NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
314 reportsMileage unknown · Sep 15, 2023
Electrical System
We received a citation for brake lights not functioning. I realized that there had been a safety recall on the brake light switch, and contacted Brandfon Hyundai in New Haven, CT. They did nothing. Upon further investigation on the Hyundai website, I noticed that the brake light switch campaign was marked "closed" in 2013, when…
Read full complaint
We received a citation for brake lights not functioning. I realized that there had been a safety recall on the brake light switch, and contacted Brandfon Hyundai in New Haven, CT. They did nothing. Upon further investigation on the Hyundai website, I noticed that the brake light switch campaign was marked "closed" in 2013, when the car was still owned by my mother-in-law whom has since gone blind and has sold the car to us. I took it upon myself to purchase and install a new brake light switch, and all new bulbs, but to no avail. Not only are we likely to get cited again, but having no brake lights is a safety hazard. At first, it was only the right side brake light out. Then the brake lights would stay on by themselves. Now, not even the rear window light, which should go on without the signal going through the computer, will go on.
NHTSA ODI #11544715
Mileage unknown · Jul 12, 2023
Air BagsInjury
While making a U-turn in a parking lot I accidentally ran over a pothole. Upon doing so the driver's airbag deployed burning a hole through my shirt and leaving burns on my stomach and arms. No other part of the vehicle was affected.
NHTSA ODI #11531753
Mileage unknown · Jul 7, 2023
Unknown Or Other
This unit was purchased from RockAuto in July 2023; they sent another defective product. When the rear engine mount was installed on the subframe--one bolt was not getting tight and a bolt inside the unit was already broken. This may have caused the disjointed connection for this rear engine mount.
NHTSA ODI #11530965
Mileage unknown · Jul 7, 2023
Suspension
The sway bar was received in July 2023 and the sway bar was manufactured too short to fit the suspension of the 2008 Hyundai Elantra. The vendor was RockAuto and this is another defective product they sent.
NHTSA ODI #11530963
127,000 miles · Jul 6, 2023
Engine And Engine Cooling
The contact owns a 2008 Hyundai Elantra. The contact stated that while idling at a stop sign, the RPMs dropped extremely low, and the vehicle stalled. After a visual inspection, the contact observed white smoke coming from the engine compartment and a coolant leak underneath the vehicle. Upon restarting the vehicle, the vehicle …
Read full complaint
The contact owns a 2008 Hyundai Elantra. The contact stated that while idling at a stop sign, the RPMs dropped extremely low, and the vehicle stalled. After a visual inspection, the contact observed white smoke coming from the engine compartment and a coolant leak underneath the vehicle. Upon restarting the vehicle, the vehicle seemed to return to normal functionality. The contact stated that the failure became a regular issue over the next 6 months. No warning lights were illuminated on the instrument panel. The vehicle was taken to an independent mechanic, who was unable to determine the cause of the failure. Later, the vehicle was taken to a second independent mechanic, who also failed to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 127,000.
NHTSA ODI #11530639
Mileage unknown · Jul 2, 2023
Unknown Or Other
The company, RockAuto, knowingly has many content quality errors describing automobile parts. This is a general safety concern to the general public because my rack and pinion set initially on the website said it came with both inner as well as outer tie rods. The rack and pinion set only came with inner tie rods with outer tie …
Read full complaint
The company, RockAuto, knowingly has many content quality errors describing automobile parts. This is a general safety concern to the general public because my rack and pinion set initially on the website said it came with both inner as well as outer tie rods. The rack and pinion set only came with inner tie rods with outer tie rods to be purchased separately. The company refunded the outer tie rods by giving a store credit.
NHTSA ODI #11529994
Mileage unknown · Mar 24, 2023
EngineUnknown Or OtherFire
When removing the key from the ignition, the cars engine was still running, as I was unable to turn the vehicle off. After a few tries the car was off and the engine stopped. I drove 1/2 mile, smelled something burning, looked down and saw smoke coming up from my lap area, and immediately turned the car off and jumped out of the…
Read full complaint
When removing the key from the ignition, the cars engine was still running, as I was unable to turn the vehicle off. After a few tries the car was off and the engine stopped. I drove 1/2 mile, smelled something burning, looked down and saw smoke coming up from my lap area, and immediately turned the car off and jumped out of the vehicle..The engine continued to run while the key was removed... Car was eventually towed by Insurance Company tow company to the Factory Authorized service center
NHTSA ODI #11513588
Mileage unknown · Dec 31, 2022
EnginePower Train
2008 Elantra should be added to the crankshaft Theta II recall. 2098 Elantra has the 2.0L engine unlike its prior years where they are made with a 1.6L engine. Last week my 2008 Elantra exhibited all the signs of this malfunction (A knocking noise from the engine that increases in frequency as the engine rpm increases. Reduced…
Read full complaint
2008 Elantra should be added to the crankshaft Theta II recall. 2098 Elantra has the 2.0L engine unlike its prior years where they are made with a 1.6L engine. Last week my 2008 Elantra exhibited all the signs of this malfunction (A knocking noise from the engine that increases in frequency as the engine rpm increases. Reduced power and/or hesitation and vibration. Illumination of the “check engine” light in the instrument cluster. Illumination of the “engine oil pressure” warning lamp.) When this occured i had taken it to Auto Zone and had the computer scanned for error codes. (See attached report). Based on the report a tune up was done, ignition coil replaced and sensor replaced. Car would still not start. When my mechanic furthe diagnosed it (he could not find the issue until he used his scope camera)he found the issue was that there is damage to the "trigger wheel" inside the crank shaft. He also said this almost never happens in a car and does not know what could have made this happen. Please investigate this issue further, this is a dangerous situation of engine seizing and should be investigated immediately and thoroughly.
NHTSA ODI #11499650
Mileage unknown · Nov 1, 2022
Suspension
2 brake lines rusted through causing me to loose my brakes. Had the car towed to my local garage. I just got a call today letting me know that my trailing or control arm is severely rusted and has a hole. This happened before, 11/1/2017 and the car collapsed. This was covered last time under the Salt Belt Corrosion Class Ac…
Read full complaint
2 brake lines rusted through causing me to loose my brakes. Had the car towed to my local garage. I just got a call today letting me know that my trailing or control arm is severely rusted and has a hole. This happened before, 11/1/2017 and the car collapsed. This was covered last time under the Salt Belt Corrosion Class Action Settlement. Hyundai is aware there is still a problem, but the undercoating recall does not work and this is still a safety hazard and it may be the exact same part. I have called Torrington Hyundai and am waiting for the manager to call back and also called Hyundai Customer Care and new case was opened #20523632. I was told it would be 2 to 5 days to be contacted by National Consumer Affairs. I am without a car again and need this resolved immediately. This has been so dangerous, my son and I could have been killed!
NHTSA ODI #11491798
200,000 miles · Oct 5, 2022
Parking BrakeService Brakes
The contact owns a 2008 Hyundai Elantra. The contact stated that while driving at an undisclosed speed, the ABS system locked up. While in the parking lot, the vehicle was smoking. Additionally, while starting the vehicle, there was an abnormal high pitch winding noise detected. The parking and ABS warning lights were illuminate…
Read full complaint
The contact owns a 2008 Hyundai Elantra. The contact stated that while driving at an undisclosed speed, the ABS system locked up. While in the parking lot, the vehicle was smoking. Additionally, while starting the vehicle, there was an abnormal high pitch winding noise detected. The parking and ABS warning lights were illuminated. The vehicle was taken to the local dealer who informed him they were not equipped to service the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 200,000.
NHTSA ODI #11488066
Official recalls
7Feb 4, 2020
Hyundai Motor America (Hyundai) is recalling certain 2007-2010 Elantra and 2009-2011 Elantra Touring vehicles. On February 21, 2020 Hyundai expanded the recall to include 46,425 model year 2007-2008 Entourage and 2007 Santa Fe vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence & remedy
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.
Remedy: Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began April 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 188.
Feb 23, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2008-2010 Elantra vehicles manufactured June 1, 2008, to April 30, 2010, and 2009-2010 Elantra Touring vehicles manufactured November 1, 2008, to April 30, 2010. The electronic power steering (EPS) electronic control unit (ECU) may sense a discrepancy in the steering input signals and, as a result, disable the steering power assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Hyundai will verify the proper operation of the Electronic Power Steering (EPS) and update the EPS control unit, free of charge. The recall began April 14, 2015. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 127.
Apr 1, 2013
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Mar 15, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2009 ELANTRA VEHICLES MANUFACTURED FROM JULY 14, 2006, THROUGH NOVEMBER 1, 2008. THE FRONT PASSENGER SEATS IN THE VEHICLES CONTAIN A WEIGHT SENSOR DESIGNED TO DEACTIVATE THE RIGHT FRONTAL AIRBAG WHEN OCCUPANTS OF CERTAIN WEIGHTS OCCUPY THE SEAT. THE ELECTRICAL CONNECTOR FOR THE WEIGHT SENSOR IS LOCATED UNDER THE CENTER CONSOLE, BETWEEN THE FRONT SEATS. UNDER CERTAIN CIRCUMSTANCES THE CONNECTOR COULD BECOME CONTAMINATED AND MALFUNCTION SUCH THAT THE FRONT PASSENGER AIRBAG WILL DEPLOY REGARDLESS OF THE WEIGHT OF THE OCCUPANT.
Consequence & remedy
Consequence: THE FRONT PASSENGER AIR BAG COULD DEPLOY IN CRASHES IN WHICH IT SHOULD NOT DEPLOY, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT FROM THE DEPLOYED AIR BAG.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE WEIGHT CLASSIFICATION SYSTEM CONNECTOR TO PREVENT CONTAMINATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTING TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Mar 15, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2008 ELANTRA VEHICLES MANUFACTURED FROM JULY 14, 2006, THROUGH AUGUST 29, 2007. THE DRIVER'S SEAT TRACK POSITION SENSOR DETERMINES THE SEAT'S FORE AND AFT POSITION AND ALLOWS THE DRIVER'S FRONTAL AIR BAG TO DEPLOY AT THE PRESSURE APPROPRIATE FOR THAT SEATING POSITION, WITH A LOWER PRESSURE DEPLOYMENT IN THE MOST FORWARD SEATING POSITIONS. THE AIR BAG CONTROL MODULE MAY RECEIVE AN UNSTABLE ELECTRICAL SIGNAL FROM THE SEAT TRACK POSITION SENSOR SUCH THAT, IN A CRASH THAT REQUIRES DRIVER FRONTAL AIRBAG DEPLOYMENT, THE DRIVER'S AIRBAG MAY DEPLOY AT THE HIGHER PRESSURE THAN INTENDED IF THE SEAT WAS POSITION IN ONE OF THE FORWARD POSITIONS IN WHICH A LOWER PRESSURE DEPLOYMENT IS INTENDED.
Consequence & remedy
Consequence: A HIGHER PRESSURE DEPLOYMENT THAN INTENDED INCREASES THE RISK OF INJURY RESULTING FROM AIRBAG DEPLOYMENT.
Remedy: DEALERS WILL REPROGRAM THE AIR BAG CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTING TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Dec 29, 2008
HYUNDAI DE PUERTO RICO (HPR) IS RECALLING 347 MY 2008 ELANTRA VEHICLES. THE FUEL PUMP MOTOR MAY NOT HAVE THE PROPER, UNIFORM INTERNAL ELECTRICAL SURFACE CONTACT. THIS MAY CAUSE THE FUEL PUMP TO PRODUCE LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM.
Consequence & remedy
Consequence: AS A RESULT, POOR ENGINE STARING AND HESITATION MAY RESULT. OTHER ENGINE PERFORMANCE ISSUES MAY ALSO RESULT AND LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE VEHICLE'S FUEL PUMP SUBASSEMBLY. THE RECALL BEGAN ON FEBRUARY 9, 2009. OWNERS MAY CONTACT HPR AT 1-800-981-0188.
Aug 25, 2008
HYUNDAI IS RECALLING 65,000 MY 2008 ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES. THE FUEL PUMP MOTOR MAY NOT HAVE THE PROPER UNIFORM INTERNAL ELECTRICAL SURFACE CONTACT. THIS MAY CAUSE THE FUEL PUMP TO PRODUCE LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM.
Consequence & remedy
Consequence: POOR ENGINE STARTING AND HESITATION MAY RESULT. OTHER ENGINE PERFORMANCE ISSUES MAY ALSO RESULT INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP SUBASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
PE08044 · Engine Stalling - Fuel Pump Failure
Opened Jul 17, 2008 · Closed Sep 3, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:fuel Pump
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Fuel System, Gasoline
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Illustration