NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
36 reportsClear category filter172,600 miles · Apr 21, 2025
Fuel System, Gasoline
The contact owns a 2008 Hyundai Elantra. The contact stated while driving 30 MPH, the vehicle started jerking and stalled. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who diagnosed the vehicle with fuel pump failure. The contact stated that the vehicle stalled intermittently. The ve…
Read full complaint
The contact owns a 2008 Hyundai Elantra. The contact stated while driving 30 MPH, the vehicle started jerking and stalled. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who diagnosed the vehicle with fuel pump failure. The contact stated that the vehicle stalled intermittently. The vehicle was not repaired. The dealer was not made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 172,600.
NHTSA ODI #11655889
31,800 miles · Aug 2, 2011
Engine And Engine CoolingFuel System, Gasoline
THE CAR STALLED 6/21/11 AT 7PM ON THE FREEWAY IN 10-20 MILE AN HOUR STOP AND GO TRAFFIC. THE TEMP OUTSIDE WAS MILD, I HAD BEEN ON THE ROAD FOR 20 MIN BEFORE HITTING TRAFFIC, AND BOTH AIR CONDITIONING AND RADIO WERE ON. I WAS IN TRAFFIC APPROX. 10 MIN. I WENT TO TAP THE GAS PEDAL AND NOTHING WAS THERE. I HAD TO GET OUT (ON FREEWA…
Read full complaint
THE CAR STALLED 6/21/11 AT 7PM ON THE FREEWAY IN 10-20 MILE AN HOUR STOP AND GO TRAFFIC. THE TEMP OUTSIDE WAS MILD, I HAD BEEN ON THE ROAD FOR 20 MIN BEFORE HITTING TRAFFIC, AND BOTH AIR CONDITIONING AND RADIO WERE ON. I WAS IN TRAFFIC APPROX. 10 MIN. I WENT TO TAP THE GAS PEDAL AND NOTHING WAS THERE. I HAD TO GET OUT (ON FREEWAY) AND PUSH THE CAR OFF THE ROAD AND ONTO CENTER DIVIDE (NO CALL BOXES). TWO STRANGERS STOPPED AND HELPED ME TO SIDE OF ROAD. AFTER 5 MINUTES I WAS ABLE TO START CAR AND DRIVE HOME. THE CAR STALLED AGAIN ON 7/29/11 IN 10-20 MPH STOP AND GO TRAFFIC AT 5PM. THE TEMP WAS MILD AND I HAD JUST FILLED THE CAR WITH GAS. 15 MINUTES LATER ON THE FREEWAY (STOP AND GO TRAFFIC), WITH AIR CONDITIONER AND RADIO ON, I WENT TO TAP THE GAS PEDAL AND NOTHING WAS THERE. WAS IN TRAFFIC LESS THAN 10 MIN. AGAIN STUCK IN THE MIDDLE OF THE FREEWAY. THIS TIME I DID NOT GET OUT OF THE CAR BUT WAS ATTEMPTING TO CALL FOR HELP WHEN CHP PULLED UP BEHIND ME AND USED HIS CAR TO PUSH ME OFF THE ROAD. I PUT CAR IN NEUTRAL, CHP PUSHED ME OFF THROUGH ENTIRE LANE OF FREEWAY TRAFFIC INTO CENTER DIVIDE. THE BRAKE WOULD NOT WORK. I HAD MY FOOT TO THE FLOOR BUT CAR WAS NOT STOPPING. THE EMERGENCY BRAKE WAS THE ONLY THING THAT KEPT ME FROM ROLLING INTO SIDERAIL. WHILE WE WAITED FOR TOW TRUCK, I ATTEMPTED TO START CAR AND IT STARTED. CHP ESCORTED ME OFF FREEWAY AND I DROVE HOME 5 MIN. AWAY. *KB
NHTSA ODI #10416777
800 miles · Mar 24, 2010
Fuel System, Gasoline
2008 HYUNDAI ELANTRA. CONSUMER STATES VEHICLE HAS A MILEAGE PROBLEM. *TGW WHILE ON A 4,600 MILE TRIP, MOSTLY ON THE INTERSTATE, WITH THE CRUISE CONTROL SET AT 60 MPH, THE AVERAGE MPG WAS ONLY 28 MPG. HYUNDAI INFORMED THE CONSUMER THEY COULD NOT HELP HIM WITH THE MILEAGE. THE EPA FUEL ECONOMY ESTIMATED 33 MPG WITH THE EXPECTED …
Read full complaint
2008 HYUNDAI ELANTRA. CONSUMER STATES VEHICLE HAS A MILEAGE PROBLEM. *TGW WHILE ON A 4,600 MILE TRIP, MOSTLY ON THE INTERSTATE, WITH THE CRUISE CONTROL SET AT 60 MPH, THE AVERAGE MPG WAS ONLY 28 MPG. HYUNDAI INFORMED THE CONSUMER THEY COULD NOT HELP HIM WITH THE MILEAGE. THE EPA FUEL ECONOMY ESTIMATED 33 MPG WITH THE EXPECTED RANGE FOR MOST DRIVERS UP TO 39 MPG. *JB
NHTSA ODI #10321960
19,650 miles · Mar 10, 2010
Fuel System, Gasoline
WHEN WE CALLED TO HYUNDAI MOTOR COMPANY ABOUT THE RECALL CAMPAIGN ON 65000 UNITS HYUNDAI ELANTRA 2008 ASKING WHY WE DID NOT RECEIVE THE NOTIFICATION. THEIR RESPONSE AS FOLLOWS " WE HAVE RECEIVED YOUR EMAIL REGARDING WHEN YOU WILL RECEIVE A RECALL NOTICE FOR YOUR 2008 ELANTRA. AFTER RESEARCHING YOUR CONCERN WE HAVE DETERMINED THA…
Read full complaint
WHEN WE CALLED TO HYUNDAI MOTOR COMPANY ABOUT THE RECALL CAMPAIGN ON 65000 UNITS HYUNDAI ELANTRA 2008 ASKING WHY WE DID NOT RECEIVE THE NOTIFICATION. THEIR RESPONSE AS FOLLOWS " WE HAVE RECEIVED YOUR EMAIL REGARDING WHEN YOU WILL RECEIVE A RECALL NOTICE FOR YOUR 2008 ELANTRA. AFTER RESEARCHING YOUR CONCERN WE HAVE DETERMINED THAT YOUR VEHICLE IS NOT AFFECTED BY CAMPAIGN 086 FOR THE FUEL FILTER. FUEL PUMPS INSTALLED IN VEHICLES PRIOR TO NOVEMBER 5, 2007, AND SINCE JUNE 28, 2008, WERE MANUFACTURED WITH UPPER BODY COMPONENTS THAT MAINTAIN PROPER ARMATURE ALIGNMENT. THE MODELS PRODUCED DURING THAT PRODUCTION DATE RANGE ARE THE ONLY ONES AFFECTED BY THE ARMATURE ALIGNMENT CONDITION. YOUR VEHICLE WAS PRODUCED ON 9/29/2007". OUR CONCLUSION THAT HYUNDAI JUST SCREEN OUT THE DEMAND OF RECALL REPAIRS AND WAIT UNTIL INCIDENT CRASH OCCURRED OR LAW SUIT IF THE FUEL PUMP FAILURE. WHEN I DRIVE ON THE STREET OR FREEWAY, SOMETIMES I FEEL THE VEHICLE IS SLOW DOWN AND JERKING OR JUMP AS NO FUEL INJECTED OR PUMPED PROPERLY IN THE ENGINE DESPITE OF MIDDLE GRADE 98 OCTANE GAS. *TR
NHTSA ODI #10318342
5,200 miles · Aug 6, 2009
Fuel System, Gasoline
MY 2008 HYUNDAI ELANTRA STALLS FREQUENTLY, BUT NOT REPRODUCIBLE, ABOUT ONCE A WEEK. I NOTICE THIS WHEN THE VEHICLE IS TRAVELING AROUND 20-25 MILES/HOUR. INTERNET SEARCH INDICATES THAT OTHERS ARE EXPERIENCING SIMILAR PROBLEM AND A FAULTY FUEL PUMP MAY BE THE ISSUE. *TR
NHTSA ODI #10279564
8,918 miles · Jul 6, 2009
Fuel System, GasolinePower Train
TL*THE CONTACT OWNS A 2008 HYUNDAI ELANTRA. WHENEVER THE CONTACT SHIFTED INTO PARK, THE GEAR WOULD NEVER STICK. THE VEHICLE WOULD EITHER MOVE FORWARD FOR A FEW SECONDS BEFORE COMING TO A COMPLETE STOP. WHENEVER THE GEAR WAS IN DRIVE, THE VEHICLE WOULD JERK FORWARD. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE WOULD …
Read full complaint
TL*THE CONTACT OWNS A 2008 HYUNDAI ELANTRA. WHENEVER THE CONTACT SHIFTED INTO PARK, THE GEAR WOULD NEVER STICK. THE VEHICLE WOULD EITHER MOVE FORWARD FOR A FEW SECONDS BEFORE COMING TO A COMPLETE STOP. WHENEVER THE GEAR WAS IN DRIVE, THE VEHICLE WOULD JERK FORWARD. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE WOULD NOT MOVE OR WOULD SUDDENLY ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES FOR THESE FAILURES. DURING THE FIRST VISIT, THE MECHANIC REPLACED THE TRANSMISSION, WHICH CORRECTED THE ISSUE FOR LESS THAN FOUR MONTHS. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THEY STATED THAT THE SOLENOIDS WERE CAUSING THE FAILURES. THE DEALER REPLACED THE VALVE ASSEMBLY AND THE SOLENOIDS. THERE HAD BEEN NO FURTHER OCCURRENCES SINCE THE LAST REPAIR. THE CONTACT BELIEVES THAT A RECALL SHOULD BE ISSUED SINCE IT APPEARED TO BE A MANUFACTURER DEFECT. THE FAILURE MILEAGE WAS 8,918 AND CURRENT MILEAGE WAS 11,792. UPDATED 7/23/09 *CN THE CONSUMER ALSO STATED THERE WAS A SMELL OF GAS IN THE VEHICLE. UPDATED 07/30/09.*UB
NHTSA ODI #10275824
5,150 miles · May 19, 2009
Electrical SystemFuel System, Gasoline
ENGINE CUT OFF WITH FUEL GAUGE DROPPING TO 'EMPTY' [ WITH A 1/2 FULL TANK]. ON THE NYS THRUWAY ALMOST CAUSING A COLLISION WITH AN 18 WHEELER AS I COASTED ACROSS ITS PATH TO THE SHOULDER IN ROCKLAND COUNTY. CALLED AAA AND EVENTUALLY, [ABOUT 10 MIN. AFTER, WHILE STILL ON THE LINE WITH AAA, I HEARD A LIGHT CLICK AND THE FUEL GAUGE…
Read full complaint
ENGINE CUT OFF WITH FUEL GAUGE DROPPING TO 'EMPTY' [ WITH A 1/2 FULL TANK]. ON THE NYS THRUWAY ALMOST CAUSING A COLLISION WITH AN 18 WHEELER AS I COASTED ACROSS ITS PATH TO THE SHOULDER IN ROCKLAND COUNTY. CALLED AAA AND EVENTUALLY, [ABOUT 10 MIN. AFTER, WHILE STILL ON THE LINE WITH AAA, I HEARD A LIGHT CLICK AND THE FUEL GAUGE WENT BACK UP TO 1/2 TANK AND THE CAR ENGINE STARTED UP TO COMPLETE MY DRIVE HOME. *TR
NHTSA ODI #10269446
Mileage unknown · Jan 12, 2009
Fuel System, Gasoline
2008 HYUNDAI ELANTRA RECALL FOR FUEL PUMP MOTOR PROBLEM. CONSUMER STATES THAT THE DEALERSHIP IS HAVING A PROBLEM WITH GETTING THE PARTS FOR THE CAR. *NJ
NHTSA ODI #10254608
9,932 miles · Jan 6, 2009
Fuel System, Gasoline
2008 HYUNDAI ELANTRA WITH RECALL FOR THE FUEL PUMP. CONSUMER STATES THAT THE VEHICLE WAS LOOKED AT AND THE WORK WAS PERFORMED. AFTER THE WORK WAS PERFORMED THE VEHICLE STOPPED RUNNING WHILE DRIVING AND A SMELL OF GASOLINE FILLED THE CAR. *KB IT WAS DISCOVERED THAT THE FUEL LINE LEADING TO THE FUEL PUMP HAD COME LOOSE AND HAD F…
Read full complaint
2008 HYUNDAI ELANTRA WITH RECALL FOR THE FUEL PUMP. CONSUMER STATES THAT THE VEHICLE WAS LOOKED AT AND THE WORK WAS PERFORMED. AFTER THE WORK WAS PERFORMED THE VEHICLE STOPPED RUNNING WHILE DRIVING AND A SMELL OF GASOLINE FILLED THE CAR. *KB IT WAS DISCOVERED THAT THE FUEL LINE LEADING TO THE FUEL PUMP HAD COME LOOSE AND HAD FALLEN OFF THE CONNECTION POINT, WHICH WAS THE CAUSE OF THE FUEL LEAK AND THE VEHICLE STALLING. THE CONSUMER BELIEVED THE PROBLEM WAS RELATED TO THE RECALL WORK THAT WAS PERFORMED. *JB
NHTSA ODI #10254532
1,291 miles · Nov 13, 2008
Fuel System, GasolinePower Train
I PURCHASED MY 08 ELANTRA THIS SUMMER. DELIVERY DATE 07/05/08. COMPLAINT 1, "CUSTOMER STATES ENGINE WONT START". THE DEALERSHIP REPLACED FUEL PUMP TO CORRECT CONCERN. COMPLAINT 2, INCIDENT 1 INVOICE DATE 09/15/08. I BEGAN TO HAVE PROBLEMS WITH MY CLUTCH. VEHICLE WILL MAKE GRINDING NOISES GOING INTO REV, 1ST, AND 2ND GEAR. CLUTCH…
Read full complaint
I PURCHASED MY 08 ELANTRA THIS SUMMER. DELIVERY DATE 07/05/08. COMPLAINT 1, "CUSTOMER STATES ENGINE WONT START". THE DEALERSHIP REPLACED FUEL PUMP TO CORRECT CONCERN. COMPLAINT 2, INCIDENT 1 INVOICE DATE 09/15/08. I BEGAN TO HAVE PROBLEMS WITH MY CLUTCH. VEHICLE WILL MAKE GRINDING NOISES GOING INTO REV, 1ST, AND 2ND GEAR. CLUTCH WILL NOT ENGAGE PROPERLY. WILL STALL OUT WHEN VERY COLD OR RAINING. MAJOR PROBLEMS WHEN AT STOP LIGHTS RAILROAD CROSSINGS(STALLING OUT ON THE TRACKS) OR GOING UP AN INCLINE. AFTER SEVERAL ATTEMPTS TO "CORRECT MY CONCERN" THE DEALERSHIP AND ITS SERVICE SHOP HAVE YET TO "DUPLICATE" THE PROBLEM OR ANY TO BE EXACT. HOWEVER, MY SERVICE REPORT DATE 09/24/08 STATES "BUT DID FIND HARD TO GET INTO GEAR AT TIMES BLED HYDRAULIC SYSTEM AND CORRECTED CONCERN." AGAIN ON 10/08/08 DEALER STATED COULD NOT DUPLICATE PROBLEM BUT SERVICE INVOICE READS " CUST STATS IN AM TRANS IS HARD TO SHIFT INTO GEAR AND RPM GAGE WILL REV HIGH FOUND HARD SHIFT REPLACED TRANNY GEAR OIL TO CORRECT CONCERN" I TOOK THE CAR BACK ON 11/06/08 BECAUSE IT STILL HAS THE SAME PROBLEMS AND A FEW NEW ONES. I SPOKE TO THE OWNER OF THE DEALERSHIP WHO VERIFIED THAT THERE WAS A PROBLEM WITH THE CAR. LATER THAT DAY HE CALLED ME BACK AND TOLD ME IT WAS FINE. LIAR MUCH?I HAVE MY CAR BACK AGAIN TODAY 11/13/08 AND IT IS STILL GIVING ME PROBLEMS. THESE PROBLEMS CREATE A SERIOUS SAFETY HAZARD DUE TO THE FACT THAT IT STALLS OUT IN THE MIDDLE OF THE ROAD IN STOP AND GO TRAFFIC AND AT LIGHTS AND GIVES OFF A WEIRD SMELL LIKE A BURNED CIRCUIT AFTER I GO UPHILL FOR TOO LONG, KEEP IN MIND I'M NOT DRIVING MY CAR INTO THE GROUND. I TOOK A TEST DRIVE WITH THE SERVICE MANAGER TODAY, THE CAR WAS GIVING ME TROUBLE RIGHT IN FRONT OF HIM AND HE CLAIMS THAT I WAS RIDING THE CLUTCH. I EXPLAINED TO HIM THAT I NEEDED TO DEPRESS THE CLUTCH PEDAL TO KEEP THE CAR FROM STALLING OUT BUT HE IGNORED ME. I'LL BE GOING BACK ON THE 15TH TO SPEAK TO THE OWNER AGAIN. *TR
NHTSA ODI #10248728
Official recalls
7Feb 4, 2020
Hyundai Motor America (Hyundai) is recalling certain 2007-2010 Elantra and 2009-2011 Elantra Touring vehicles. On February 21, 2020 Hyundai expanded the recall to include 46,425 model year 2007-2008 Entourage and 2007 Santa Fe vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence & remedy
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.
Remedy: Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began April 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 188.
Feb 23, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2008-2010 Elantra vehicles manufactured June 1, 2008, to April 30, 2010, and 2009-2010 Elantra Touring vehicles manufactured November 1, 2008, to April 30, 2010. The electronic power steering (EPS) electronic control unit (ECU) may sense a discrepancy in the steering input signals and, as a result, disable the steering power assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Hyundai will verify the proper operation of the Electronic Power Steering (EPS) and update the EPS control unit, free of charge. The recall began April 14, 2015. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 127.
Apr 1, 2013
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Mar 15, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2009 ELANTRA VEHICLES MANUFACTURED FROM JULY 14, 2006, THROUGH NOVEMBER 1, 2008. THE FRONT PASSENGER SEATS IN THE VEHICLES CONTAIN A WEIGHT SENSOR DESIGNED TO DEACTIVATE THE RIGHT FRONTAL AIRBAG WHEN OCCUPANTS OF CERTAIN WEIGHTS OCCUPY THE SEAT. THE ELECTRICAL CONNECTOR FOR THE WEIGHT SENSOR IS LOCATED UNDER THE CENTER CONSOLE, BETWEEN THE FRONT SEATS. UNDER CERTAIN CIRCUMSTANCES THE CONNECTOR COULD BECOME CONTAMINATED AND MALFUNCTION SUCH THAT THE FRONT PASSENGER AIRBAG WILL DEPLOY REGARDLESS OF THE WEIGHT OF THE OCCUPANT.
Consequence & remedy
Consequence: THE FRONT PASSENGER AIR BAG COULD DEPLOY IN CRASHES IN WHICH IT SHOULD NOT DEPLOY, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT FROM THE DEPLOYED AIR BAG.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE WEIGHT CLASSIFICATION SYSTEM CONNECTOR TO PREVENT CONTAMINATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTING TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Mar 15, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2008 ELANTRA VEHICLES MANUFACTURED FROM JULY 14, 2006, THROUGH AUGUST 29, 2007. THE DRIVER'S SEAT TRACK POSITION SENSOR DETERMINES THE SEAT'S FORE AND AFT POSITION AND ALLOWS THE DRIVER'S FRONTAL AIR BAG TO DEPLOY AT THE PRESSURE APPROPRIATE FOR THAT SEATING POSITION, WITH A LOWER PRESSURE DEPLOYMENT IN THE MOST FORWARD SEATING POSITIONS. THE AIR BAG CONTROL MODULE MAY RECEIVE AN UNSTABLE ELECTRICAL SIGNAL FROM THE SEAT TRACK POSITION SENSOR SUCH THAT, IN A CRASH THAT REQUIRES DRIVER FRONTAL AIRBAG DEPLOYMENT, THE DRIVER'S AIRBAG MAY DEPLOY AT THE HIGHER PRESSURE THAN INTENDED IF THE SEAT WAS POSITION IN ONE OF THE FORWARD POSITIONS IN WHICH A LOWER PRESSURE DEPLOYMENT IS INTENDED.
Consequence & remedy
Consequence: A HIGHER PRESSURE DEPLOYMENT THAN INTENDED INCREASES THE RISK OF INJURY RESULTING FROM AIRBAG DEPLOYMENT.
Remedy: DEALERS WILL REPROGRAM THE AIR BAG CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTING TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Dec 29, 2008
HYUNDAI DE PUERTO RICO (HPR) IS RECALLING 347 MY 2008 ELANTRA VEHICLES. THE FUEL PUMP MOTOR MAY NOT HAVE THE PROPER, UNIFORM INTERNAL ELECTRICAL SURFACE CONTACT. THIS MAY CAUSE THE FUEL PUMP TO PRODUCE LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM.
Consequence & remedy
Consequence: AS A RESULT, POOR ENGINE STARING AND HESITATION MAY RESULT. OTHER ENGINE PERFORMANCE ISSUES MAY ALSO RESULT AND LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE VEHICLE'S FUEL PUMP SUBASSEMBLY. THE RECALL BEGAN ON FEBRUARY 9, 2009. OWNERS MAY CONTACT HPR AT 1-800-981-0188.
Aug 25, 2008
HYUNDAI IS RECALLING 65,000 MY 2008 ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES. THE FUEL PUMP MOTOR MAY NOT HAVE THE PROPER UNIFORM INTERNAL ELECTRICAL SURFACE CONTACT. THIS MAY CAUSE THE FUEL PUMP TO PRODUCE LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM.
Consequence & remedy
Consequence: POOR ENGINE STARTING AND HESITATION MAY RESULT. OTHER ENGINE PERFORMANCE ISSUES MAY ALSO RESULT INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP SUBASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
PE08044 · Engine Stalling - Fuel Pump Failure
Opened Jul 17, 2008 · Closed Sep 3, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:fuel Pump
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Fuel System, Gasoline
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Illustration