IllustrationUNKNOWN the cars transmission after running for a bit feels like it slips out and will not lock in and shift, leading to higher rpm I run at 2500 to go 45 miles per hour, I also only get 4.3 miles per gallon it says on the dash.
2007 Hyundai Elantra
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Hyundai Elantra do not stand out strongly from the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Elantra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
3325–50K
4850–75K
4175–100K
49100–150K
20150K+
222 reports with mileage · 44 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility/wiper. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
21 crash reports13 fire reports16 injury reports
Vehicle Speed Control complaints
9 reportsOn 2/3/2023 I started my vehicle like normal drove approximately 2 miles to the store , during the drive my the vehicle was accelerating uncontrollably, more than I was driving normally. I then hit the brakes and it did slow down . Upon arriving to my destination I then tried to park my vehicle and applied the brakes and my vehi…
Read full complaint
On 2/3/2023 I started my vehicle like normal drove approximately 2 miles to the store , during the drive my the vehicle was accelerating uncontrollably, more than I was driving normally. I then hit the brakes and it did slow down . Upon arriving to my destination I then tried to park my vehicle and applied the brakes and my vehicle kept accelerating and moving I then placed the car in reverse which stopped the motion. I then placed the car back in drive and went home . Then car still was accelerating uncontrollably so I kept my hand over the emergency brake for emergency use if needed . Upon arriving home the engine light came on
WAS DRIVING VERY SLOWLY ON COLLEGE CAMPUS LOOKING FOR PARKING SPACE AS I HAVE DONE EVERY TIME I GO TO THE OFFICE FOR 45 YEARS WHEN SUDDENLY THE HYUNDAI ELANTRA ACCELERATED AT VERY HIGH RATE AND ROLLED OVER UPSIDE DOWN. AIRBAGS DEPLOYED AND I WAS RUSHED TO THE HOSPITAL. WINDSHIELD AND FRONT OF ROOF COLLAPSED FROM ROLLOVER! I ABSO…
Read full complaint
WAS DRIVING VERY SLOWLY ON COLLEGE CAMPUS LOOKING FOR PARKING SPACE AS I HAVE DONE EVERY TIME I GO TO THE OFFICE FOR 45 YEARS WHEN SUDDENLY THE HYUNDAI ELANTRA ACCELERATED AT VERY HIGH RATE AND ROLLED OVER UPSIDE DOWN. AIRBAGS DEPLOYED AND I WAS RUSHED TO THE HOSPITAL. WINDSHIELD AND FRONT OF ROOF COLLAPSED FROM ROLLOVER! I ABSOLUTELY DID NOT PRESS DOWN THE GAS PEDAL BY MISTAKE. I AM SURE. THIS COULD VERY LIKELY KILLED ANYONE WALKING OR DRIVING IN FRONT OF THIS CRAZY CAR.
TL* THE CONTACT OWNS A 2007 HYUNDAI ELANTRA. WHILE DRIVING 5 MPH, THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 160,000.
TL* THE CONTACT OWNS A 2007 HYUNDAI ELANTRA. THE CONTACT STATED THAT WHILE ATTEMPTING TO MERGE INTO TRAFFIC, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING. THE CONTACT MENTIONED THAT THE VEHICLE ACCELERATED TO 80 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC HOWEVER, THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2007 HYUNDAI ELANTRA. THE CONTACT STATED THAT WHILE ATTEMPTING TO MERGE INTO TRAFFIC, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING. THE CONTACT MENTIONED THAT THE VEHICLE ACCELERATED TO 80 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC HOWEVER, THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 104,000.
ON THE MORNING OF JUNE 23, 2012, I WAS PARKING MY 2007 HYUNDAI ELANTRA IN A SHOPPING CENTER PARKING LOT. I PULLED INTO A PARKING SPACE AND PRESSED THE BRAKE PEDAL TO STOP, AS USUAL, AND FELT THE CAR SLOWING DOWN AT FIRST; BUT THEN, JUST AS I WAS COMING TO A COMPLETE STOP, THE ENGINE SUDDENLY GOT REALLY LOUD AND THE CAR VIOLENTLY…
Read full complaint
ON THE MORNING OF JUNE 23, 2012, I WAS PARKING MY 2007 HYUNDAI ELANTRA IN A SHOPPING CENTER PARKING LOT. I PULLED INTO A PARKING SPACE AND PRESSED THE BRAKE PEDAL TO STOP, AS USUAL, AND FELT THE CAR SLOWING DOWN AT FIRST; BUT THEN, JUST AS I WAS COMING TO A COMPLETE STOP, THE ENGINE SUDDENLY GOT REALLY LOUD AND THE CAR VIOLENTLY LURCHED FORWARD VERY FAST. IT JUMPED OVER THE PARKING STOP, THEN COLLIDED WITH A 2-FOOT HIGH CONCRETE WALL THAT WAS ONLY ABOUT 18" OR SO PAST THE PARKING STOP (IT WAS A BARRIER SEPARATING THAT PARKING LOT FROM AN ADJACENT ONE). LUCKILY FOR ME, THE AIR BAG DEPLOYED AND SO I ONLY HAD A FEW BRUISES. THE CAR WAS DECLARED A TOTAL LOSS. EVEN THOUGH IT'S TOO LATE FOR MY CAR, I REALLY WISH HYUNDAI WOULD DO SOMETHING ABOUT THIS PROBLEM BEFORE PEOPLE GET HURT. SINCE I WAS IN A SHOPPING CENTER PARKING LOT, IF THAT CONCRETE BARRIER HAD NOT BEEN THERE TO STOP MY CAR, IT COULD HAVE ENDED UP MUCH WORSE - I COULD HAVE CRASHED INTO OTHER VEHICLES OR EVEN HIT A PEDESTRIAN. IT REALLY SCARES ME WHEN I THINK ABOUT WHAT COULD HAVE HAPPENED. *TR
HYUNDAI DIDN'T FULLY ASSESS RECALL ID # 09V122000 ON THE BRAKE STOP LIGHT. MINE HAS MALFUNCTIONED TWICE IN 1.5 YEARS, YET THEY ARE NOW TELLING ME THAT I AM NOT A PART OF THE RECALL. THIS IS A VERY SERIOUS ISSUE THAT CAN ALSO INVOLVE THE CRUISE CONTROL NOT STOPPING, SHIFTING PROBLEMS, AND A POSSIBLE REAR-END ACCIDENT. THIS NE…
Read full complaint
HYUNDAI DIDN'T FULLY ASSESS RECALL ID # 09V122000 ON THE BRAKE STOP LIGHT. MINE HAS MALFUNCTIONED TWICE IN 1.5 YEARS, YET THEY ARE NOW TELLING ME THAT I AM NOT A PART OF THE RECALL. THIS IS A VERY SERIOUS ISSUE THAT CAN ALSO INVOLVE THE CRUISE CONTROL NOT STOPPING, SHIFTING PROBLEMS, AND A POSSIBLE REAR-END ACCIDENT. THIS NEEDS TO BE LOOKED IN TO - MORE PEOPLE THAN ORIGINALLY ESTIMATED CAN BE AT SERIOUS RISK - NOT TO MENTION MORE PEOPLE ARE PAYING TO HAVING THIS FIXED BY THEIR DEALER (I.E. ME) THAN THERE SHOULD BE! *TR
I REARENDED SOMEONE IN MAY DESPITE THE FACT THAT I WAS COMPLETELY STOPPED. I HAD MY FOOT COMPLETELY DEPRESSED ON THE BRAKE AND STOPPED AT A LIGHT, BUT STILL, MY CAR HIT THE CAR INFRONT OF ME WITH INCREDIBLE FORCE. I THOUGHT THAT I WAS HIT FROM BEHIND AND PUSHED INTO THIS CAR BUT WHEN WE PULLED INTO THE PARKING LOT, THERE WERE …
Read full complaint
I REARENDED SOMEONE IN MAY DESPITE THE FACT THAT I WAS COMPLETELY STOPPED. I HAD MY FOOT COMPLETELY DEPRESSED ON THE BRAKE AND STOPPED AT A LIGHT, BUT STILL, MY CAR HIT THE CAR INFRONT OF ME WITH INCREDIBLE FORCE. I THOUGHT THAT I WAS HIT FROM BEHIND AND PUSHED INTO THIS CAR BUT WHEN WE PULLED INTO THE PARKING LOT, THERE WERE NO SCRATCHES OR ANYTHING ON THE BACK OF MY CAR. IT CAME DOWN TO BEING MY FAULT SINCE THERE WAS NO-ONE ELSE AND I COULDN'T PROVE THAT MY FOOT WAS ON THE BRAKE. THEN, TODAY, AS I WAS REACHING DOWN TO PUT MY CAR IN PARK, IN A PARKING LOT WHERE I WAS, AGAIN, COMPLETELY STOPPED, MY CAR REPEATED THE FORCEFUL THRUST FORWARD. THIS TIME THERE WAS NO CAR INFRONT OF ME, THANK GOODNESS, BUT MY CAR HIT AND BOUNCED OFF OF THE CONCRETE CURB IN THE PARKING LOT RESULTING IN ME GETTING A HEADACHE FROM THE FORCE. AGAIN, I WAS COMPLETELY STOPPED AND MY CAR LURCHED FORWARD LIKE I WAS REARENDED. I KNOW THAT THE INCIDENT IN MAY WAS NOT BECAUSE I HAD TAKEN MY FOOT OFF THE BRAKE BUT THAT THERE IS SOMETHING WRONG WITH MY CAR AND NOW THAT IT'S HAPPENED AGAIN, I KNOW I'M RIGHT. ONCE, IT HAPPENED TO HAPPEN WHEN I WAS BEHIND A CAR AND THEN TODAY IT HAPPENED WHEN I WAS IN A PARKING LOT, BUT I'M SCARED OF WHAT MAY HAPPEN IF THERE IS SOMEONE ELSE INFRONT OF ME. I TOOK IT TO THE DEALERSHIP BUT THEY COULDN'T FIND ANYTHING WRONG WITH IT. I DON'T WANT ANYONE TO GET HURT BECAUSE OF THIS FAULTY CAR, SO THIS IS MY LAST HOPE OF GETTING SOMEONE TO FIND OUT WHAT THE PROBLEM IS. IT HAS ONLY HAPPENED TWICE IN A YEAR AND A HALF BUT I DON'T KNOW WHEN THE NEXT TIME WILL BE AND I DON'T WANT ANYONE TO GET HURT FROM IT. *TR
TL*THE CONTACT HAD A 2007 HYUNDAI ELANTRA RENTAL. WHILE PULLING INTO A PARKING SPACE, THE VEHICLE ACCELERATED ON ITS OWN. THE CONTACT CRASHED INTO A POLE AND TWO OTHER VEHICLES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED AND IS NOW IN THE POSSESSION OF AVIS CAR RENTAL. THE CURRENT AND FAILURE MILEAGES WERE 20,000. U…
Read full complaint
TL*THE CONTACT HAD A 2007 HYUNDAI ELANTRA RENTAL. WHILE PULLING INTO A PARKING SPACE, THE VEHICLE ACCELERATED ON ITS OWN. THE CONTACT CRASHED INTO A POLE AND TWO OTHER VEHICLES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED AND IS NOW IN THE POSSESSION OF AVIS CAR RENTAL. THE CURRENT AND FAILURE MILEAGES WERE 20,000. UPDATED 08/14/07. *JB
Official recalls
620V061000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Feb 4, 2020
Hyundai Motor America (Hyundai) is recalling certain 2007-2010 Elantra and 2009-2011 Elantra Touring vehicles. On February 21, 2020 Hyundai expanded the recall to include 46,425 model year 2007-2008 Entourage and 2007 Santa Fe vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence & remedy
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.
Remedy: Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began April 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 188.
13V113000 · Exterior Lighting:brake Lights:switch
Apr 1, 2013
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
11V143000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Mar 15, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2009 ELANTRA VEHICLES MANUFACTURED FROM JULY 14, 2006, THROUGH NOVEMBER 1, 2008. THE FRONT PASSENGER SEATS IN THE VEHICLES CONTAIN A WEIGHT SENSOR DESIGNED TO DEACTIVATE THE RIGHT FRONTAL AIRBAG WHEN OCCUPANTS OF CERTAIN WEIGHTS OCCUPY THE SEAT. THE ELECTRICAL CONNECTOR FOR THE WEIGHT SENSOR IS LOCATED UNDER THE CENTER CONSOLE, BETWEEN THE FRONT SEATS. UNDER CERTAIN CIRCUMSTANCES THE CONNECTOR COULD BECOME CONTAMINATED AND MALFUNCTION SUCH THAT THE FRONT PASSENGER AIRBAG WILL DEPLOY REGARDLESS OF THE WEIGHT OF THE OCCUPANT.
Consequence & remedy
Consequence: THE FRONT PASSENGER AIR BAG COULD DEPLOY IN CRASHES IN WHICH IT SHOULD NOT DEPLOY, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT FROM THE DEPLOYED AIR BAG.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE WEIGHT CLASSIFICATION SYSTEM CONNECTOR TO PREVENT CONTAMINATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTING TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
11V179000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Mar 15, 2011
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2008 ELANTRA VEHICLES MANUFACTURED FROM JULY 14, 2006, THROUGH AUGUST 29, 2007. THE DRIVER'S SEAT TRACK POSITION SENSOR DETERMINES THE SEAT'S FORE AND AFT POSITION AND ALLOWS THE DRIVER'S FRONTAL AIR BAG TO DEPLOY AT THE PRESSURE APPROPRIATE FOR THAT SEATING POSITION, WITH A LOWER PRESSURE DEPLOYMENT IN THE MOST FORWARD SEATING POSITIONS. THE AIR BAG CONTROL MODULE MAY RECEIVE AN UNSTABLE ELECTRICAL SIGNAL FROM THE SEAT TRACK POSITION SENSOR SUCH THAT, IN A CRASH THAT REQUIRES DRIVER FRONTAL AIRBAG DEPLOYMENT, THE DRIVER'S AIRBAG MAY DEPLOY AT THE HIGHER PRESSURE THAN INTENDED IF THE SEAT WAS POSITION IN ONE OF THE FORWARD POSITIONS IN WHICH A LOWER PRESSURE DEPLOYMENT IS INTENDED.
Consequence & remedy
Consequence: A HIGHER PRESSURE DEPLOYMENT THAN INTENDED INCREASES THE RISK OF INJURY RESULTING FROM AIRBAG DEPLOYMENT.
Remedy: DEALERS WILL REPROGRAM THE AIR BAG CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTING TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT HYUNDAI'S CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
09V280000 · Exterior Lighting
Jul 21, 2009
HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A DEFECTIVE STOP LAMP SWITCH MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION WOULD NOT BE ABLE TO BE SHIFT OUT OF THE "PARK" POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: ANY OF THESE MALFUNCTIONS COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 2, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO CUSTOMER SERVICE AT 1-787-999-4310.
09V122000 · Exterior Lighting:brake Lights:switch
Apr 15, 2009
HYUNDAI IS RECALLING 532,633 MY 2006-2007 ACCENT, ENTOURAGE, SONATA, MY 2007 AZERA, ELANTRA AND SANTA FE, MY 2005-2007 TUCSON AND MY 2007-2008 VERACRUZ VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
PE09003 · Stop Lamp Switch Failure
Opened Jan 14, 2009 · Closed Apr 24, 2009
Status: closed (inferred from source dates) · Electronic Stability Control; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Power Train:automatic Transmission:lever And Linkage:column Shift; Power Train:automatic Transmission:lever And Linkage:floor Shift; Power Train:manual Transmission:column Shift Assembly; Power Train:manual Transmission:floor Shift Assembly; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:pedals And Linkages; Vehicle Speed Control:cruise Control
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (10)
Electronic Stability Control
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights:switch
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:automatic Transmission:lever And Linkage:column Shift
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:automatic Transmission:lever And Linkage:floor Shift
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:manual Transmission:column Shift Assembly
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:manual Transmission:floor Shift Assembly
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Service Brakes, Hydraulic:pedals And Linkages
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Vehicle Speed Control:cruise Control
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
PE08044 · Engine Stalling - Fuel Pump Failure
Opened Jul 17, 2008 · Closed Sep 3, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:fuel Pump
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.
Fuel System, Gasoline
ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-429, HYUNDAI CAMPAIGN 086).THE RECALLED VEHICLES ARE EQUIPPED WITH FUEL PUMPS MANUFACTURED WITH UPPER BODY COMPONENTS FROM A DIFFERENT SUPPLIER THAN THOSE MANUFACTURED PRIOR TO NOVEMBER 5, 2007.ACCORDING TO HYUNDAI, THE NEW SUPPLIER'S UPPER BODY COMPONENTS HAD INCORRECT DIMENSIONAL CHARACTERISTICS RESULTING IN MISALIGNMENT OF THE ARMATURE SHAFT, WHICH CAUSED SOME OF THE FUEL PUMPS TO EXPERIENCE POOR BRUSH-TO-COMMENTATOR CONTACT CONDITIONS THAT COULD RESULT IN ENGINE STALL. THE USE OF ETHANOL BLEND FUEL, CONTAINING UP TO 10 PERCENT ETHANOL, CAUSES A FILM BUILD-UP THAT CREATES HIGH RESISTANCE BETWEEN THE BRUSH AND COMMUTATOR.THE MISALIGNED ARMATURE SHAFT PREVENTS THE BRUSH AND COMMUTATOR FROM MAKING SUFFICIENT CONTACT TO OVERCOME THE HIGH RESISTANCE FILM BUILD-UP, THEREFORE PRODUCING LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM. SIXTY-FOUR OF THE COMPLAINTS (72%), INCLUDING THE CRASH AND INJURY ALLEGATION, INVOLVE THE RECALLED VEHICLES.THE COMPLAINT RATE IN THE SUBJECT VEHICLE POPULATION IS 98.5 PER 100,000 VEHICLES, COMPARED WITH 21.4 IN THE REMAINING POPULATION, WHICH HAS ON AVERAGE BEEN IN SERVICE OVER A YEAR LONGER.THE WARRANTY CLAIM RATE IS ALSO SIGNIFICANTLY HIGHER IN THE RECALLED VEHICLES, WHICH HAD 569 CLAIMS (0.9 PERCENT CLAIM RATE) COMPARED WITH 126 CLAIMS IN THE REMAINING POPULATION (0.1 PERCENT CLAIM RATE). HYUNDAI WILL REPLACE THE FUEL PUMP SUBASSEMBLIES IN THE RECALLED VEHICLES FREE OF CHARGE.THIS PRELIMINARY EVALUATION IS CLOSED WITH HYUNDAI'S RECALL.