NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
32 reportsClear category filter20,000 miles · Apr 16, 2014
Exterior LightingService Brakes
TL* THE CONTACT OWNS A 2008 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE BRAKE LIGHT WAS CONTINUOUSLY BURNING OUT. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER RECALL NHTSA CAMPAIGN NUMBER: 13V113000 (EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN VERIF…
Read full complaint
TL* THE CONTACT OWNS A 2008 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE BRAKE LIGHT WAS CONTINUOUSLY BURNING OUT. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER RECALL NHTSA CAMPAIGN NUMBER: 13V113000 (EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN VERIFIED THE FAILURE AND REPLACED THE BRAKE LAMP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 30,000.
NHTSA ODI #10583178
44,500 miles · Mar 29, 2014
Service BrakesVehicle Speed Control
THE GAS PEDAL GOT "STUCK" IN THE DOWN POSITION WHILE DRIVING, RESULTING IN A PROBLEM BEING ABLE TO STOP THE VEHICLE. I WAS GOING APPROXIMATELY 45-50 MPH, PASSING/MERGING/ACCELERATING IN ORDER TO GET ONTO AN ONRAMP WHICH CURVED SLIGHTLY TO GO INTO ANOTHER MAIN HIGHWAY. WHEN I PRESSED ON THE BRAKES TO SLOW DOWN A BIT FOR THE RAMP,…
Read full complaint
THE GAS PEDAL GOT "STUCK" IN THE DOWN POSITION WHILE DRIVING, RESULTING IN A PROBLEM BEING ABLE TO STOP THE VEHICLE. I WAS GOING APPROXIMATELY 45-50 MPH, PASSING/MERGING/ACCELERATING IN ORDER TO GET ONTO AN ONRAMP WHICH CURVED SLIGHTLY TO GO INTO ANOTHER MAIN HIGHWAY. WHEN I PRESSED ON THE BRAKES TO SLOW DOWN A BIT FOR THE RAMP, NOTHING HAPPENED. MY CAR CONTINUED TO GO AT THE SAME SPEED. I CONTINUED TO BRAKE, AND THE CAR WOULD NOT SLOW DOWN. I SLID MY FOOT OVER THE GAS PEDAL AND COULD TELL IT WAS STILL COMPLETELY "DOWN" AND MAKING THE CAR ACCELERATE AT FULL CAPACITY. I THEN GLANCED DOWN TO CONFIRM THAT THE PEDAL WAS STUCK IN THE DOWNWARD POSITION. THERE WAS NOTHING UNDER THE PEDAL, THE FLOOR MAT WAS NOT STUCK UNDERNEATH, NOR WAS IT ANYWHERE NEAR WHERE THE PEDAL WAS PRESSED DOWN. I CLICKED MY HAZARDS ON DURING THE PROCESS BECAUSE SINCE IT WAS AN ONRAMP, THERE WAS NOWHERE TO PULL OVER. AS I CONTINUOUSLY PRESSED ON THE BRAKES, THE CAR ONLY SLOWED DOWN APPROXIMATELY 3-5 MPH TOTAL, BECAUSE THE GAS PEDAL WAS STUCK ALL THE WAY DOWN, THEREFORE THE BRAKES WERE TRYING TO WORK AGAINST THE FULL POWER OF THE ACCELERATION. ONCE THE PASSENGER REALIZED WHAT WAS HAPPENING, HE HELPED BY PUTTING THE CAR IN NEUTRAL. THIS HELPED SLOW THE CAR, AND I THEN PULLED THE EMERGENCY BRAKE. THE CAR CAME TO A STOP IN THE MIDDLE OF A MAIN HIGHWAY ONRAMP. THE CARS BEHIND ME WERE ABLE TO REACT QUICK ENOUGH TO GO AROUND AND NOT HIT THE CAR. I TRIED TO REPLICATE THE PROBLEM IN ORDER TO HELP DIAGNOSE THIS ISSUE AND HAVE MORE INFORMATION TO TELL HYUNDAI. ONCE ON A STRAIGHTAWAY WITHOUT OTHER CARS NEARBY, I PRESSED THE GAS PEDAL ALL THE WAY DOWN, AND SURE ENOUGH I WAS ABLE TO RECREATE THE ISSUE AND THE PEDAL GOT STUCK AGAIN. UPON TRYING TO RECREATE IT A 3RD TIME, IT DID NOT GET STUCK AND SEEMED TO BE WORKING PROPERLY. BUT IT DID GET STUCK 2 OUT OF THE 3 TIMES. IT WAS TERRIFYING TO NOT BE ABLE TO STOP. *TR
NHTSA ODI #10575641
89,000 miles · Mar 12, 2014
Service Brakes
THE ABS WARNING LIGHT WAS NOTED TO BE ON CONTINUOUSLY FOR MORE THAN A WEEK. THE PROBLEM WAS TRACED TO A BROKEN WIRE IN THE MAIN ENGINE HARNESS. THERE WAS NO NOTICEABLE CHANGE IN PERFORMANCE OF THE VEHICLE. *TR
NHTSA ODI #10568726
80,000 miles · Oct 30, 2013
Service BrakesCrashInjury
IF SOMEONE HAD NOTIFIED ME ABOUT MY NEW CAR AND ITS PROBLEMS I WOULD OF NOT BEEN IN THREE DIFFERENT ACCIDENTS FRONT END ALL OF THEM AND CHECK FOR YOUR SELF MY RECORD IN DRIVING WAS PERFECT LAST TEN YEARS OR MORE WHEN I HAD MY OLDER CAR IN YEAR AND NO ACCIDENTS .. HI I HAVE BEEN IN MULTIPLE ACCIDENTS AFTER I BOUGHT THIS CAR IN DE…
Read full complaint
IF SOMEONE HAD NOTIFIED ME ABOUT MY NEW CAR AND ITS PROBLEMS I WOULD OF NOT BEEN IN THREE DIFFERENT ACCIDENTS FRONT END ALL OF THEM AND CHECK FOR YOUR SELF MY RECORD IN DRIVING WAS PERFECT LAST TEN YEARS OR MORE WHEN I HAD MY OLDER CAR IN YEAR AND NO ACCIDENTS .. HI I HAVE BEEN IN MULTIPLE ACCIDENTS AFTER I BOUGHT THIS CAR IN DEC OF 2012 A FEW MONTHS GOES BY AND I WAS ON MY WAY HOME FROM WORK ,, KEEP IN MIND BEFORE I HAD A JETTA OLD MODEL NO ACCIDENTS SINCE THE DAY I GOT MY LICENSE .. I FELT WHEN I TRIED TO JAM ON BRAKES TO NOT GET IN ACCIDENT MY BRAKES STOP ALITTLE BUT LUNGED FORWARD I PUSHED VERY HARD STILL AGAIN STOP LUNGED FORWARD .. NOT EVEN A MONTH AFTER IT WAS FIXED AND I SPRAINED MY NECK ANOTHER FRONT END DAMAGE OCCURRED BRAKES AT FAULT BECAUSE PUSHED HARD TO STOP IN SUDDEN ISN'T WORKING PROPERLY I HAVEN'T BEEN NOTIFIED ABOUT ANY DEFECTS OR ANYTHING THAT WOULD LET ME THINK BREAKS ARE NOT PERFECT AS THEY SHOULD BE .. I HAD A PERFECT DRIVING RECORD SINCE I WAS SIXTEEN FOR THE MOST PART LAST TEN YRS NO ACCIDENTS . BUT AS SOON AS I PURCHASE THIS ELANTRA THREE ACCIDENTS I WILL NOT BE PUNISHED FOR REASON I WAS NEVER NOTIFIED OF RECALLS . *TR
NHTSA ODI #10550101
78,000 miles · Aug 30, 2013
EngineService Brakes
THE CRUISE CONTROL ON HYUNDAI ELANTRA FAILED TO DISENGAGE WHILE I DRIVING ON HIGHWAY AT 70 MPH DESPITE REPEATEDLY PUSHING THE "CANCEL" AND "OFF" BUTTONS. FIRM BRAKING ALSO FAILED TO DISENGAGE THE CRUISE CONTROL. I MANAGED TO STOP ONLY AFTER PULLING THE EMERGENCY BRAKE AND APPLYING HEAVY/MAXIMUM BRAKING. SMOKE. TIRES DESTROYE…
Read full complaint
THE CRUISE CONTROL ON HYUNDAI ELANTRA FAILED TO DISENGAGE WHILE I DRIVING ON HIGHWAY AT 70 MPH DESPITE REPEATEDLY PUSHING THE "CANCEL" AND "OFF" BUTTONS. FIRM BRAKING ALSO FAILED TO DISENGAGE THE CRUISE CONTROL. I MANAGED TO STOP ONLY AFTER PULLING THE EMERGENCY BRAKE AND APPLYING HEAVY/MAXIMUM BRAKING. SMOKE. TIRES DESTROYED. SCARY! MY CHILD AND I ALMOST DIED. THE ABS AND ESC OFF LIGHTS CAME ON AND REMAINED ON. KIA AND HYUNDAI RECENTLY RECALLED 1.9 MILLION VEHICLES TO FIX THIS ISSUE. HOWEVER, THIS INCIDENT SUGGESTS THAT HYUNDAI HAS NOT FIXED THE PROBLEM BECAUSE MY CAR HAD THE RECALL PROCEDURE COMPLETED ONE MONTH PRIOR TO THE INCIDENT OCCURING.
NHTSA ODI #10538151
189,148 miles · May 18, 2013
Air BagsElectronic Stability Control (esc)Service BrakesCrashInjury
TRAVELING 38-40 MPH DAMP ROAD, SWERVED TO MISS ANIMAL. FISH TAIL, SPUN APPROXIMATELY 270 DEGREES; HIT TREE ON PASSENGER SIDE DOOR; BROKE PASSENGER WINDOW. PUSHED FORWARD, HIT TREE IN FRONT QUARTER PANEL PASSENGER SIDE THEN AGAIN HIT TREE DIRECTLY FRONT CENTER OF CAR. ESC DID NOT WORK (RECEIVED ESC RECALL WHEN GOT HOME FROM AC…
Read full complaint
TRAVELING 38-40 MPH DAMP ROAD, SWERVED TO MISS ANIMAL. FISH TAIL, SPUN APPROXIMATELY 270 DEGREES; HIT TREE ON PASSENGER SIDE DOOR; BROKE PASSENGER WINDOW. PUSHED FORWARD, HIT TREE IN FRONT QUARTER PANEL PASSENGER SIDE THEN AGAIN HIT TREE DIRECTLY FRONT CENTER OF CAR. ESC DID NOT WORK (RECEIVED ESC RECALL WHEN GOT HOME FROM ACCIDENT); BRAKES LOCKED UP (ABS DIDN'T WORK); NEITHER FRONT OR SIDE AIRBAGS DEPLOYED. CAR TOTALED: DAMAGE TO FRONT BUMPER; ENGINE HOOD; FRONT WINDSHIELD; PASSENGER DOOR; PASSENGER WINDOW; FRONT PASSENGER TIRE BENT IN TOWARDS CAR. PASSENGER RECEIVED LACERATIONS FROM BROKEN GLASS, DRIVER & PASSENGER RECEIVED SEVERAL BUMPS, BRUISES, SORE NECKS, SORE BACKS. HAVE ANOTHER HYUNDAI WITH INTERMITTENT TPS LIGHT - DEALER WONT FIX... HUGE CONCERN WITH SAFETY! *TR
NHTSA ODI #10512651
77,951 miles · Apr 3, 2013
Exterior LightingService Brakes
CAR FOLLOWING ME NOTIFIED ME THAT MY BRAKE LIGHTS WERE NOT WORKING ON MY 2008 HYUNDAI ELANTRA. I HAVE CHANGE MY BRAKE BULBS 3 TIMES LAST YEAR AND 1 TIME BEGING OF THIS YEAR. STOP AND CHECK ALL MY BULBS AND FUSE THEY WERE IN GOOD CONDITION. I CALLED HYUNDAI CUSTOMER CARE AND WAS TOLD THAT 2008 ELANTRA'S WERE NOT COVERED BY THEIR …
Read full complaint
CAR FOLLOWING ME NOTIFIED ME THAT MY BRAKE LIGHTS WERE NOT WORKING ON MY 2008 HYUNDAI ELANTRA. I HAVE CHANGE MY BRAKE BULBS 3 TIMES LAST YEAR AND 1 TIME BEGING OF THIS YEAR. STOP AND CHECK ALL MY BULBS AND FUSE THEY WERE IN GOOD CONDITION. I CALLED HYUNDAI CUSTOMER CARE AND WAS TOLD THAT 2008 ELANTRA'S WERE NOT COVERED BY THEIR RECALL FOR THIS PROBLEM, THAT I WOULD HAVE TO BRING THE CAR IN FOR A DIGNOSTIC THAT WILL COST $110. THEY TOLD ME THAT EVEN IF THEIR WERE A RECALL, THE RECALL DOES NOT AFFECT MY CAR AND IS NOT IN THEIR DATABASE. *TR
NHTSA ODI #10505523
102,043 miles · Mar 21, 2013
Exterior LightingService Brakes
CAR FOLLOWING ME NOTIFIED ME THAT THE BRAKE LIGHTS WERE NOT WORKING ON MY 2008 HYUNDAI ELANTRA. STOP LAMP FUSE I WAS CHECKED AND WAS GOOD AS WELL AS BOTH REAR STOP LAMP BULBS. I INSPECTED THE BRAKE LAMP SWITCH NEAR THE BRAKE AND FOUND IT TO STUCK IN THE OFF POSITION. AFTER PRESSING THE SWITCH SEVERAL TIMES THE SWITCH WORKED FOR …
Read full complaint
CAR FOLLOWING ME NOTIFIED ME THAT THE BRAKE LIGHTS WERE NOT WORKING ON MY 2008 HYUNDAI ELANTRA. STOP LAMP FUSE I WAS CHECKED AND WAS GOOD AS WELL AS BOTH REAR STOP LAMP BULBS. I INSPECTED THE BRAKE LAMP SWITCH NEAR THE BRAKE AND FOUND IT TO STUCK IN THE OFF POSITION. AFTER PRESSING THE SWITCH SEVERAL TIMES THE SWITCH WORKED FOR A FEW TIMES AND THEN STUCK IN THE ON POSITION. I CALLED HYUNDAI CUSTOMER CARE AND WAS TOLD THAT 2008 ELANTRA'S WERE NOT COVERED BY THEIR RECALL FOR THIS PROBLEM AND THEY WOULD PAY FOR REPAIR. *TR
NHTSA ODI #10503967
23,950 miles · Mar 2, 2013
EngineService BrakesVehicle Speed Control
WHILE DRIVING IN HEAVY TRAFFIC, INCHING ALONG AT LOW SPEED FOR ABOUT 1/2 MILES; STOPPING AND STARTING ALL THE WAY, SUDDENLY DURING ONE OF THESE STOPS, THE MOTOR STARTED TO REV AND THE CAR ACCELERATED ON ITS OWN. HAD TO BRAKE HARD TO AVOID HITTING THE CAR IN FRONT OF ME. ABOUT 10 MINUTES LATER, WHILE PARKING THE CAR IN A PARKING…
Read full complaint
WHILE DRIVING IN HEAVY TRAFFIC, INCHING ALONG AT LOW SPEED FOR ABOUT 1/2 MILES; STOPPING AND STARTING ALL THE WAY, SUDDENLY DURING ONE OF THESE STOPS, THE MOTOR STARTED TO REV AND THE CAR ACCELERATED ON ITS OWN. HAD TO BRAKE HARD TO AVOID HITTING THE CAR IN FRONT OF ME. ABOUT 10 MINUTES LATER, WHILE PARKING THE CAR IN A PARKING SPACE, THE SAME THING HAPPENED. I HAD ALREADY STOPPED AND WAS PUTTING THE CAR IN PARK. I TOOK THE CAR TO THE LOCAL HYUNDAI GARAGE WHERE THEY DID ROAD TESTING. COMPUTER TESTS SHOWED NO CODES; SO NO REPAIRS WERE MADE. WHEN THE TECH LINE OF THE MANUFACTURER WAS CONTACTED ON THIS MATTER WAS TOLD THAT THERE WERE NO CASES RELATING TO THIS PROBLEM ON FILE. HAVE HAD THIS PROBLEM SPORADICALLY SINCE 2010. LAST REPORTED AN ACCELERATION PROBLEM TO THE HYUNDAI GARAGE EARLY IN THE MONTH OF DECEMBER 2012. NO ONE AT HYUNDAI WANTS TO HELP ME. *TR
NHTSA ODI #10501067
72,000 miles · Feb 13, 2013
Electrical SystemService Brakes
ON 02/12/2013 I OBSERVED THE BRAKES LIGHTS ON MY 2008 HYUNDAI ELANTRA TO BE OUT. I CHECKED THE FUSES, ALL WERE GOOD. A PRIVATE MECHANIC CHECKED AND STATED THE STOP LIGHT SWITCH WAS BAD AND WOULD NEED TO BE REPLACED. *TR
NHTSA ODI #10497974
Official recalls
7Feb 4, 2020
Hyundai Motor America (Hyundai) is recalling certain 2007-2010 Elantra and 2009-2011 Elantra Touring vehicles. On February 21, 2020 Hyundai expanded the recall to include 46,425 model year 2007-2008 Entourage and 2007 Santa Fe vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence & remedy
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.
Remedy: Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began April 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 188.
Feb 23, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2008-2010 Elantra vehicles manufactured June 1, 2008, to April 30, 2010, and 2009-2010 Elantra Touring vehicles manufactured November 1, 2008, to April 30, 2010. The electronic power steering (EPS) electronic control unit (ECU) may sense a discrepancy in the steering input signals and, as a result, disable the steering power assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Hyundai will verify the proper operation of the Electronic Power Steering (EPS) and update the EPS control unit, free of charge. The recall began April 14, 2015. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 127.
Apr 1, 2013
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Mar 15, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2009 ELANTRA VEHICLES MANUFACTURED FROM JULY 14, 2006, THROUGH NOVEMBER 1, 2008. THE FRONT PASSENGER SEATS IN THE VEHICLES CONTAIN A WEIGHT SENSOR DESIGNED TO DEACTIVATE THE RIGHT FRONTAL AIRBAG WHEN OCCUPANTS OF CERTAIN WEIGHTS OCCUPY THE SEAT. THE ELECTRICAL CONNECTOR FOR THE WEIGHT SENSOR IS LOCATED UNDER THE CENTER CONSOLE, BETWEEN THE FRONT SEATS. UNDER CERTAIN CIRCUMSTANCES THE CONNECTOR COULD BECOME CONTAMINATED AND MALFUNCTION SUCH THAT THE FRONT PASSENGER AIRBAG WILL DEPLOY REGARDLESS OF THE WEIGHT OF THE OCCUPANT.
Consequence & remedy
Consequence: THE FRONT PASSENGER AIR BAG COULD DEPLOY IN CRASHES IN WHICH IT SHOULD NOT DEPLOY, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT FROM THE DEPLOYED AIR BAG.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE WEIGHT CLASSIFICATION SYSTEM CONNECTOR TO PREVENT CONTAMINATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTING TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Mar 15, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2008 ELANTRA VEHICLES MANUFACTURED FROM JULY 14, 2006, THROUGH AUGUST 29, 2007. THE DRIVER'S SEAT TRACK POSITION SENSOR DETERMINES THE SEAT'S FORE AND AFT POSITION AND ALLOWS THE DRIVER'S FRONTAL AIR BAG TO DEPLOY AT THE PRESSURE APPROPRIATE FOR THAT SEATING POSITION, WITH A LOWER PRESSURE DEPLOYMENT IN THE MOST FORWARD SEATING POSITIONS. THE AIR BAG CONTROL MODULE MAY RECEIVE AN UNSTABLE ELECTRICAL SIGNAL FROM THE SEAT TRACK POSITION SENSOR SUCH THAT, IN A CRASH THAT REQUIRES DRIVER FRONTAL AIRBAG DEPLOYMENT, THE DRIVER'S AIRBAG MAY DEPLOY AT THE HIGHER PRESSURE THAN INTENDED IF THE SEAT WAS POSITION IN ONE OF THE FORWARD POSITIONS IN WHICH A LOWER PRESSURE DEPLOYMENT IS INTENDED.
Consequence & remedy
Consequence: A HIGHER PRESSURE DEPLOYMENT THAN INTENDED INCREASES THE RISK OF INJURY RESULTING FROM AIRBAG DEPLOYMENT.
Remedy: DEALERS WILL REPROGRAM THE AIR BAG CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTING TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Dec 29, 2008
HYUNDAI DE PUERTO RICO (HPR) IS RECALLING 347 MY 2008 ELANTRA VEHICLES. THE FUEL PUMP MOTOR MAY NOT HAVE THE PROPER, UNIFORM INTERNAL ELECTRICAL SURFACE CONTACT. THIS MAY CAUSE THE FUEL PUMP TO PRODUCE LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM.
Consequence & remedy
Consequence: AS A RESULT, POOR ENGINE STARING AND HESITATION MAY RESULT. OTHER ENGINE PERFORMANCE ISSUES MAY ALSO RESULT AND LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE VEHICLE'S FUEL PUMP SUBASSEMBLY. THE RECALL BEGAN ON FEBRUARY 9, 2009. OWNERS MAY CONTACT HPR AT 1-800-981-0188.
Aug 25, 2008
HYUNDAI IS RECALLING 65,000 MY 2008 ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES. THE FUEL PUMP MOTOR MAY NOT HAVE THE PROPER UNIFORM INTERNAL ELECTRICAL SURFACE CONTACT. THIS MAY CAUSE THE FUEL PUMP TO PRODUCE LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM.
Consequence & remedy
Consequence: POOR ENGINE STARTING AND HESITATION MAY RESULT. OTHER ENGINE PERFORMANCE ISSUES MAY ALSO RESULT INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP SUBASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
PE08044 · Engine Stalling - Fuel Pump Failure
Opened Jul 17, 2008 · Closed Sep 3, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:fuel Pump
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Fuel System, Gasoline
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Illustration