IN IT BEFORE I EVEN GOT OUT OF THE CAR. BACK IN AUGUST I TOLD MY DEALER THE CAR WAS ROLLING BACKWARDS WHEN I WOULD PARK ON A HILL AND THEY CHECKED IT OUT AND IT STOPPED DOING THIS, BUT THEY SAID THEY FOUND NOTHING WRONG. NOW IT IS GETTING MORE SERIOUS. *TR
NHTSA ODI #10256691
7,000 miles · Jan 19, 2009
Service Brakes, Hydraulic
MY CAR, WHEN DRIVEN IN THE SNOW, WHEN YOU BRAKE, THE CAR STARTS TO BRAKE, BUT THE BRAKE PEDAL FREEZES BACK TO THE ORIGINAL POSITION, AT THE TOP OF THE PEDAL, LEAVING YOU WITH NO BRAKES. I TOOK IT TO THE DEALERSHIP, AND THEY TOLD ME, THEY ARE UNABLE TO REPRODUCE THE PROBLEM. THIS TO ME, MAKES THE CAR A DEATH TRAP, WHEN DRIVING …
Read full complaint
MY CAR, WHEN DRIVEN IN THE SNOW, WHEN YOU BRAKE, THE CAR STARTS TO BRAKE, BUT THE BRAKE PEDAL FREEZES BACK TO THE ORIGINAL POSITION, AT THE TOP OF THE PEDAL, LEAVING YOU WITH NO BRAKES. I TOOK IT TO THE DEALERSHIP, AND THEY TOLD ME, THEY ARE UNABLE TO REPRODUCE THE PROBLEM. THIS TO ME, MAKES THE CAR A DEATH TRAP, WHEN DRIVING IN SNOW. I DIDN'T HAVE AN ACCIDENT OR ANYTHING, I CAN EASILY REPRODUCE THE PROBLEM BY DRIVING ON A STREET WITH SNOW, I'M AFRAID TO TAKE IT NOW ONTO A HIGHWAY. *TR
NHTSA ODI #10255570
Mileage unknown · Jan 12, 2009
Fuel System, Gasoline
2008 HYUNDAI ELANTRA RECALL FOR FUEL PUMP MOTOR PROBLEM. CONSUMER STATES THAT THE DEALERSHIP IS HAVING A PROBLEM WITH GETTING THE PARTS FOR THE CAR. *NJ
NHTSA ODI #10254608
4,983 miles · Jan 10, 2009
Visibility
MY COMPLAINT DEALS WITH THE FRONT WINDOW. IT WAS CRACKED WHILE DRIVING ON A HIGHWAY BY A SMALL ROCK. THE CAR IS FIVE MONTHS OLD. I HAVE HEARD OF TWO OTHER OWNERS OF THE SAME VEHICLE WHO HAVE A SIMILAR EXPERIENCES WITH CRACKS AND EXPANSION IN THE FRONT WINDOW OF HYUNDAI ELANTRA MODEL 08. *TR
NHTSA ODI #10254473
Official recalls
7Feb 4, 2020
Hyundai Motor America (Hyundai) is recalling certain 2007-2010 Elantra and 2009-2011 Elantra Touring vehicles. On February 21, 2020 Hyundai expanded the recall to include 46,425 model year 2007-2008 Entourage and 2007 Santa Fe vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence & remedy
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.
Remedy: Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began April 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 188.
Feb 23, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2008-2010 Elantra vehicles manufactured June 1, 2008, to April 30, 2010, and 2009-2010 Elantra Touring vehicles manufactured November 1, 2008, to April 30, 2010. The electronic power steering (EPS) electronic control unit (ECU) may sense a discrepancy in the steering input signals and, as a result, disable the steering power assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Hyundai will verify the proper operation of the Electronic Power Steering (EPS) and update the EPS control unit, free of charge. The recall began April 14, 2015. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 127.
Apr 1, 2013
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Mar 15, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2009 ELANTRA VEHICLES MANUFACTURED FROM JULY 14, 2006, THROUGH NOVEMBER 1, 2008. THE FRONT PASSENGER SEATS IN THE VEHICLES CONTAIN A WEIGHT SENSOR DESIGNED TO DEACTIVATE THE RIGHT FRONTAL AIRBAG WHEN OCCUPANTS OF CERTAIN WEIGHTS OCCUPY THE SEAT. THE ELECTRICAL CONNECTOR FOR THE WEIGHT SENSOR IS LOCATED UNDER THE CENTER CONSOLE, BETWEEN THE FRONT SEATS. UNDER CERTAIN CIRCUMSTANCES THE CONNECTOR COULD BECOME CONTAMINATED AND MALFUNCTION SUCH THAT THE FRONT PASSENGER AIRBAG WILL DEPLOY REGARDLESS OF THE WEIGHT OF THE OCCUPANT.
Consequence & remedy
Consequence: THE FRONT PASSENGER AIR BAG COULD DEPLOY IN CRASHES IN WHICH IT SHOULD NOT DEPLOY, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT FROM THE DEPLOYED AIR BAG.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE WEIGHT CLASSIFICATION SYSTEM CONNECTOR TO PREVENT CONTAMINATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTING TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Mar 15, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2008 ELANTRA VEHICLES MANUFACTURED FROM JULY 14, 2006, THROUGH AUGUST 29, 2007. THE DRIVER'S SEAT TRACK POSITION SENSOR DETERMINES THE SEAT'S FORE AND AFT POSITION AND ALLOWS THE DRIVER'S FRONTAL AIR BAG TO DEPLOY AT THE PRESSURE APPROPRIATE FOR THAT SEATING POSITION, WITH A LOWER PRESSURE DEPLOYMENT IN THE MOST FORWARD SEATING POSITIONS. THE AIR BAG CONTROL MODULE MAY RECEIVE AN UNSTABLE ELECTRICAL SIGNAL FROM THE SEAT TRACK POSITION SENSOR SUCH THAT, IN A CRASH THAT REQUIRES DRIVER FRONTAL AIRBAG DEPLOYMENT, THE DRIVER'S AIRBAG MAY DEPLOY AT THE HIGHER PRESSURE THAN INTENDED IF THE SEAT WAS POSITION IN ONE OF THE FORWARD POSITIONS IN WHICH A LOWER PRESSURE DEPLOYMENT IS INTENDED.
Consequence & remedy
Consequence: A HIGHER PRESSURE DEPLOYMENT THAN INTENDED INCREASES THE RISK OF INJURY RESULTING FROM AIRBAG DEPLOYMENT.
Remedy: DEALERS WILL REPROGRAM THE AIR BAG CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTING TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Dec 29, 2008
HYUNDAI DE PUERTO RICO (HPR) IS RECALLING 347 MY 2008 ELANTRA VEHICLES. THE FUEL PUMP MOTOR MAY NOT HAVE THE PROPER, UNIFORM INTERNAL ELECTRICAL SURFACE CONTACT. THIS MAY CAUSE THE FUEL PUMP TO PRODUCE LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM.
Consequence & remedy
Consequence: AS A RESULT, POOR ENGINE STARING AND HESITATION MAY RESULT. OTHER ENGINE PERFORMANCE ISSUES MAY ALSO RESULT AND LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE VEHICLE'S FUEL PUMP SUBASSEMBLY. THE RECALL BEGAN ON FEBRUARY 9, 2009. OWNERS MAY CONTACT HPR AT 1-800-981-0188.
Aug 25, 2008
HYUNDAI IS RECALLING 65,000 MY 2008 ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES. THE FUEL PUMP MOTOR MAY NOT HAVE THE PROPER UNIFORM INTERNAL ELECTRICAL SURFACE CONTACT. THIS MAY CAUSE THE FUEL PUMP TO PRODUCE LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM.
Consequence & remedy
Consequence: POOR ENGINE STARTING AND HESITATION MAY RESULT. OTHER ENGINE PERFORMANCE ISSUES MAY ALSO RESULT INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP SUBASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
PE08044 · Engine Stalling - Fuel Pump Failure
Opened Jul 17, 2008 · Closed Sep 3, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:fuel Pump
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Fuel System, Gasoline
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Illustration